BMW X3 Complaints

271 consumer complaints on file.

#11735435May 4, 2026
Insert, Padding, Chest Clip, Buckle, Harness
[XXX] old infant's face was cut and bleeding from the Chicco Fit360 ClearTex Rotating Car Seat's safety straps with included pads INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11734760April 30, 2026
UNKNOWN OR OTHER
While driving, my sunroof spontaneously exploded/shattered and rained glass onto me while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734078April 27, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734038April 27, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732613April 21, 2026
ENGINE
The engine oil pump has an internal plastic housing that can fail and will cause oil pressure variations and even low pressure which can lead to engine failure. This has been documented for a while on various b58tu engines. This a very costly repair that can easily be 5000-6000 usd. Failure of the said part can also render that vehicle unable to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730851April 13, 2026
VISIBILITY/WIPER
This car was purchased new from an authorized dealer. After about 3 months of operation, I noticed a crack in the windshield starting at the upper edge of the passenger side of the vehicle. The crack has since spread approx. halfway across the windshield. I'm concerned that this will continue until the windshield fails. I took it to the dealer who agreed that it didn't appear to have been struck by a rock or anything else, but the dealership has refused to take responsibility. I looked up possible recalls on this issue and discovered that BMW has recalled other similar models for this problem, but not this model. I believe that this is an issue that should result in a recall and subsequent replacement of the windshield and I wanted to make the NHTSA aware of it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730794April 13, 2026
ENGINE, STEERING
Vehicle is experiencing critical mounting component failure very early on. Vehicle has under 50k miles but the engine mounts and thrush rod bushings are failing, putting the car at risk when driving or starting. It has been inspected by the dealership and the manufacturer has confirmed that the issue exists.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730231April 9, 2026
ENGINE
2021 BMW X3 M40i – Starter Motor Failure Matches NHTSA 26V056000 Defect (No-Start at Stop Light + Excessive Starter Torque Fault + Fire Risk) I am filing this safety complaint regarding a sudden starter motor failure on my 2021 BMW X3 M40i. On March 31, 2026, the vehicle stalled at a stop light and displayed the message “car can be restarted in XX seconds.” After the timed period elapsed and a few restart attempts, the vehicle would not start and had to be towed to Sewell BMW Mini of Plano, Texas. The service department at the dealership diagnosed a faulty starter motor. The technician’s notes explicitly state: “checked faults for excessive torque and found starter motor faulty” and the vehicle inspection video shows the starter unraveling. They quoted $2,060.50 to replace it under reliability concerns. This failure mode - sudden no-start at idle/stop with the timed restart lockout and “excessive torque” fault - is identical to the defect in NHTSA Campaign 26V056000 announced January 2026, affecting 2021–2024 X3 models. That recall describes internal starter wear causing no-start conditions and potential overheating/fire risk. BMW has already acknowledged and is replacing the starter for free on thousands of nearly identical G01 X3s. The service manager at Sewell BMW of Plano also confirmed that prior B58-engine X3 M40i models, same engine family as mine, have had starter recalls for the same issue. Despite this clear precedent, BMW North America denied our goodwill request for coverage due to it being out of warranty and that we’re not the original owners of the vehicle. We believe this is a safety defect that BMW should remedy at no cost, consistent with federal standards and their handling of the identical issue on other X3 models. Please investigate and require BMW to provide free remedy or full reimbursement. This poses a real safety risk due to a sudden stall while driving and potential fire as demonstrated in other recalled BMW X3s within the same year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730111April 9, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729361April 6, 2026
POWER TRAIN
I am reporting a potential safety defect in BMW vehicles equipped with the B58TU engine, primarily model years 2019–2021. These vehicles use an oil pump containing an internal plastic component responsible for regulating oil pressure. This component has been reported to fracture in service, resulting in sudden and complete loss of oil pressure. Failures commonly occur during cold starts in low ambient temperatures. When the component fails, oil pressure may become erratic or drop to zero with little or no advance warning. In some cases, drivers may observe warning signs such as inability to measure engine oil level electronically, abnormal oil pressure behavior, or drivetrain malfunction warnings. These conditions can rapidly escalate to engine shutdown or severe engine damage due to oil starvation. This defect presents a significant safety risk, as vehicles may become disabled unexpectedly while driving or shortly after startup. Sudden loss of propulsion increases the risk of traffic incidents, particularly if the vehicle becomes immobilized in active traffic lanes. The risk is heightened in winter conditions, when failures are more likely and occupants may be exposed to freezing temperatures while awaiting assistance. Repair typically requires extensive engine disassembly, with costs ranging from approximately $6,000 to $8,000, excluding potential engine damage. A key concern is that owners cannot reliably determine whether their vehicle is equipped with the original plastic component or a revised metal version. BMW’s VIN-based parts systems now reflect updated components even if the original part remains installed, and the original plastic component is no longer listed in dealer parts catalogs. Reports indicate failures across multiple production years, and the full scope of affected vehicles is unclear. Given the potential for sudden vehicle disablement without adequate warning, this issue warrants investigation as a safety-related defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728646April 1, 2026
VISIBILITY:WINDSHIELD
The contact owns a 2024 BMW X3. The contact stated that while driving at an undisclosed speed, the windshield unexpectedly cracked on several occasions without impact. The contact stated that the crack originated at the top of the windshield and extended approximately six inches toward the driver’s side. The vehicle was taken to the dealer, but was not inspected. The dealer ordered replacement windshields several times. The contact stated that after the windshield was replaced, the failure recurred. The manufacturer was made aware of the failure. The approximate failure mileage was 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727845March 29, 2026
STEERING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: ASSIST
While actively driving at speed this loaner vehicle, the vehicle's Driving Assistance Professional Package (DAPP) completely deactivated without warning. This caused an immediate, unexpected loss of both adaptive cruise control and active lane-keeping steering assistance, requiring sudden manual emergency intervention to maintain control of the vehicle and avoid a collision. This is a severe safety defect. The vehicle has been presented to an authorized BMW dealership twice for this exact failure. It is currently on its second repair attempt and has been out of service for over 20 consecutive days. The dealership and manufacturer have been unable to permanently resolve my personal vehicle this electronic/steering system malfunction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727843March 29, 2026
STEERING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: ASSIST
While actively driving at speed, the vehicle's Driving Assistance Professional Package (DAPP) completely deactivated without warning. This caused an immediate, unexpected loss of both adaptive cruise control and active lane-keeping steering assistance, requiring sudden manual emergency intervention to maintain control of the vehicle and avoid a collision. This is a severe safety defect. The vehicle has been presented to an authorized BMW dealership twice for this exact failure. It is currently on its second repair attempt and has been out of service for about 30 consecutive days. It is stilll in the shop. The dealership and manufacturer have been unable to permanently resolve this electronic/steering system malfunction. Additionally, they gave me another 2025 BMW X3 VIN [XXX] which experienced the same problem yesterday 3/28/2026 while I was driving about 35 miles per hour on the freeway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726141March 22, 2026
ENGINE, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Car spontaneously caught on fire. Total loss. Drove car home from haircut appointment 5 to 10 minutes away. Parked car as normal and went inside. Within approximately 5 minutes loud knock on door “Your car is on fire!” I came out of my home and saw my car in driveway with fire erupting from engine area onto windshield, and through hole in middle of hood. Took a few seconds of video, then ran into house for large fire extinguisher. Emptied fire extinguisher contents into hole of hood and into fire area coming out from engine area onto windshield.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11725100March 17, 2026
POWER TRAIN, ELECTRICAL SYSTEM, ENGINE
My vehicle is subject to an active safety recall (NHTSA #25V-636) issued in September 2025 involving the engine starter. As of today, no remedy has been provided by the manufacturer. Due to the safety risk associated with this recall, I do not feel safe operating the vehicle and have been forced to keep it parked and unused for an extended period of time. This has caused significant financial hardship, as I am still required to make monthly loan payments, maintain insurance, and cover related expenses for a vehicle that is unsafe to drive. The issue has effectively rendered the vehicle unusable. The manufacturer has failed to provide a repair, replacement, or timeline for resolution. This situation places my safety and the safety of others at risk, as the vehicle may fail to start or function properly without warning. I am requesting immediate action, as this delay is unreasonable and creates both a safety hazard and financial burden.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725049March 17, 2026
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2022 BMW X3. The contact stated that while driving and stopping at a red light or stop sign, the vehicle accelerated from 20 MPH to 40 MPH. There was no warning light illuminated. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 34,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724957March 17, 2026
POWER TRAIN, STEERING, ELECTRICAL SYSTEM
On Feb. 25th, 2026, while driving at high speeds (about 45 mph), the vehicle suffered a sudden and total loss of motive power. Diagnostic reports(DIACODE: D6121_00000000_01_901) later confirmed a failing 12V battery system with only 37% startability limit. This critical electrical failure coincided with the engine stalling, which resulted in the immediate impairment of electronic power steering and brake assist. This made the vehicle extremely difficult to control safely, creating a life-threatening emergency. Despite being a 2025 model with only ~11000 miles, the dealership has failed to provide 48B system diagnostic and root cause upon request and the vehicle has been out of service for over 20 days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723646March 11, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted several times about the recall and confirmed that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721588March 2, 2026
SERVICE BRAKES
on [XXX] I was going into a Parking Garage in Beverly Hills, CA. I got a little too far from the ticket machine so I put the BMWX3 in PARK and PUT the Emergency Brake on so I could open my door, step out and grab the ticket. The car immediately rolled backwards into a Dodge Charger behind me. That woman is suing for $150,000. It caused my insurance to double, I had to have PT on my pelvis. I had to pay the deductible to get the car repaired. BMW will not take responsibility for the malfunction. My Dad was a professional driver for FORD and I have never caused an accident in my [XXX] years of driving. The woman claims that she and her children were injured but no air bags deployed. the car rolled. It did give me quite a jolt. Her car showed no visible damage but mine was damaged - tail pipe and bumper. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11721165February 28, 2026
VISIBILITY/WIPER
We purchased this vehicle new. It has less than 3,000 miles on it. A crack has developed in the windshield, starting in the upper corner on the passenger side and extending approximately 18 inches diagonally across the windshield. There is no evidence of an impact on the windshield by a rock or other road debris. It appears to be a defect in the glass itself or the method of installation. I believe that this issue is worthy of investigation by the NHTSA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW X3