Toyota · Model Report
Showing safety data for the 2020 model year only.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
The "airbag malfunction" light keeps coming on and off warning that there's something wrong with the airbags or the system itself. It's actually for something they have recalls for but my VIN number doesn't show up for the recall. It says "SRS airbag system malfunction".
No injuries · No fire · No crash
While fixing another problem, I pulled the codes from the ECM and found several P0087 (low fuel rail pressure). The problem was apparently intermittent and if the engine service light came on, it was transient and the light cleared. So neither my wife or I noticed an engine service light. I did some research and found that Denso found and reported a problem with the in tank fuel pump design to the NTSB in Feb. of 2020. We purchased the Camry in Dec. 2019 which meant we had the defective fuel pump. I ordered a new Denso fuel pump and install it and no new codes have appeared in the ECM log. Apparently Toyota has been slowly adding more years to the recall, but hasn't yet added the 2020 model year. This is a problem since a number of people have reported engine stalls due to the defective fuel pump. We live in the mountains, that might have been very dangerous especially if my wife suddenly lost power brakes and steering on a mountain road. Why hasn't a recall been ordered for this pump on all effected years?
No injuries · No fire · No crash
My car sputters and dies while driving. It looses power when I push the gas to take my turn at a light or intersection. The emergency brake has come on multiple times with no one in front of me. These have all occurred multiple times since mid 2021
No injuries · No fire · No crash
The transmission is premature wearing due to excessive heat causing pump to overheat
No injuries · No fire · No crash
2020 Toyota Camry XSE, VIN [XXX], 2.5L 4-cylinder A25A-FKS engine, built at Toyota Motor Manufacturing Kentucky (TMMK) during the production window covered by NHTSA Recall 20V-064 (Toyota campaign 20TA04), which addresses porosity in engine castings that can cause internal and external coolant leaks, engine overheating, and possible engine failure. Toyota’s VIN lookup returns this vehicle as not affected by the campaign, but the failure pattern matches the recall defect exactly. Timeline of failures and repair attempts: XXX, at approximately 92,832 miles, Camelback Toyota in Phoenix, AZ (RO XXX). Check engine light active. Diagnosed DTC P268115 (Engine Coolant Bypass Valve Circuit, Short to Battery or Open). Battery also failed load test. Overheating symptom noted on the same repair order. Coolant bypass valve replacement recommended. Following that visit, water pump and thermostat were replaced at Berge Toyota (Mesa/Gilbert, AZ area). Camelback Toyota stated the vehicle was fixed. Vehicle overheated again the next day after being returned as repaired. XXX, at 93,034 miles, Camelback Toyota (RO XXX). Oil and filter change performed under good faith goodwill service, transmission fluid exchange completed. Overheating condition persisted. Vehicle continued to overheat through the summer and into September 2026. Current dealer now recommends head gasket replacement and states that if the head gasket does not resolve the overheating, the engine block is cracked and the engine will need replacement. Dealer describes the engine as “sucking air,” indicating combustion gases entering the cooling system and/or a compromised block-to-head seal. This failure sequence — persistent overheating, multiple failed repair attempts across two Toyota dealers, replacement of water pump, thermostat, and coolant bypass valve without resolution, and dealer conclusion pointing to a cracked engine block — matches the failure mode described in NHTSA Rec INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)
No injuries · No fire · No crash