Lincoln Navigator Service Bulletins (2024)
94 manufacturer communications on file.
- September 24, 2025•Document ID: 11023547Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2423
- Date Added:
- October 2, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: - No upshift past second gear - Unable to achieve third gear ratio - Illuminated malfunction indicator lamp (MIL) with DTCs P0757 and P2701 This may be due to a damaged one-way clutch (OWC).
Associated Products (10)Associated Documents - August 29, 2025•Document ID: 11022410Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2417
- Date Added:
- September 3, 2025
- Manufacturer:
- LINCOLN
SummaryThis article supersedes TSB 25-2345 to update the causal part. Some of the vehicles listed in the Model statement above may exhibit an instrument panel upper section speaker grille that is lifted, warped, or not seated flush with the instrument panel. This may be due to upper section speaker grille clips that are not seating.
Associated Products (4)Associated Documents - August 14, 2025•Document ID: 11021976Service Bulletin/Repair InstructionsFUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- SSM 54138
- Date Added:
- August 19, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 F-150, Expedition/Navigator, Escape/Corsair, Bronco, Explorer, Mustang, Maverick vehicles equipped with a 1.5/2.0/2.3/3.5L EcoBoost engine and built on 01-Oct-2024 and through 31-May-2025 may exhibit an extended crank condition, strong fuel smell in the engine oil, high engine oil level and may have various drivability diagnostic trouble codes (DTCs) stored in the powertrain control module (PCM) with an illuminated malfunction indicator lamp (MIL). This may be due to an internal fuel leak of the fuel injection pump causing fuel to enter the crankcase and reduce fuel pressure in the high pressure fuel rail. Diagnose this condition using Pinpoint Test HP located in the Workshop Manual, Section 303-04A. If no DTCs are stored in the PCM, proceed from Step HP1 to Step HP5 and continue testing. For claiming, if fuel injection pump replacement is required, use causal part number 9D376 and labor operation code 9543A. If the root cause is identified as anything other than the fuel injection pump, claim the repair outside of this article. Note: Components damaged as a result of this failure mode
Associated Products (18)2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Corsair2025 Lincoln Navigator2024 Ford Bronco Sport2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Maverick2024 Ford Mustang2024 Lincoln Corsair2024 Lincoln NavigatorAssociated Documents - August 14, 2025•Document ID: 11021975Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; VISIBILITY/WIPER
- Mfr Comm. #:
- SSM 54137
- Date Added:
- August 19, 2025
- Manufacturer:
- FORD
SummaryVarious 2021-2025 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit "Please Check Surroundings For Safety" or "Full View Not Available" messages when the rear camera button is pressed and the vehicle is not in reverse. Inform customers this condition is considered normal operation and does not affect vehicle durability because the full rear view camera image can only be shown when the vehicle is in reverse. No additional diagnosis or service is required for this condition.
Associated Products (56)2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2025 Lincoln Navigator2024 Ford Bronco Sport2024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Maverick2024 Ford Ranger2024 Ford Transit+ 36 moreAssociated Documents - July 29, 2025•Document ID: 11021358Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54090
- Date Added:
- August 4, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford and Lincoln vehicles equipped with SYNC4/Digital Experience may exhibit an unsuccessful telematics control unit module (TCU) software update or software activation during a universal serial bus (USB) update. This may be due to the vehicle connectivity setting being disabled.
Associated Products (45)2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2025 Lincoln Nautilus2025 Lincoln Navigator2024 Ford Bronco2024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford F-1502024 Ford Mustang+ 25 moreAssociated Documents - July 29, 2025•Document ID: 11020959Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54083
- Date Added:
- July 30, 2025
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Explorer, 2022-2023 F-150, and 2023-2024 Expedition/Navigator vehicles equipped with a 2.3L/3.5L EcoBoost engine may exhibit may exhibit an illuminated malfunction indicator lamp (MIL) and/or powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) P25B3, P25B4, P25B5, P25B6, P2ABA, P2ABB, P2ABC, P2AB7, P2AB8, and/or P2AB9 stored in the powertrain control module (PCM). This may be due to a concern with the turbocharger wastegate. To correct the condition, follow the applicable diagnostic pinpoint tests (PPT) steps found in Workshop Manual (WSM), Section 303-04 and repair as necessary.
Associated Products (9)Associated Documents - July 25, 2025•Document ID: 11020989Service Bulletin/Repair InstructionsSTRUCTURE:BODY; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2345
- Date Added:
- July 30, 2025
- Manufacturer:
- LINCOLN
SummarySome of the vehicles listed in the Model statement above may exhibit an instrument panel upper section speaker grille that is lifted, warped, or not seated flush with the instrument panel. This may be due to upper section speaker grille clips that are not seating.
Associated Products (4)Associated Documents - June 25, 2025•Document ID: 11020044Service Bulletin/Repair InstructionsENGINE; POWER TRAIN
- Mfr Comm. #:
- SSM 53973
- Date Added:
- July 2, 2025
- Manufacturer:
- LINCOLN
SummarySome 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco Sport/E-Series/Escape/Corsair/Expedition/Navigator/Explorer/Aviator/F-150/F-Super Duty/Mustang/Ranger, and 2022-2025 Maverick vehicles may require an A/C compressor clutch assembly replacement be performed for various concerns. Workshop Manual (WSM), Section 412-00 Removal and Installation has been updated to eliminate the need to remove and install the A/C compressor to change out the A/C Compressor clutch assembly.
Associated Products (76)2025 Ford Bronco2025 Ford Bronco Sport2025 Ford E-3502025 Ford E-4502025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Bronco2024 Ford Bronco Sport2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition+ 56 moreAssociated Documents - June 5, 2025•Document ID: 11019494Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 53878
- Date Added:
- June 11, 2025
- Manufacturer:
- LINCOLN
SummarySome 2021-2025 Expedition/Navigator and 2021-2025 F-150 non-Lightning/non-PowerBoost vehicles may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine to transmission spacer plate (separator plate). To correct this condition, inspect the engine to transmission spacer plate and torque converter studs for wear/damage. If wear/damage is found, replacement of the torque converter is not necessary. Replace only the engine to transmission spacer plate. Refer to Workshop Manual (WSM) Section 303-01 > Engine to Transmission Spacer Plate for full spacer plate removal and installation. When reinstalling the starter motor, make sure the starter is flush with the engine to transmission spacer plate prior to tightening the studbolts. Failure to do so may result in damaging the newly installed engine to transmission spacer plate.
Associated Products (15)Associated Documents - April 24, 2025•Document ID: 11017346Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53661
- Date Added:
- April 30, 2025
- Manufacturer:
- FORD
SummarySome 2018-2024 Expedition/Navigator vehicles equipped with 22 inch wheels, may exhibit an increased level of vibrations which can be felt while driving on a smooth road at speeds at or above 75 mph (120 km/h). Pinpoint Test G located in Workshop Manual (WSM), Section 204-04 has been developed to assist with diagnosis of this condition. When submitting a warranty claim, include all results from the Pinpoint Test.
Associated Products (8)Associated Documents - April 4, 2025•Document ID: 11016915Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53569
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
Associated Products (25)2025 Ford Bronco Sport2025 Ford Escape2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Escape2024 Ford Expedition2024 Ford F-1502024 Ford Mustang2024 Ford Ranger2024 Lincoln Corsair2024 Lincoln Navigator2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Lincoln Corsair+ 5 moreAssociated Documents - March 19, 2025•Document ID: 11016079Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2107
- Date Added:
- March 31, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2055 to update the labor time description.
Associated Products (16)Associated Documents - March 19, 2025•Document ID: 11016076Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2104
- Date Added:
- March 31, 2025
- Manufacturer:
- LINCOLN
SummaryThis article supersedes TSB 24-2251 to update the labor times associated with the Service Procedure from M-time to AP-time.
Associated Products (12)Associated Documents - March 5, 2025•Document ID: 11015517Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53469
- Date Added:
- March 11, 2025
- Manufacturer:
- FORD
SummarySome 2022-2024 Expedition/Navigator vehicles may exhibit the liftgate spoiler contacting the roof during freezing temperatures when ice is present.
Associated Products (6)Associated Documents - February 27, 2025•Document ID: 11014840Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2059
- Date Added:
- March 4, 2025
- Manufacturer:
- FORD
SummaryThis TSB supersedes 24-2261. Reason for update: update the procedure, parts list and labor operation. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Lower than actual fuel level indication on the fuel gauge * Inaccurate DTE displayed in the IPC after adding fuel to the vehicle This may be due to the IPC software and can occur if the vehicle is shut off before placing the gear shift module (GSM) in park (p) and then partially filling the fuel tank.
Associated Products (2)Associated Documents - February 25, 2025•Document ID: 11014836Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2055
- Date Added:
- March 4, 2025
- Manufacturer:
- LINCOLN
SummarySome of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * General system performance/stability/intermittent system reboot * Intermittent wireless CarPlay or Android Auto function * Phone related concerns with intermittent no audio or static * Navigation/global positioning system (GPS) related concerns through CarPlay and Android Auto * Alexa function consistency and stability * Charge Assist/Public Charging app inoperative (e-Transit only) This may be due to a concern with the software in the accessory protocol interface module (APIM).
Associated Products (16)Associated Documents - February 21, 2025•Document ID: 11014932OtherUNKNOWN OR OTHER
- Mfr Comm. #:
- 25B01
- Date Added:
- March 5, 2025
- Manufacturer:
- FORD
SummaryCertain 2024 Model Year F-150, Mustang, Expedition, Navigator, Transit, Super Duty, and 2025 Model Year Explorer vehicles, equipped a 10R80/10R100 Transmission. Transmission Assembly Replacement
Associated Products (6)Associated Documents - January 24, 2025•Document ID: 11013846Over The AirUNKNOWN OR OTHER
- Mfr Comm. #:
- OTA SU 10.1.0 Navigator
- Date Added:
- February 6, 2025
- Manufacturer:
- LINCOLN
Summary"Quality Improvements: - Customer should be able to enable and disable Intelligent power toggle button. -Adresses SYNC reboots and improves the vehicle's conectivity with the user's phone "
Associated Products (3)Associated Documents - January 17, 2025•Document ID: 11013132Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53305
- Date Added:
- January 27, 2025
- Manufacturer:
- FORD
SummarySome 2017-2025 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving.
Associated Products (39)2025 Ford Explorer2025 Ford F-1502025 Lincoln Aviator2024 Ford Bronco2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford Mustang2024 Ford Ranger2024 Ford Transit2024 Lincoln Aviator2024 Lincoln Navigator2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator+ 19 moreAssociated Documents - December 17, 2024•Document ID: 11012136Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53236
- Date Added:
- January 2, 2025
- Manufacturer:
- FORD
SummarySome 2021-2023 F-150 non-Lightning, 2022-2024 F-150 Lightning/Expedition/Navigator, and 2024 Ranger vehicles may exhibit a "trailer brake module fault" message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) U0137 and/or U0252 stored in the body control module (BCM),
Associated Products (10)Associated Documents