Ford F-150 Service Bulletins (2025)
150 manufacturer communications on file.
- June 23, 2025•Document ID: 11019704Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2273
- Date Added:
- June 24, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 24-2443 to update the vehicles affected. Some of the vehicles listed in the Model statement above equipped with the 400-watt direct current/alternating current (DC/AC) inverter system (minor feature code HUKAJ) with a pickup bed alternating current (AC) power outlet socket may exhibit inoperative power outlets with diagnostic trouble code (DTC) B1330:9A stored in the body control module (BCM). This may be due to a connection issue at C4628. NOTE: This article does not apply to vehicles with an inverter system other than the 400-watt DC/AC inverter system with a pickup bed AC power outlet socket.
Associated Products (5)Associated Documents - June 9, 2025•Document ID: 11019421Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2246
- Date Added:
- June 10, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2165 to update the labor operation allowance and update the Service Procedure. Some of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450 stored in the powertrain control module (PCM). This may be due to the software level of the PCM.
Associated Products (5)Associated Documents - June 5, 2025•Document ID: 11019494Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 53878
- Date Added:
- June 11, 2025
- Manufacturer:
- LINCOLN
SummarySome 2021-2025 Expedition/Navigator and 2021-2025 F-150 non-Lightning/non-PowerBoost vehicles may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine to transmission spacer plate (separator plate). To correct this condition, inspect the engine to transmission spacer plate and torque converter studs for wear/damage. If wear/damage is found, replacement of the torque converter is not necessary. Replace only the engine to transmission spacer plate. Refer to Workshop Manual (WSM) Section 303-01 > Engine to Transmission Spacer Plate for full spacer plate removal and installation. When reinstalling the starter motor, make sure the starter is flush with the engine to transmission spacer plate prior to tightening the studbolts. Failure to do so may result in damaging the newly installed engine to transmission spacer plate.
Associated Products (15)Associated Documents - June 4, 2025•Document ID: 11019420Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- TSB 25-2245
- Date Added:
- June 10, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an illuminated ABS warning indicator and diagnostic trouble code (DTC) U3012:68 stored in the anti-lock brake system (ABS) module. The vehicle may also exhibit any of the following symptoms: - a soft brake pedal following vehicle start-up - various brake system illuminated warning lamps - brake-related messages displayed in the instrument panel cluster (IPC) This may be due to a controller area network (CAN) communication concern within the ABS module.
Associated Products (1)Associated Documents - May 30, 2025•Document ID: 11018773Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL
- Mfr Comm. #:
- SSM 53858
- Date Added:
- June 2, 2025
- Manufacturer:
- FORD
SummarySome 2025 F-150 vehicles may exhibit an illuminated anti-lock brake system (ABS) warning indicator with diagnostic trouble code (DTC) U3012:68 stored in the ABS module. The vehicle may also exhibit any of the following symptoms: a soft brake pedal following vehicle start-up, various brake system illuminated warning lamps and/or brake-related messages displayed in the instrument panel cluster (IPC).
Associated Products (1)Associated Documents - May 15, 2025•Document ID: 11018526Service Bulletin/Repair InstructionsVISIBILITY/WIPER
- Mfr Comm. #:
- TSB 25-2201
- Date Added:
- May 21, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls, not opening all the way and/or bouncing back when using the one-touch close function. This may be due to a calibration parameter in the driver door module (DDM) and/or passenger door module (PDM).
Associated Products (5)Associated Documents - May 13, 2025•Document ID: 11018521Service Bulletin/Repair InstructionsENGINE; POWER TRAIN
- Mfr Comm. #:
- SSM 53764
- Date Added:
- May 21, 2025
- Manufacturer:
- FORD
SummarySome 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
Associated Products (65)2025 Ford Bronco2025 Ford E-3502025 Ford E-4502025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Bronco2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer+ 45 moreAssociated Documents - May 12, 2025•Document ID: 11018238Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53759
- Date Added:
- May 13, 2025
- Manufacturer:
- LINCOLN
SummaryAfter replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occurring between modules and/or a module is not responding. This may be a result of missing the new module secret authentication security key obtained when running the Ford Diagnosis and Repair System (FDRS) "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure after replacement. When replacing a TRON capable module, run the FDRS "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure in the GWM tool box, not in the toolbox of the module with the DTC's, to distribute a new set of secret authentication security keys to all TRON-capable modules. Using the specific vehicle identification number (VIN), refer to Workshop Manual (WSM), Section 418-00 and 418-01 for updated DTCs, applicable TRON module listings and pinpoint tests.
Associated Products (16)Associated Documents - May 6, 2025•Document ID: 11018318Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2165
- Date Added:
- May 14, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450 stored in the powertrain control module (PCM). This may be due to the software level of the PCM.
Associated Products (5)Associated Documents - April 29, 2025•Document ID: 11017397Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53683
- Date Added:
- May 1, 2025
- Manufacturer:
- FORD
SummarySome 2025 F-150/Expedition/Navigator/Bronco/Ranger vehicles may exhibit diagnostic trouble code (DTC) U3012:68 stored in the anti-lock brake system (ABS) module with a soft brake pedal following vehicle start-up with various brake system illuminated warning lamps and/or brake-related messages displayed in the instrument panel cluster (IPC). This may be due to a controller area network (CAN) communication concern within the ABS module. Replacement of the ABS module will not resolve this condition. To resolve this condition, place the vehicle in park. Disengage the park brake. Turn the vehicle off. Close all doors and liftgate/tailgate. Allow the vehicle to sit for 5 minutes to allow all vehicle modules to power down. Restart the vehicle. Verify brake functionality and clear any DTCs. Pressing unlock/lock button on the key fob, opening the doors/liftgate/tailgate or keeping the key fob within 30 ft (8 meters) of the vehicle can prevent the modules from powering down completely. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition
Associated Products (5)Associated Documents - April 27, 2025•Document ID: 11017337Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2174
- Date Added:
- April 30, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the model statement with approximately 1,000 miles (1600 km) or less on the odometer, may exhibit an intermittent momentary moan noise with an associated vibration when traveling an uphill grade at 50-70 mph (80-112 km/h), while the throttle pedal is slightly depressed (throttle tip-in) without shifting. The vibration may be felt through the accelerator pedal, through the driver's side floor of the vehicle and the steering wheel that lasts for 1-2 seconds. This may be due to momentary excessive slip of the torque converter lock up clutch within the front hybrid drive unit.
Associated Products (2)Associated Documents - April 14, 2025•Document ID: 11017064Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53638
- Date Added:
- April 16, 2025
- Manufacturer:
- LINCOLN
SummaryAfter replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occuring between modules and/or a module is not responding. This may be a result of missing the new module secret authentication security key obtained when running the Ford Diagnosis and Repair System (FDRS) "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure after replacement. When replacing a TRON capable module, run the FDRS "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure to distribute a new set of secret authentication security keys to all TRON-capable modules. Using the specific VIN, refer to Workshop Manual (WSM), Section 418-00 and 418-01 for updated DTCs, applicable TRON module listings and pinpoint tests.
Associated Products (16)Associated Documents - April 11, 2025•Document ID: 11017055Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2144
- Date Added:
- April 16, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit one or more of the following conditions that lead to needing to perform the calibration (alignment) procedure on exhaust tailpipe actuators: * An illuminated malfunction indicator lamp (MIL) and an Exhaust mode not available message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) P26FE, P2BFB, P26C5:78, and/or P2BF8:78 stored in the powertrain control module (PCM) * A condition/symptom that requires the installation of an exhaust tailpipe actuator when undergoing normal diagnosis and repair * Exhaust tailpipe actuators failing alignment procedure after installation with parameter identification (PID) "EFCV_A_MON_STAT" and/or PID "EFCV_B_MON_STAT" reading "3" * No audible difference in exhaust tone when transitioning between exhaust modes These exhaust tailpipe actuators require alignment after installation. These vehicles may require an update to the PCM prior to attempting exhaust tailpipe actuator alignment.
Associated Products (3)Associated Documents - April 8, 2025•Document ID: 11017061Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53602
- Date Added:
- April 16, 2025
- Manufacturer:
- FORD
SummarySome 2022-2025 Ford or Lincoln vehicles may exhibit DTCs B142E:78, B1432:78, and/or B1433:54 diagnostic trouble codes (DTCs) in the CCM. This may be due to non-factory sized tires that may cause inaccurate speedometer readings that can impact the functionality of the CCM. When a vehicle is modified in this manner, replacement or realignment of the CCM may impact the normal operation of the system and/or performance of radar and camera-based features. Repair or replacement of the CCM when a vehicle is equipped with non-factory size tires may not be warrantable and subject to chargeback.
Associated Products (20)2025 Ford Bronco2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2024 Ford Bronco2024 Ford F-1502024 Ford Maverick2024 Ford Mustang2024 Ford Ranger2023 Ford Bronco2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2022 Ford Bronco2022 Ford F-1502022 Ford Maverick2022 Ford Mustang2022 Ford RangerAssociated Documents - April 7, 2025•Document ID: 11016927Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 25-2124
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2080 to remove the side obstacle detection control module C (SODCMC) in the Issue statement, Action statement and Service Procedure and update the causal part
Associated Products (4)Associated Documents - April 5, 2025•Document ID: 11016919Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53579
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 F-150 vehicles equipped with a lower active grille shutter may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P05B0 stored in the powertrain control module (PCM).
Associated Products (2)Associated Documents - April 4, 2025•Document ID: 11016915Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53569
- Date Added:
- April 9, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
Associated Products (25)2025 Ford Bronco Sport2025 Ford Escape2025 Ford Explorer2025 Ford F-1502025 Ford Maverick2025 Ford Mustang2025 Ford Ranger2025 Lincoln Aviator2025 Lincoln Corsair2024 Ford Escape2024 Ford Expedition2024 Ford F-1502024 Ford Mustang2024 Ford Ranger2024 Lincoln Corsair2024 Lincoln Navigator2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Lincoln Corsair+ 5 moreAssociated Documents - April 1, 2025•Document ID: 11016853Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53559
- Date Added:
- April 8, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 vehicles equipped with the rear parking aid feature may exhibit all of the following conditions:<br /> * A rear parking aid alarm activation when in reverse and no rear obstacles are present<br /> * No diagnostic trouble codes (DTCs) stored in the image processing module A (IPMA)<br /> The Workshop Manual (WSM) has recently been updated to address this condition. Refer to the WSM, Section 413-13A Parking Aid - Vehicles With: Front Parking Aid/Rear Parking Aid > Diagnosis and Testing > Parking Aid > Pinpoint Test R: Continuous Or Intermittent Tone When No Obstacles Or Fault Codes Are Present.
Associated Products (5)Associated Documents - March 26, 2025•Document ID: 11016089Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53530
- Date Added:
- March 31, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Ford vehicles may exhibit a condition where heated/cooled seats, heated steering wheel and/or front/rear defrost features will not turn on after a remote start is performed through the FordPass application or the key fob.
Associated Products (8)Associated Documents - March 25, 2025•Document ID: 11016087Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 53522
- Date Added:
- March 31, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 F-150 vehicles equipped with a hybrid powertrain may exhibit an intermittent moan noise with an associated vibration when travelling at 50-70 mph (80-113 km/h) while the throttle pedal is slightly depressed (throttle tip in) without shifting.
Associated Products (2)Associated Documents