Volvo XC60 Complaints

656 consumer complaints on file.

#11446687January 7, 2022
VISIBILITY/WIPER
During heavy rains and movement there is water leaking into the vehicle along the top drivers inside of the windshield. It also drips onto the steering wheel which often startles me while actively driving. The windshield has no cracks and is the original windshield.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11446418January 5, 2022
VISIBILITY/WIPER
Yesterday ice-cold water was dripping onto my lap while I was driving (distracting), as well as obstructing my vision while it ran down the inside of the glass. In addition, water collected at the footwell made it soggy and being that it was 5 degrees overnight it was frozen solid making the break pedal almost non-functional.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11446234January 4, 2022
ENGINE
"The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling the oil each 4-6 weeks. The vehicle was taken to the dealer, Bobby Rahal of the South Hills, who diagnosed that the piston rings needed to be replaced for more than $4,000 or the dealer stated that adding oil to the car every month would be a cheaper and not unsafe solution. On January 1 while driving on the highway, far from home, in the rain and fog with 3 children in the car, the engine started riding rough. The vehicle was driven cautiously home and taken to the independent mechanic specializing in Volvos who diagnosed that the engine had failed and needed to be replaced. The independent mechanic said he has seen 4-5 Volvos this year with the same problem, and that there is something wrong with the 2015 2/5 engine for this car, but prior to that year, it has been a good engine, and since that year, it has been a good engine. The vehicle was towed to the dealer where it was purchased, Bobby Rahal Volvo of the North Hills, and the diagnosis was the same for the 6 year old car needing a new engine for more than $16,000. Since the car was purchased in November 2020 for $18K+, the customer is wondering if the dealer that sold the car and the dealer that was asked about the oil issue knew the car engine was likely defective, did not tell the contact and put the contact's family in an unsafe situation. The manufacturer was notified of the failure, and the contact is awaiting a response. The vehicle has not yet been repaired. The failure mileage was approximately 76,000, after less than 8,000 of vehicle ownership."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11445465December 29, 2021
UNKNOWN OR OTHER
There is a steady leak in the top left (driver side) of the windshield. Heard from the Tom Wood service and collision department that this is a common problem with these vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11445478December 29, 2021
UNKNOWN OR OTHER
The front seal on my windshield glass is not connected, the adhesive us either gone or not working anymore. You can push the glass up and see it move visibly when pushed. The leak is impacting my safety while driving. Yesterday ice cold water was dripping onto my lap while I was driving (distracting), as well as obstructing my vision while it ran down the inside of the glass. An independent glass company has inspected the windshield and duplicated the issues I have mentioned above. They mentioned that they have seen many of these faulty windshield seals and thought there might be a recall, but I have not been able to see one from Volvo.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11444515December 20, 2021
FUEL/PROPULSION SYSTEM
The fuel pump regulator failed causing the fuel pump to fail way to early (car has less than 60K miles). In addition, the floats in the fuel tank itself stick making the fuel gauge unreliable. We have had to replace the fuel pump regulator, fuel pump and also have an unreliable gas gauge now unfortunately. The car failed while we were driving through the canyon in southern CA which was terrifying and very dangerous. We are fortunate we were able to steer off the road and get out of the way.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11444016December 16, 2021
VISIBILITY/WIPER
When it rains or I go through the car wash the windshield leaks water that runs down the inside of the glass and has stained the headliner
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443740December 14, 2021
TIRES:SIDEWALL
Without incident, the rear driver side tire on our 2020 Volvo XC60 blew out on the sidewall on December 1, 2021. The tire, original to our purchase of the new vehicle, had approximately 10,600 miles on it. There was no other damage to any other part of the tire or wheel. Unfortunately, even though we requested Discount Tire (who replaced the tire) to keep the tire for us, they did not so we don't have it for inspection. Regardless, I have several pictures and a couple of videos of the tire (while on the vehicle). No accident occurred and the other three tires on the vehicle are still undamaged.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442178November 30, 2021
STRUCTURE:BODY
After I parked my car, the driver’s seat back tilted forward towards the steering wheel and could not be repositioned either manually or electronically. I could barely squeeze in and certainly could not drive the car with the seat in that position. The car needed to be towed to the dealer and Volvo replaced all related components, which were under warranty. If this had occurred while I was driving, the situation would have been extremely dangerous. There were no prior warnings of the seat back failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11441245November 22, 2021
UNKNOWN OR OTHER, AIR BAGS
Windshield leaks while raining. Mold getting into headliner and the drips affect my visibility. The water intrudes into airbag area and could affect airbag lifespan and efficiency. Can affect electrical safety features in car. Cannot see while driving . Other people all over internet have this issue . Reported it to dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440071November 10, 2021
STEERING
I purchased a brand new Volvo XC60 T5 AWD Inscription 7/04/2021. On 9/22/2021 I was driving in the middle lane on interstate 20 located in DFW TX and entering a curve when suddenly and without warning the steering wheel went stiff (as if I had NO power steering). I almost got into an accident, had I not been an experienced driver. A warning then displayed in the driver's information center "Power Steering Service Urgent, Drive To Workshop". The steering wheel continued to function as if I had no power steering until I arrived at work. I immediately called the dealership where I purchased the my SUV and they got me scheduled with a loaner. It was a traumatic incident that caused me great deal of concern since my SUV in brand new. Apparently Volvo put out an advisory notice that the sub-battery attached to the power steering pump is having issues and the dealership replaced it. I have not had a similar experience since...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11439425November 4, 2021
ELECTRICAL SYSTEM
Summary: Vehicle suddenly and completely loses all electric power. i.e. no lights, including hazard lights or brake lights, no engine, no power steering. Status: The root issue has occurred twice, and the vehicle is pending service to positively diagnose and repair the issue. First occurrence: Driver parked the vehicle, turned off the engine, and remained inside with standard electric power active. Upon exiting the vehicle and closing the driver’s door, the door lock button did not respond. Returning to the vehicle it became apparent the reason for the lock failure was the absence of electric power. During the process of preparing to connect jumper cables, electric power returned. This was without actually connecting to a jump source. Second occurrence, 1 day after first: While driving at 60 MPH on a highway, electric power suddenly ceased. Driver unable to activate hazard lights or any other warning to other vehicles. Driver was able to steer to roadside and come to a stop. At suggestion of mechanic shop, driver opened battery compartment and tapped the cables connected to the battery terminal, and power returned. Mechanic suggested hairline fracture of metal connectors of positive cable connecting to vehicle power. Now awaiting mechanic diagnosis and repair. Fortunately the failure did not result in a collision, but does present a clear safety hazard upon its occurrence. The mechanic’s suggestion leads to the suspicion this is a known issue with the vehicle component.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438075October 25, 2021
SERVICE BRAKES, ELECTRICAL SYSTEM
1. One day after getting car the rear rotors were defective and had to be replaced. 2. Second problem affected stop/start mechanism. Brought car in four times for this repair. First 3 times service department had no idea what was causing problem. Last time brought in for this problem a stop/start battery was replaced. 3. New most dangerous problem is that while driving car the dashboard display turned into a bright barcode (I took a picture if needed). Stoped car at red light and upon restarting car same problem existed. Went to restaurant and upon leaving 90 minutes later same problem exhausted. This morning when dealer came to pick up car display was working. My wife drives car and this last problem scared her very much and she is frightened to drive car not knowing when and if this, or other problems will again occur. You could not see the speed you were driving at nor how much gas was left. Also, this occurred at night and the light from the barcode display was so bright that it interfered with driving. Have other Volvo owners experienced this problem ? This car is a lemon. And only 16 months old.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437908October 23, 2021
FUEL/PROPULSION SYSTEM
The gas gauge no longer reports accurate level of fuel in tank. Thousands of people have reported this issue, yet no recall exists, though this endangers lives - especially in the deserts of the southwest. Volvo service quotes are aways ripoffs, quoting $3000 minimum.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436878October 15, 2021
VISIBILITY/WIPER
Water is leaking down the inside of the windshield while driving in rain. It comes from the top edge and streaks down the drivers side (left side). I spoke with a mechanic that services my vehicle and was told if it was a sunroof drain issue it would be coming down the pillars and getting on the floor. They were confident that it was the windshield that was leaking and referred me to a local auto glass business for repair. I read on a car forum about other Volvo car owners having the exact same problem with their Volvos that are around the same age as mine. It seems to be a glass adhesion failure that consistently occurs on the top edge of the Volvo OEM windshields. The forum is located at https://beranek.agrrmag.com/2015/04/volvo-glass-bonding-issue/ I also contacted Volvo about what I had found and having it covered by them, and they asked me to first get it inspected by a Volvo dealer before they would decide whether or not they'd pay for the repair. I spoke with someone in the service department of my nearest Volvo dealer and they wanted to charge me $300 just to inspect it. The date of the incident I'm giving below is the date that I first experienced the water running down the inside of the windshield while driving. Thankfully I had something within reach to wipe it with as I was doing 60 MPH on the interstate highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11433750September 21, 2021
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
On 9/8/2021, Niello Volvo Sacramento service replaced my fuel pressure sensor and fuel line. On 9/15/2021, my engine caught fire and the car was deemed a total loss by insurance company. I drove from my home in Plumas Lake 95961 to Marysville approximately 10 miles away at 9:50 AM, at approximately 10:00-10:05 as I was nearing the end of my trip, a trouble light came on that said “engine performance decreased” and the picture of a turtle appeared on my dash screen, shortly after that another light appeared that said “battery not charging”, I parked my car in the Save Mart parking lot and exited and noticed some smoke coming out of the hood, it was light at first but increased quickly so I called 911 immediately. As I was on the phone with 911, flames began shooting out from under the hood, so I grabbed my fire extinguisher out of the back of my car and tried to put the fire out, but extinguisher was too small, a man from the grocery store brought out a bigger extinguisher, but fire continued to grow, by now the fire dept. arrived, opened the hood and after about 10 minutes extinguished the fire with a hose. I contacted Niello Volvo but they seemed disinterested in getting involved and after a second call to them, the service manager [XXX] hung up on me. I could have been killed! If my elderly husband or mother had been in the car with me, it would have been difficult to get them out! I want to know what caused the fire! Faulty electrical system, faulty fuel sensor/fuel line which had just been installed 7 days prior? Faulty engine? There are still many 2015 Volvo XC60’s on the road and I fear for anyone driving one if there is a problem in need of recall. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11433852September 21, 2021
SERVICE BRAKES, POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owned a 2021 Volvo XC60. The contact stated that while driving approximately 25 mph, the vehicle suddenly began to accelerate and the brakes failed to stop. The vehicle crashed into a nearby fence causing the vehicle to flip. The air bags did deploy. The contact received injuries to their right shoulder and left knee. Medical attention was needed. A police report was filed. The vehicle was towed and had not been deemed totaled as of yet however, damage to the vehicle would be considered unrepairable. The dealer was informed of the incident however they were unable to assist. The manufacturer was not made aware of the failure. The approximate failure mileage was unknown.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11433850September 21, 2021
UNKNOWN OR OTHER
I leased the vehicle in December, 2020. Periodically while the tailgate is open and I am underneath it, the tailgate has closed on me and hit me in the back. In February, 2021, the struts on the tailgate were replaced at Patrick Volvo, Fort Myers, Florida, after I received a recall letter from Volvo. On September 9, 2021 at approximately 11:00 a.m. (CST) I was under the opened tailgate and it closed three times in a row and hit me in the back. Each time that it hit me, it reversed direction and went back into the open position. I was not injured but my back was sore for the rest of the day. I brought the SUV into Patrick Volvo, Shaumburg, Illinois. The service representative (SR) explained to me that there is a sensor under the rear bumper that will open and close the tailgate if you waive your foot under one specific location. Which is approximately two feet from the left edge of the bumper. The SR explained to me that I must have accidentally waived my foot under the bumper and the sensor caused the tailgate to close. He further advised that it could not be deactivated. On September 18, 2021, at approximately 10:00 a.m. I was sitting in the cargo area putting on my golf shoes. The tailgate started to close. I ran as fast I could and avoided getting hurt or injured. My feet were not capable of engaging the sensor as they were in front of the bumper. I have advised Volvo Customer Service and Patrick Volvo of this new safety concern. Patrick Volvo has stated to me that they have never had this problem on any of their SUVS. They also do not know what is causing it. They are waiting for a loaner SUV to come back to their dealership and then I will bring the vehicle in, so they can attempt to solve this safety issue. In the meantime, I have to be very cautious when the tailgate is open. My fear is not only that it will hit me, but more so that it will not reverse direction and close on me.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11432966September 14, 2021
TIRES
The contact owns a 2019 Volvo XC60 equipped with Pirelli tires, Tire line: Scorpion Zero, Tire size: 235/55/R19, DOT number: XB08V824219. The contact stated that while the vehicle was parked, the passenger side rear tire experienced a blowout. The contact's child was nearby when the tire exploded but did not sustain any injuries. The dealer was made aware of the failure and was sending a tow truck to tow the vehicle. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431557September 2, 2021
UNKNOWN OR OTHER, VISIBILITY/WIPER, AIR BAGS
The problem started 2 years ago and has progressively become worse. The original windshield is leaking water, which drains down inside the A-pillar and windshield. Water also leaks into the air-bag in the A-pillar, and moisture may come in contact with the electronic parts in the dashboard, creating a safety issue and a potential fire hazard. Last year I contacted Tucson Volvo for help, and they referred me to JD Auto Glass (520-370-6599). The local dealer refused to take any responsibility for this safety defect. There have been heavy rains recently in Tucson, and water is dripping onto my lap while I am driving, and trying to wipe the dashboard dry. This causes a major distraction and obstructs my vision, since the water continuously runs down the inside of the windshield glass. Yesterday I contacted Tucson Volvo again, and they referred me to Tony's AutoGlass (520-889-2422). The Owner/Manager of Tony's AutoGlass informed me that leaking windshields are a very common problem with Volvos. I believe this is a very serious safety defect, and am seeking help from your office. Thank You!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC60