Volkswagen · Model Report
Showing safety data for the 1999 model year only.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Just as I parked, the explosive seatbelt retractor for the rear passenger seat activated. There was a loud pop from the charge and the plastic seatbelt alignment clip flew off, and smoke came out from around the seatbelt. Had the vehicle been in motion there would have been a very serious safety hazard from the distraction, and if someone was in the back, there was the clip that flew off that could have struck them. No one was in the seat at the time of the incident. The seatbelt is now stuck in the retracted position. The component has not been inspected. There were no warning lamps before or after the failure. The climate control system does have an error and is not cooling. The error is for the A/C pressure sensor, so it does not seem related. I do have an appointment for the climate control system, so I can have the component inspected by the service center. Ambient temperature was approx 85F at the time of the incident. The sunroof was set to vent position while driving, and the climate control system fan was operating so interior temp should have been around 85F as well.
No injuries · No fire · No crash
I WOS DRIVING FROM WORK TO HOME I TOOK THE PARKWAY I WOS GOING 60 MILES THEN IN HIS OWN THE CAR STARTING INCREASING SPEED SO I MOVE THE SHOULDER I PUT THE CAR NEUTRAL AND STOP THE CAR.THE TOOK ME 3 TRY TO THE CAR GO BACK TO NORMAL. I DONT KNOW IF THIS CAR GOT I RECALL.
No injuries · No fire · No crash
AFTER STARTING AND BEGINNING MOTION THERE'S A SLOWING IN MOTION AS THOUGH THE BRAKES HAD BEEN SLIGHTLY TAPPED OR AS THOUGH THE ABS HAD TOLD THE TRANSMISSION COMPUTER TO SLOW DOWN. GAS CONSUMPTION WAS 16MPG. AFTER SEVERAL YEARS ONE TECH LISTENED TO ME, ADJUSTED THE 'FEEDBACK' FROM ABS TO THE TRANSMISSION MODULE COMPUTER AND THE SENSATION OF BRAKED SLOWING WAS GONE! AND THE GAS CONSUMPTION BECAME 19MPG! SEVERAL YEARS LATER MY DOOR LOCKS SHORTED OUT AND HAD TO BE REPLACED AFTER DESTROYING TWO BATTERIES. THE TECH THEN REPORTED THAT HE HAD REPROGRAMMED THE ELECTRICAL SYSTEM TO 'FACTORY SPECS' AT THAT POINT THE 'SLOWING (BRAKED)' PROBLEM RECURRED AND THE GAS CONSUMPTION DROPPED BACK TO 16 MPG. HOW CAN I GET THE CAR READJUSTED TO GET RID OF THE 'SLOWING' PROBLEM AND RETURN TO 19MPG GAS USAGE??? [XXX] , [XXX] MY DEALER IS :CARTER VOLKSWAGEN,SEATTLE, WA MY E-MAIL IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
No injuries · No fire · No crash
DRIVERS SIDE WINDOW FELL PARTIALLY INTO THE DOOR WHILE OPERATING WINDOW POWER CONTROL DURING DRIVING OPERATION ON HIGHWAY. UPON REACHING THE DESTINATION AND TOUCHING THE WINDOW POWER CONTROL, THE WINDOW COMPLETELY FELL DOWN INTO THE DOOR. THIS EVENT IS THE SECOND TIME IT'S HAPPENED ON THIS VEHICLE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE HAVING A ROUTINE SERVICE PERFORMED AT AN INDEPENDENT MECHANIC, THE TECHNICIAN DIAGNOSED THE WATER PUMP WAS CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 179,000.
No injuries · No fire · No crash