Volkswagen · Model Report
Showing safety data for the 2020 model year only.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2020 Passat vehicles. The passenger frontal air bag may have been folded incorrectly affecting its deployment force. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas and 2020 Passat vehicles. An incorrect driver and/or front passenger side impact air bag may have been installed.
my 2020 vw passat has less than 60k mikes and i am replacing my 3rd wheel sensor. they fail without warning disabling my antilock brakes. And other safety features
No injuries · No fire · No crash
The front information center which is responsible for the rear camera system is shutdown due to the radio / entire screen being dead without reason
No injuries · No fire · No crash
While driving and after, we noticed gas fumes both inside and outside of vehicle. The gas tank was approximately half full. Became very concerned over the the possibility of a fire. Did research online and realized that this was and is a common problem with older models of the Passad (ours is a 2020 model that we bought new and had zero accidents) plus Jetta and Golf models. We took it to a VW Dealer (Ken Graff VW Gilbert, AZ ) nearest our home for fear of a fire hazard and safety. They repaired it stating that the gas tank had various creaks neasr the top of the tank which allowed fumes to be released. My cost to repair was approximately $1,100 which for a vehicle with some 62,000 miles and no accidents seems to be concerning. The service advisor stated not covered under warranty or not under a recall notice. Thjs is plainly wrong and is certainly a fire hazard. Thank you for looking into this important issue.
No injuries · No fire · No crash
2020 Volkswagen Passat SE 2.0L VIN: [XXX] Complaint Summary: I am reporting a persistent and unresolved fault involving the secondary air injection system (DTC P0491 – insufficient airflow) that has resulted in repeated, conflicting diagnoses across multiple repair facilities. This raises concerns about a potential systemic defect affecting this vehicle model. Detailed Description: The issue began prior to March 2025 while the vehicle was still under warranty. The vehicle displayed a Check Engine Light associated with diagnostic trouble code P0491 (secondary air injection system insufficient airflow). On April 3, 2025, a repair facility diagnosed the issue as a failed secondary air injection pump and replaced the component. However, the Check Engine Light returned within 24 hours with the exact same fault code, indicating that the repair did not resolve the issue. A second independent diagnostic evaluation was performed later in April 2025. This inspection confirmed that: The secondary air injection pump was functioning correctly Airflow through the system was present Electrical controls and PCM commands were operating properly The fault was attributed instead to a mechanically stuck secondary air injection combination valve Despite this revised diagnosis, the issue has remained unresolved. As of 2026, a dealership evaluation has now attributed the same fault condition to a potential failure within the cylinder head assembly, indicating a significantly more serious underlying condition. Safety Concern: This issue involves the emissions and engine air management system and has resulted in: Persistent Check Engine Light Repeated failure of emissions-related components Conflicting and escalating repair diagnoses across multiple qualified service providers I am requesting that the National Highway Traffic Safety Administration review this issue for potential investigation into a systemic defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
Steering wheel controls stopped working, no horn either. Probably no airbag but haven't got into an accident. There was recall on the same part for the until 2018, but the new part I was going to install lists that if fits cars 2016-2022 Part # 5K0-953-569-BC Recall from VW. Number: VWP-18-11, Will replace part for my fiance,
No injuries · No fire · No crash