Mercury Milan Complaints

2,579 consumer complaints on file.

#11466614May 29, 2022
SERVICE BRAKES
I took the vehicle in earlier this year for the recall on the Brake system. They bled the brakes and said it was fine but now the brakes are just like they were before taking it in. I would assume that the HCU is bad but they did not want to change it out when they had it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466349May 27, 2022
AIR BAGS
RE: Safety Recall Notice 21S12 / NHTSA Recall 21V-158 ISSUE: "In the event of a crash that causes deployment of the driver airbag, the driver airbag inflator in your vehicle may explode." RISK: "If an airbag inflator explodes, sharp metal fragments could strike the driver or other occupants causing serious injury or death." MY COMPLAINT: I received this notice from Ford Motor Co. in APRIL 2021. Today is May 27, 2022, and the manufacturer has failed to remedy this situation or even to contact me with a possible resolution date for this situation. My life and safety as the only driver of this vehicle is seriously at risk every time I am on the road. This is a most egregious situation and I demand immediate repair. CONCLUSION: I need to know exactly what is being done by the NHTSA and the manufacturer to fix this problem immediately. Sincerely, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466255May 26, 2022
SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed but almost went to the floorboard. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who referred the contact to the dealer. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified but no additional assistance was provided. The contact stated the failure was related to NHTSA Campaign Number 19V904000 (Service Brakes, Hydraulic). The failure mileage was approximately 99,450.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463609May 6, 2022
SERVICE BRAKES
Brake failure related to recall 19s54 which my vehicle vin number was not included. All brake warning lights came on and traction control lights came on as well as brake pedal going to floor and unable to stop in time going over railroad tracks. Almost causing me to crash thru railroad crossing gates as train was approaching. I used emergency brake to stop vehicle. Lights remained on and very little brake peddle stoping now. Ford says vehicle is not one of the vin numbers included in recall yet it is the same problem. Car needs to be flushed with dot 4 brake fluid brake fluid cap needs replacing and HUD needs to be replaced for stuck ABS valve.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462825April 30, 2022
VISIBILITY/WIPER, UNKNOWN OR OTHER
Rear windshield tint has hundreds of bubbles, making it impossible to see especially when dark. Theres been many instances where I have not been able to use my car when it’s dark because of the danger. And if it’s raining, I have absolutely no visibility. There’s no words to accurately describe how dangerous this is. I can’t back out of anywhere. The pictures will speak for themselves.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460708April 14, 2022
STEERING
The contact owns a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000. The VIN was not included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456914March 16, 2022
AIR BAGS
I was sent an IMPORTANT SAFETY RECALL April 2021. The problem has never been fixed, and it's been almost a year since it was issued, and no parts are in to fix it?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453863February 24, 2022
STEERING
Power steering has failed multiple times on the vehicle. The dashboard displays 'power steering assist fault' and the steering wheel is locked. This is very dangerous and this vehicle is driven my my 80 year old mother.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453386February 22, 2022
SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact stated that ABS engaged while traveling on an icy road, the brake pedal was depressed to the floorboard. There were no warning lights illuminated. The contact continued driving and the failure corrected itself. The vehicle was taken to an independent mechanic who informed the contact that the ABS control module was sticking and needed to be replaced. The contact stated the failure was related to NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The contact called the local dealer however, the vehicle was not diagnosed or repaired. The manufacturer was contacted but no further assistance was provided. The approximate failure mileage was 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451665February 12, 2022
STEERING
THE POWER STEERING STOPPED WORKING GOING 60 MPH. POWER STEERING ASSIST FAULT. LUCKY TO GET THE CAR STPPED WITH OUT WRECKING . 93500 MILES 2010 MILAN PREMIER. WHY WAS THESE CARS RE CALLED ?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451218February 9, 2022
STEERING:ELECTRIC POWER ASSIST SYSTEM
The contact owns a 2010 Mercury Milan. The contact stated while driving approximately 30 MPH, the power steering failed. The contact stated that while making a right turn the power steering assist warning light illuminated. The contact was able to safely pull over and turn off the vehicle. The contact restarted the vehicle and the power steering assist and Service Advanced Trac warning lights were illuminated. The contact drove the vehicle back to his residence without power assist functionality. The local dealer was contacted and informed of the failure however, the vehicle was not taken to be diagnosed or repaired. The manufacturer was informed of the failure and the contact was informed that the vehicle was not included in NHTSA Campaign Number: 15V340000 (Steering). The failure mileage was approximately 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450381February 4, 2022
SERVICE BRAKES
The problem I am having is with the cars braking system. I have extended brake travel required to stop the vehicle for which I have been issued two recalls. Because of the extended brake travel, I was unable to stop in time and had a front end collision with minor damage, which was not reported. The problem first showed up when I was forced to brake hard a few years causing the ABS to engage. The brake pedal traveled to the floor until the next time the ABS was engaged. Shortly after that, I was issued a recall stating the exact problem I was having. When I took it to my local dealership to get it fixed, they performed a test, changed the brake fluid, and said the system was working properly. It was not. Took it back to the dealership when hydraulic control valve became permanently locked open. They inspected it again and said the ABS unit needed to be replaced but the parts were not available. Contacted FMC customer service, and they were unable to help me either. I asked for a loaner vehicle, and received no response. Since then, I have been issued another recall and am still driving an unsafe car in a Michigan winter. All I want is a safe car to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449698February 1, 2022
SERVICE BRAKES
RE: NHTSA Campaign Number: 19V904000 Manufacturer Ford Motor Company Components SERVICE BRAKES, HYDRAULIC Vehicle regarding complaint: 2008 Mercury Milan Vehicle Vin: [XXX] Good day, In September of 2021 I took the above mentioned vehicle in for the above stated recall regarding the Hydraulic control unit. The vehicle was taken to Westlie Motor Company 500 S Broadway Minot, ND 58701 (701) 852-1354. The vehicle was tested and did in fact fail the test and I was informed the replacement part would be ordered promptly. After two months of no calls from the dealership I stopped in and was told they had no idea about the part. I was assured it would be looked in to. The first week of December I was called and requested the vehicle be brought in for the recall service. I took the vehicle in December 6th and after two hours was notified service was finished. Upon driving home I immediately noticed the problem had not been fixed. I returned to the dealership upon inspecting the vehicle having noticed the NO obvious repairs had been done. Demanding explanation I was told that it was a miscommunication and recall work had not been done. Only a brake flush and cap replacement. I was then again told that they were not sure where the part was or when it would arrive. I then escalated a complaint to Ford motor company ( 1-866-631-3788) Case # [XXX]. I was assure Ford would call the company and inform me intermediately as to the situation and a solution. I received no call back and I again phoned in January with the same result. I was told they would look into it and call me back. I again called today Feb 1st and spoke with Ford and was told the same thing with no solution given. I have been dealing with this recall for nearly 6 months. As per your website states, a company or manufacturer must fix or offer a solution in a reasonable time period. I feel 6 months is long enough to find a part. Please help. I want my car safe for my family. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449117January 27, 2022
AIR BAGS, SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact received notification of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic) and 21V158000 (Air Bags) however, the part to do the recall repair was not yet available. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms part not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448926January 25, 2022
SERVICE BRAKES
For several years, my vehicle has had an issue with "extended brake pedal travel," making it more difficult to come to a stop with a reasonable effort, and increasing the likelihood of an accident. My vehicle has already been repaired for a prior recall regarding "extended brake pedal travel" (this "repair" did not fix this problem; in fact, it apparently passed the Ford-developed test, thus warranting no significant repair. My father is a Ford automotive technician and he was also surprised by this result. I suspect the Ford-developed "test" to determine whether there is indeed a problem was developed in Ford's favor and does not ensure the safety of the customer/driver.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448065January 19, 2022
AIR BAGS, SERVICE BRAKES, HYDRAULIC
The contact owns a 2008 Mercury Milan. The contact stated that he had initially received a recall notice for NHTSA Campaign Number: 17V024000 (Air Bags) and had the vehicle serviced at a dealer. Despite the recall repair, the passenger’s and driver’s side air bag warning lights illuminated. The contact also stated that the ABS warning light was also illuminated on the instrument panel. The contact had yet to experience a brake failure despite the warning light. The contact received notification of NHTSA Campaign Number: 21V158000 (Air Bags) and 19V904000 (Service Brakes, Hydraulic) however, the parts for the recall repairs were unavailable. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 139,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447584January 15, 2022
EXTERIOR LIGHTING, SERVICE BRAKES
Tail and brake light for the second time has failed. A safety function of this nature should not be this difficult to fix and replace. The item should be available and affordable. You literally have to take out a lone to get it fixed. So now I can't go to work or anything else with this vehicle. This is supposed to be an affordable car. So the only way for me right now to fix is park it. I hear one person say " well it's not like a wheel falling off " I said tell that to the person behind me. With all these distractions now, between phones and other fancy options on cars. I'm a truck driver so I know how important these warning devices are. It is time to set a new standard in how safety items get replaced availability and cost should never be an issue.!!!!!!!!! With out question.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447237January 12, 2022
STEERING
My vehicles electric power assisted steering failed. Luckily my 8o year old wife was not at the wheel at the time! Ford is aware of the EPAS problem but earlier refused to correct the problem before it entered full failure mode! Dash Panel warning was displayed after the steering went into failure mode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442954December 7, 2021
STEERING
I backed out of a parking space in a parking lot and turned the steering wheel left then as I put vehicle into "drive" my steering seemed to lock up and became extremely hard to turn. I kept attempting to turn wheel and suddenly it was easily turned again as normal. While I was driving home the power steering stopped working causing steering wheel to feel as if locked again and almost impossible to turn in any direction. I almost wrecked my vehicle and hit another vehicle on the road way but hit my brakes and continued to aggressively turn the wheel to missed the vehicle in front of me. I heard and felt a pop and then steering wheel was easily turned again. I barely missed the vehicle in front of me but I did hit the curb and a bicycle a pedestrian was holding next to him on sidewalk. He was able to jump out of the way and was fortunately unharmed. I stopped my vehicle and parked immediately. I called my husband and he came to get the vehicle and I drove his home. He had no problems driving vehicle home and power steering was working as normal but once he was close to pulling into the driveway, a warning message on dash read "service power steering now".... there were no warning of this problem what so ever and just suddenly happened. Very dangerous and I have read many many others have had same issue with exact make and model of 2010 mercury milan. Please add this issue with power steering to recall list so others don't get hurt. I hurt my neck & wrist when I hit that curb and bicycle. I also had to pay for bicycle I hit.. A code reader was put onto car the next day and gave codes C-1963 and C-1277 if that helps with the recall. Thank you for your time and concern in this matter and I apologize for any inconvenience.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11440735November 17, 2021
EXTERIOR LIGHTING
I was pulled over for my BRAKE LIGHT being out. I went to the dealer and was charged $600 for a brake light assembly. My car has 35,636 miles on it, like new vehicle. Even though it is know defect Ford would not reimburse me for part. I was told it was out of warranty and NOT a saftey issue. I certainly believe that a brake light is a safety issue- especially since they have not replaced my driver side airbag. I think this part should have been recalled and I should be reimbursed. Thank you!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercury Milan