Hyundai Tucson Service Bulletins (2016)
173 manufacturer communications on file.
- September 15, 2017•Document ID: 10118674Service Bulletin/Repair InstructionsSUSPENSION
- Mfr Comm. #:
- 5NP-K9M7J-10
- Date Added:
- October 12, 2017
- Manufacturer:
- HYUNDAI
SummaryDue to parts communization, the rear trailing arms on (TL) Tucsons produced after July 26, 2016 have been revised. This change also affects service parts. Therefore, anytime a rear trailing arm is replaced on (TL) Tucsons produced on or before July 26, 2016 it is necessary to replace both sides. Refer to the repair procedure located in the applicable Service Shop Manual: Suspension System - Rear Suspension System- Trailing Arm - Repair Procedures.
Associated Products (1)Associated Documents - September 6, 2017•Document ID: 10118676Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- 5NP-Y8D3S-10
- Date Added:
- October 12, 2017
- Manufacturer:
- HYUNDAI
SummaryOn certain 2016 - 2017 MY Tucson (TL), intermittently there is no sound from the audio system. This is caused by the instrument cluster not sending the proper CAN signals to the amplifier. This bulletin describes the procedure to reprogram the instrument cluster to correct the signal transmission timing.
Associated Products (2)Associated Documents - August 9, 2017•Document ID: 10117374Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:12V/24V/48V BATTERY
- Mfr Comm. #:
- 5NP-E2C3Q-09
- Date Added:
- September 14, 2017
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Inc. (KBI).
Associated Products (12)Associated Documents - August 3, 2017•Document ID: 10117373Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- 5NP-V3F8T-09
- Date Added:
- September 14, 2017
- Manufacturer:
- HYUNDAI
SummaryIf you are servicing a vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. ? Diagnostic trouble codes: ? P0705 - Range switch sensor circuit ? P0706 - Range switch range/performance ? P0707 - Range switch - open circuit ? P0708 - Range switch - short circuit or multiple inputs ? Symptoms: ? Malfunction Indicator Light (MIL) illuminated ? 4th gear fail-safe ? No gear indication in cluster ? Intermittent no engine crank/no start in ?P? or ?N? with or without MIL or DTC.
Associated Products (56)2018 Hyundai Elantra2018 Hyundai Elantra GT2018 Hyundai Santa Fe Sport2018 Hyundai Sonata2017 Hyundai Accent2017 Hyundai Azera2017 Hyundai Elantra2017 Hyundai Santa Fe Sport2017 Hyundai Sonata2017 Hyundai Tucson2016 Hyundai Accent2016 Hyundai Azera2016 Hyundai Elantra2016 Hyundai Santa Fe2016 Hyundai Santa Fe Sport2016 Hyundai Sonata2016 Hyundai Tucson2015 Hyundai Accent2015 Hyundai Azera2015 Hyundai Elantra+ 36 moreAssociated Documents - March 16, 2017•Document ID: 10110927Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES; ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- 5NP-B6N5A-04
- Date Added:
- August 10, 2017
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the procedure to update both the ECM (Engine Control Module) and the TCM (Transmission Control Module) on some 2016 and 2017 Hyundai Tucsons equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). The update will address: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response. ? Malfunction indicator light illuminated with DTC P0128 - Coolant Thermostat - Coolant Temp Below Thermostat Regulating Temperature.
Associated Products (2)Associated Documents - December 22, 2016•Document ID: 10089504Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:WIRING; TRAILER HITCHES
- Mfr Comm. #:
- 5NP-D8L3J-01
- Date Added:
- January 25, 2017
- Manufacturer:
- HYUNDAI
SummaryTHE 2017 SANTA FE (NC) AND 2016 2017 TUCSON (TL) ARE AVAILABLE WITH A GENUINE HYUNDAI TRAILER HITCH AND WIRING HARNESS. ON CERTAIN UNITS, WHEN THE TRAILERS LIGHTING WIRING HARNESS IS CONNECTED TO THE VEHICLE, THE TOW HITCH MODULE MAY MALFUNCTION RESULTING IN CONTINUOUS ILLUMINATION OF THE TRAILERS BRAKE AND/OR TURN SIGNAL BULB(S). THIS CONDITION AFFECTS ONLY THE TRAILERS LIGHTING; NOT THE VEHICLES. IF A VEHICLE EQUIPPED WITH THE GENUINE HYUNDAI ACCESSORY TOW PACKAGE IS DRIVEN WITH A TRAILER, IT IS POSSIBLE THAT THE TRAILER LIGHTS WOULD BE UNABLE TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS. A FAILURE TO NOTIFY OTHER VEHICLES OF THE DRIVERS INTENT COULD POTENTIALLY INCREASE THE RISK OF A CRASH.
Associated Products (4)Associated Documents - November 14, 2016•Document ID: 10119107Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 5NP-X7Y4J-12
- Date Added:
- October 15, 2017
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the procedure to update both the ECM (Engine Control Module) and the TCM (Transmission Control Module) on some 2016 and 2017 Hyundai Tucsons equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). The update will address: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response. ? Malfunction indicator light illuminated with DTC P0128 - Coolant Thermostat - Coolant Temp Below Thermostat Regulating Temperature.
Associated Products (2)Associated Documents - November 14, 2016•Document ID: 10119093Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 5NP-R6T4X-12
- Date Added:
- October 15, 2017
- Manufacturer:
- HYUNDAI
SummaryHyundai Motor America conducted Recall 149 to update the DCT Control Logic on certain 2016 Model Year Tucson 1.6L vehicles. Recall 149 (16-01-038-01) provides an updated procedure to update the TCU and ECM software. Hyundai Motor America is conducting a revision to Recall to update both the TCU and ECM.
Associated Products (1)Associated Documents - November 14, 2016•Document ID: 10119090Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 5NP-P9A3V-12
- Date Added:
- October 15, 2017
- Manufacturer:
- HYUNDAI
SummaryEco, Sport, and Limited trim 2016 Hyundai Tucsons are equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). In specific operating conditions, the transmission clutch application logic can result in a delayed engagement when accelerating from a stop. If the accelerator pedal is steadily depressed for approximately 1.5 to 2 seconds, the vehicle will begin to accelerate and normal driving is resumed. However, if the accelerator pedal is repeatedly cycled, the vehicle will not accelerate. The inability to move the vehicle in traffic may increase the risk of a crash. Also accompanying with the software are updates for the following: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response. ? Malfunction indicator light illuminated with DTC P0128 - Coolant Thermostat - Coolant Temp Below Thermostat Regulating Temperature.
Associated Products (1)Associated Documents - November 14, 2016•Document ID: 10119089Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 5NP-P8N9N-12
- Date Added:
- October 15, 2017
- Manufacturer:
- HYUNDAI
SummaryHyundai Motor America is conducting a Service Campaign to update both the ECM (Engine Control Module) and the TCM (Transmission Control Module) on certain 2016-17MY Model Year Tucson equipped with DCT. Service Campaign T1B provides a procedure to update the ECM and TCM.
Associated Products (2)Associated Documents - September 9, 2016•Document ID: 10082764Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 5NP-N5Z7L-10
- Date Added:
- October 18, 2016
- Manufacturer:
- HYUNDAI
SummaryEFFECTIVE SEPT. 10, 2016 THE FOLLOWING SERVICE CAMPAIGN WILL END.
Associated Products (1)Associated Documents - September 7, 2016•Document ID: 10082445Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 5NP-X7J3D-10
- Date Added:
- October 14, 2016
- Manufacturer:
- HYUNDAI
SummaryECO, SPORT, AND LIMITED TRIM 2016 HYUNDAI TUCSONS ARE EQUIPPED WITH A 7-SPEED ECOSHIFT® DUAL CLUTCH TRANSMISSION (DCT). IN SPECIFIC OPERATING CONDITIONS, THE TRANSMISSION CLUTCH APPLICATION LOGIC CAN RESULT IN A DELAYED ENGAGEMENT WHEN ACCELERATING FROM A STOP. IF THE ACCELERATOR PEDAL IS STEADILY DEPRESSED FOR APPROXIMATELY 1.5 TO 2 SECONDS, THE VEHICLE WILL BEGIN TO ACCELERATE AND NORMAL DRIVING IS RESUMED. HOWEVER, IF THE ACCELERATOR PEDAL IS REPEATEDLY CYCLED, THE VEHICLE WILL NOT ACCELERATE. THE INABILITY TO MOVE THE VEHICLE IN TRAFFIC MAY INCREASE THE RISK OF A CRASH.
Associated Products (1)Associated Documents - September 6, 2016•Document ID: 10082761Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 5NP-P9D5W-10
- Date Added:
- October 18, 2016
- Manufacturer:
- HYUNDAI
Summary"HYUNDAI MOTOR AMERICA IS CONDUCTING RECALL 149 TO UPDATE THE TCU SOFTWARE ON CERTAIN 2016 MODEL YEAR TUCSON 1.6L VEHICLES. RECALL 149 PROVIDES A PROCEDURE TO UPDATE THE TCU SOFTWARE."
Associated Products (1)Associated Documents - September 2, 2016•Document ID: 10082725Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 5NP-S9D9P-10
- Date Added:
- October 18, 2016
- Manufacturer:
- HYUNDAI
SummaryTHIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).
Associated Products (79)2017 Hyundai Elantra2017 Hyundai Sonata2017 Hyundai Tucson2016 Hyundai Elantra2016 Hyundai Sonata2016 Hyundai Tucson2016 Hyundai Veloster2015 Hyundai Elantra2015 Hyundai Sonata2015 Hyundai Tucson2015 Hyundai Veloster2014 Hyundai Elantra2014 Hyundai Sonata2014 Hyundai Tucson2014 Hyundai Veloster2013 Hyundai Elantra2013 Hyundai Sonata2013 Hyundai Tucson2013 Hyundai Veloster2012 Hyundai Elantra+ 59 moreAssociated Documents - August 17, 2016•Document ID: 10081532Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 5NP-B3N9F-09
- Date Added:
- October 5, 2016
- Manufacturer:
- HYUNDAI
SummaryTHIS BULLETIN PROVIDES INFORMATION FOR NEW SOFTWARE TO UPDATE THE NAVIGATION AND DISPLAY AUDIO SYSTEM TO INCLUDE THE APPLE CARPLAY AND ANDROID AUTO FEATURE. THIS BULLETIN DESCRIBES HOW TO TRANSFER THE UPDATE SOFTWARE TO A STORAGE DRIVE (USB OR SD CARD) AND PERFORM THE SOFTWARE INSTALLATION INTO THE AUDIO SYSTEM.
Associated Products (25)2017 Genesis G802017 Genesis G902017 Hyundai Azera2017 Hyundai Elantra2017 Hyundai Santa Fe2017 Hyundai Santa Fe Sport2017 Hyundai Sonata2017 Hyundai Tucson2017 Hyundai Veloster2016 Hyundai Azera2016 Hyundai Elantra2016 Hyundai Genesis2016 Hyundai Santa Fe2016 Hyundai Santa Fe Sport2016 Hyundai Sonata2016 Hyundai Tucson2016 Hyundai Veloster2015 Hyundai Azera2015 Hyundai Elantra2015 Hyundai Genesis+ 5 moreAssociated Documents - August 9, 2016•Document ID: 10082455Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN:AXLE ASSEMBLY
- Mfr Comm. #:
- 5NP-B6E2P-10
- Date Added:
- October 14, 2016
- Manufacturer:
- HYUNDAI
Summary"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET (ERASE) AND RELEARN THE PCM/TCM ADAPTIVE VALUES. AFTER THE FOLLOWING REPAIRS HAVE BEEN COMPLETED, THE PCM/TCM ADAPTIVE VALUES MUST BE RESET IN ORDER TO PROVIDE OPTIMUM SHIFT QUALITY. IF THE PROCEDURE IS NOT PERFORMED, THE TRANSMISSION MAY EXPERIENCE A SHIFT FLARE OR HARSH SHIFT. H REPLACE AUTOMATIC TRANSAXLE OR PCM/TCM H REPROGRAM OR EXCHANGE A PCM/TCM FROM ANOTHER VEHICLE"
Associated Products (122)2016 Hyundai Accent2016 Hyundai Azera2016 Hyundai Elantra2016 Hyundai Equus2016 Hyundai Genesis2016 Hyundai Genesis Coupe2016 Hyundai Santa Fe2016 Hyundai Sonata2016 Hyundai Tucson2016 Hyundai Veloster2015 Hyundai Accent2015 Hyundai Azera2015 Hyundai Elantra2015 Hyundai Equus2015 Hyundai Genesis2015 Hyundai Genesis Coupe2015 Hyundai Santa Fe2015 Hyundai Sonata2015 Hyundai Tucson2015 Hyundai Veloster+ 102 moreAssociated Documents - August 2, 2016•Document ID: 10081533Service Bulletin/Repair InstructionsPOWER TRAIN:MANUAL TRANSMISSION
- Mfr Comm. #:
- 5NP-Q7S7E-09
- Date Added:
- October 5, 2016
- Manufacturer:
- HYUNDAI
SummaryTHE SHIFT LEVER ON SOME 6-SPEED VEHICLES MAY INTERMITTENTLY NOT SHIFT OUT OF PARK. THIS BULLETIN PROVIDES THE DIAGNOSTIC PROCEDURES TO CORRECT THIS CONDITION.
Associated Products (44)2017 Hyundai Elantra2016 Hyundai Accent2016 Hyundai Azera2016 Hyundai Elantra2016 Hyundai Santa Fe2016 Hyundai Sonata2016 Hyundai Tucson2016 Hyundai Veloster2015 Hyundai Accent2015 Hyundai Azera2015 Hyundai Elantra2015 Hyundai Santa Fe2015 Hyundai Sonata2015 Hyundai Tucson2015 Hyundai Veloster2014 Hyundai Accent2014 Hyundai Azera2014 Hyundai Elantra2014 Hyundai Santa Fe2014 Hyundai Sonata+ 24 moreAssociated Documents - June 21, 2016•Document ID: 10081106Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- 5NP-M5P8Y-07
- Date Added:
- September 29, 2016
- Manufacturer:
- HYUNDAI
SummaryTHIS TSB PROVIDES INTRUCTION ON UPDATING THE NAVIGATION/AUDIO SYSTEM TO INCLUDE APPLE CARPLAY AND ANDROID AUTO FEATURES.
Associated Products (19)2017 Genesis G802017 Genesis G902017 Hyundai Elantra2017 Hyundai Santa Fe2017 Hyundai Santa Fe Sport2017 Hyundai Sonata2017 Hyundai Tucson2016 Hyundai Elantra2016 Hyundai Genesis2016 Hyundai Santa Fe2016 Hyundai Santa Fe Sport2016 Hyundai Sonata2016 Hyundai Tucson2015 Hyundai Elantra2015 Hyundai Genesis2015 Hyundai Santa Fe2015 Hyundai Santa Fe Sport2015 Hyundai Sonata2015 Hyundai TucsonAssociated Documents - May 10, 2016•Document ID: 10082362Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- 5NP-F9E3D-09
- Date Added:
- October 13, 2016
- Manufacturer:
- HYUNDAI
Summary"THIS BULLETIN DESCRIBES STEPS TO ACTIVATE APPLICABLE VEHICLES WITH NAVIGATION OR DISPLAY AUDIO RADIOS THAT HAVE BEEN DE-ACTIVATED FOR THE FOLLOWING REASONS: H A CUSTOMER WHO INITIALLY WAIVES BLUE LINK ENROLLMENT, AND THEN DECIDES TO ENROLL AFTER PURCHASE OF VEHICLE. H A CUSTOMER WHO ALLOWS ALL PACKAGES OF THEIR BLUE LINK SUBSCRIPTION TO EXPIRE AND THEN WISHES TO RE-SUBSCRIBE TO BLUE LINK. H A CUSTOMER WHO DID NOT ENROLL IN BLUE LINK WITHIN THE FIRST 30 DAYS OF OWNERSHIP (AT WHICH TIME THE DEVICE BECOMES INACTIVE), BUT THEN DECIDES TO ENROLL. H A SUBSEQUENT OWNER WHO WISHES TO ENROLL IN BLUE LINK."
Associated Products (27)2017 Genesis G802017 Genesis G902017 Hyundai Azera2017 Hyundai Elantra2017 Hyundai Santa Fe2017 Hyundai Santa Fe Sport2017 Hyundai Sonata2017 Hyundai Tucson2017 Hyundai Veloster2016 Hyundai Azera2016 Hyundai Elantra2016 Hyundai Genesis2016 Hyundai Genesis Coupe2016 Hyundai Santa Fe2016 Hyundai Santa Fe Sport2016 Hyundai Sonata2016 Hyundai Tucson2016 Hyundai Veloster2015 Hyundai Azera2015 Hyundai Elantra+ 7 moreAssociated Documents - April 27, 2016•Document ID: 10082283Service Bulletin/Repair InstructionsTRAILER HITCHES
- Mfr Comm. #:
- 5NP-X4N7R-09
- Date Added:
- October 13, 2016
- Manufacturer:
- HYUNDAI
Summary"HYUNDAI MOTOR AMERICA IS LAUNCHING RECALL 142 FOR CERTAIN 2016 MY TUCSON VEHICLES. IF AN AFFECTED 2016 TUCSON EQUIPPED WITH THE HYUNDAI ACCESSORY TOW PACKAGE IS DRIVEN WITH A TRAILER, IT IS POSSIBLE THAT THE TRAILERS LIGHTS WOULD NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS."
Associated Products (1)Associated Documents