Freightliner · Model Report
Showing safety data for the 2026 model year only.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2024-2026 Western Star 47X, Freightliner Business Class M2, FCCC MT55G, 2025-2026 Western Star 49X, Freightliner Cascadia, Freightliner 114SD, FCCC MT45G, FCCC S2RV106, 2026 Thomas Built Buses Saf-T-Liner C2, Freightliner eCascadia, FCCC S2C106, and Freightliner 108SD vehicles. The tie rod castle nut and cotter pin may not be installed properly, which can result in a loss of vehicle steering control.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2025 FCCC XCR, FCCC XBS, FCCC MT45, Western Star 57X, 2025-2026 Freightliner Business Class M2, Freightliner Cascadia, Freightliner 114SD, Freightliner 108SD, FCCC MT55G, FCCC MT45G, FCCC XCP, FCCC XCM, Western Star 49X, Western Star 47X, 2026 Freightliner Cascadia 5th Gen, FCCC MT55, and FCCC MT50E vehicles. The brake caliper mounting bolts may loosen and detach, which can cause a loss of brake function and damage the tire and/or wheel.
Daimler Trucks North America LLC (DTNA) is recalling certain 2026 Freightliner Cascadia Fifth Gen vehicles. The compressed natural gas fuel line was routed incorrectly, allowing it to chafe and damage wiring harnesses and brake lines.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2026 Freightliner eM2, Freightliner 108SD, Freightliner 114SD, Freightliner Cascadia, 2025-2026 Freightliner Business Class M2, Western Star 47X, and Western Star 49X vehicles. A software error in the advanced signal and actuator module for the automatic emergency braking system may cause the brake lights to fail to illuminate.
The contact owns a 2026 Freightliner Cascadia equipped with Goodyear Tires, Tire Line: Endurance LHS, Tire Size: 11R22.5, DOT Number: (N/A). The contact owns a fleet service and stated that within the last 50 days, 18 similar tires had sustained sidewall splitting. The contact stated that the failures were exclusively on the inner dually positions on the vehicles. The cause of the failures was not yet determined. The dealer was notified of the failure. The manufacturer was not notified of the failure. The tire failure mileage was unknown. The VIN was not available.
No injuries · No fire · No crash
On May 24, 2026, while driving home from the Ocotillo Wells OHV Recreation Area toward San Diego, California, a drive of roughly 90 miles, a dashboard warning reading "Stability Controls Not Working" illuminated on [XXX] near Warner Springs in San Diego County. The vehicle is a 2026 Freightliner Cascadia chassis carrying a Renegade Classic 43CMD Super C motorhome body. The vehicle was approximately six weeks old with about 3,100 miles. I stopped the vehicle and attempted to clear the fault by cycling the chassis power; the warning did not clear. I completed the drive home with a passenger aboard, aware that the stability control system was reporting itself inoperative. On XXX I delivered the vehicle to Velocity Truck Centers, an authorized Freightliner service center in San Diego, California, recorded at 3,189 miles under service invoice XXX and warranty claim XXX. The technician recorded the cause as "ABS ECU SHORTED." His written correction states that he verified the ESC light was on, ran end-of-line code 1810/2 which did not clear the fault, confirmed the ESC module was mounted level and tight, unplugged the connector and drag tested all four pins and found them good, and concluded that the ESC module was shorted out. He removed the old module and installed a new one, which required calibration on a road test; the unit passed the road test. The replacement part is listed as ECU-ESC6, part number 446 065 095 0. An internally shorted electronic stability control module on a six-week-old vehicle with roughly 3,100 miles, on a motorhome of this size and weight carrying occupants at highway speed, is a safety concern. I am filing this complaint so the failure is documented for safety-trend and potential recall analysis. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
On August 1st, I was travelling on I-44 (a toll road with an 80 mph speed) near Claremont Oklahoma. I was doing 68 mph when a red warning message came up on my dash. It read...KINGPIN RELEASE ACTIVATED. STOP IMMEDIATELY! KINGPIN RELEASED WITHOUT REQUEST. I did not touch my brakes. I gently moved to the the shoulder and coasted to a stop...so as not to put any pressure on the kingpin or fifth-wheel and hoping the weight of the trailer would hold it in place til I could stop. I checked under my truck and the lock was perfectly across the jaws. It did NOT turn loose, thankfully. Our road breakdown dept and Tulsa Freightliner could not say what the problem was. Freightliner replaced the kingpin release button on the dash and hoped that was the fix. The service manager told me if it happened again, they would have to keep the truck at least a week and Dahmler would be opening a file on the problem. I know that means they don't know what happened.
No injuries · No fire · No crash