The contact's former employer owns a 2022 Freightliner Cascadia Commercial vehicle. The contact stated that while a company's technician was performing a preventative maintenance service on the vehicle, an exhaust leak was discovered; however, the technician informed the contact that the vehicle was safe to drive. While driving 65 MPH, the contact fell asleep, causing the vehicle to drift into the median. Another driver approached the vehicle and sounded the horn, waking the contact, who then pulled over to the side of the road. The contact reported the incident to a manager, who suspected potential carbon monoxide poisoning and advised the contact to seek medical attention; however, a senior manager instructed the contact's manager that the contact had to complete the delivery services or resign. The contact received medical treatment from a neurologist and a pulmonologist. The neurologist informed the contact that he sustained acute dementia because of the carbon monoxide inhalation. The contact also experienced post-traumatic stress disorder (PTSD) and a fear of driving, and the contact was receiving Social Security Disability assistance. The contact associated the failure with Daimler Trucks North America Emission Recall Campaign Number: FL922, which was previously performed on the vehicle. A second technician inspected the vehicle, confirmed the exhaust leak, and informed the contact that it posed a life-threatening risk. The vehicle was repaired. The manufacturer was notified of the failure but denied responsibility. The failure mileage was approximately 128,113.
The contact owns a 2026 Freightliner Cascadia equipped with Goodyear Tires, Tire Line: Endurance LHS, Tire Size: 11R22.5, DOT Number: (N/A). The contact owns a fleet service and stated that within the last 50 days, 18 similar tires had sustained sidewall splitting. The contact stated that the failures were exclusively on the inner dually positions on the vehicles. The cause of the failures was not yet determined. The dealer was notified of the failure. The manufacturer was not notified of the failure. The tire failure mileage was unknown. The VIN was not available.
No injuries · No fire · No crash
On May 24, 2026, while driving home from the Ocotillo Wells OHV Recreation Area toward San Diego, California, a drive of roughly 90 miles, a dashboard warning reading "Stability Controls Not Working" illuminated on [XXX] near Warner Springs in San Diego County. The vehicle is a 2026 Freightliner Cascadia chassis carrying a Renegade Classic 43CMD Super C motorhome body. The vehicle was approximately six weeks old with about 3,100 miles. I stopped the vehicle and attempted to clear the fault by cycling the chassis power; the warning did not clear. I completed the drive home with a passenger aboard, aware that the stability control system was reporting itself inoperative. On XXX I delivered the vehicle to Velocity Truck Centers, an authorized Freightliner service center in San Diego, California, recorded at 3,189 miles under service invoice XXX and warranty claim XXX. The technician recorded the cause as "ABS ECU SHORTED." His written correction states that he verified the ESC light was on, ran end-of-line code 1810/2 which did not clear the fault, confirmed the ESC module was mounted level and tight, unplugged the connector and drag tested all four pins and found them good, and concluded that the ESC module was shorted out. He removed the old module and installed a new one, which required calibration on a road test; the unit passed the road test. The replacement part is listed as ECU-ESC6, part number 446 065 095 0. An internally shorted electronic stability control module on a six-week-old vehicle with roughly 3,100 miles, on a motorhome of this size and weight carrying occupants at highway speed, is a safety concern. I am filing this complaint so the failure is documented for safety-trend and potential recall analysis. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The front sensor is calibrated wrong. It slams my brakes on road if a shadow is in road, bridges, vehicles parked on side of road, and sometimes if another semi passes me it slams the breaks on. It happens if its just raining out not so much winter because snow and ice blocks the sensor. This has also almost caused accidents as well.
No injuries · No fire · No crash
while driving a UPS Freightliner truck (Cascadia Vin number [XXX] ) on [XXX] on [XXX] in Charlotte, North Carolina, the tractor brakes locked down causing [XXX] 's arm to jam into shoulder from having all momentum come to abrupt stop causing seatbelt to yank across shoulder ultimately necessitating surgery and putting me out of work for 6 months+ and ongoing INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)