Ford · Model Report
Showing safety data for the 1984 model year only.
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
SECONDARY HOOD LATCH COMPONENTS MAY HAVE BEEN IMPROPERLY POSITIONED DURING ASSEMBLY. IF THE HOOD IS NOT CLOSED TIGHTLY, OR IS INADVERTENTLY RELEASED, THE SECONDARY LATCH MAY NOT WORK AND THE HOOD MAY FLY UP WITHOUT PRIOR WARNING.
WEIGHT RATING INFORMATION IS INCORRECT ON VEHICLE MANUAL LABELS AND RATING DECALS.
IF TRUCK IS STRUCK FROM THE SIDE, THE CAP ON THE FUEL TANK COULD BECOME UNSEALED, ALLOWING UNSAFE LEAKAGE OF FUEL. THIS IS A FAILURE TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, "FUEL SYSTEM INTEGRITY". LEAKAGE CAN BE CAUSED BY AN ORANGE-COLORED PLASTIC DIESEL FUEL INFORMATION RING WHICH IS FOUND AROUND THE FUEL TANK NECK, OR BY THE TETHER.
THE VEHICLE STALLED WITHOUT WARNING. *JB
No injuries · No fire · No crash
NO SUMMARY
No injuries · No fire · No crash
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NOTICED IN LOCAL PAPER CONCERN OVER FIRES IN HEATING/VENTILATING SYSTEM OF FORD VEHICLES. BURNING OF LEAVES CAUGHT IN HEATER DUCTING WHICH WAS IGNITED BY HEATER MOTOR SPEED CONTROL RESISTANCE COILS LOCATED IN HEATER DUCTWORK HAS HAPPENED TWO TIMES ON MY 1984 FORD RANGER PICKUP. THE FIRST TIME WAS IN THE LATE 1980'S IN OCTOBER OR NOVEMBER AND THE LATEST INCIDENT WAS OCTOBER OF 1997. HORTOCULTURIST AT BOTANICAL GARDEN WHERE I VOLUNTEER HAD A SIMILAR FIRE IN JANUARY OF 1999 IN A 1980'S FULL SIZED FORD PICKUP (DON'T KNOW EXACT YEAR). ALTHOUGH THIS TYPE OF FIRE IS SHORT AND DOES NOT APPEAR TO DO A GREAT AMOUNT OF DAMAGE; IT IS VERY DISTURBING AT THE TIME. YOUR VISIBILITY IS CLOUDED, YOU IMMEDIATELY GET OFF OF ROAD TO GET OUT OF 'BURNING' VEHICLE AND FOR SOME TIME VEHICLE HAS ASHES BLOWING FROM VENT SYSTEM AND ODOR OF SMOLDERING LEAVES LEFT IN VEHICLE. THIS COULD BE A SIGNIFICANT TRAFFIC SAFETY OCCURANCE IF TRAFFIC WAS HEAVY AND CONTROL OF VEHICLE WAS LOST OR ONCOMING TRAFFIC HIT VEHICLE AS IT WAS BEING STOPPED TO CHECK SOURCE OF THE 'FIRE'. I NOTICE THAT THE 1992 FORD E-150 VAN WHICH WE OWN HAS A FINER MESH SCREEN BELOW THE VENT AIR INTAKE IN FRONT OF THE WINDSHIELD; WHEREAS, THE 1984 (AND OTHER) FORD VEHICLE DOES NOT. WHEN I CAN REMEMBER EACH YEAR, I REMOVE THE HEATER CONTROL SWITCH FROM THE DUCTING AND FISH OUT THE LEAVES WITH A PIECE OF WIRE THROUGH THE SMALL ACCESS HOLE. DON'T REMEMBER TO DO THIS EVERY YEAR--AND I EXPECT MOST OWNERS DON'T OR DON'T KNOW HOW AND FORD DEALERS PROBABLY ARE NOT AWARE THAT THIS IS A POTENTIAL SAFETY ISSUE WHICH SHOULD BE ADDRESSED.
THE DESIGN AND LOCATION OF THE OPEN WIRE WOUND MOTOR SPEED CONTROL RESISTOR BLOCK ALLOWS FOR DEBRIS TO COLLECT RESULTING IN VEHICLE FIRE AND INJURY TO CONSUMER. (ATTORNRY FOR CONSUMER).