Ford Focus Complaints

22,326 consumer complaints on file.

#11477383August 3, 2022
WHEELS
When a transmission recall was corrected I was advised that the lug nuts were warping and needed to be replaced. Substandard lug nuts should be covered by the manufacturer
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477412August 3, 2022
POWER TRAIN
Transmission occasionally fails to shift into reverse and has issues properly shifting gears automatically. Gear shifting has been a very minor issue for at least 5 years, only happened once. In the past week, the issues mentioned in first sentence has grown progressively worse starting with minor juttering when gears are shifted higher. Reverse issue has started at the start of this week, and the juttering has gotten worse. Vehicle is available for inspection upon request at this time. Vehicle fails to speed up when acceleration is applied for a good while, engine reving into 4000-5000 rpm range before it corrects itself after 5-10 seconds. Acceleration issues may cause collision issues with drivers following. Lack of reverse leaves vehicle requiring to park in ways it can drive forward or roll back out of the parking spot, making parking more dangerous. This system has been a part of a prior recall. Since the recall was supposedly fixed, the system has not been inspected since. The check engine light illuminates from time to time, mainly when the vehicle can't reverse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477467August 3, 2022
FUEL/PROPULSION SYSTEM, STRUCTURE:BODY
There is a warning light showing a code 1450, unable to create fuel vacuum, that at first was thought to be an issue with a current recall for the car that was fixed. But after a routine oil change a fuel leak was found. I was told by the mechanic that it appears to be a fuel tank deformation similar to the 19S22 recall. My Ford focus was not apart of that recall and I was told by Ford to contact you to potentially have my car added. The leak is subnational enough that it could cause an engine fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477115August 2, 2022
POWER TRAIN
The contact owns a 2018 Ford Focus. The contact stated that while driving the clutch was sticking. The vehicle hesitated and almost stopped before shifting into gear. The check engine warning light was illuminated. The transmission overheating message was displayed. The vehicle was towed to an independent mechanic who informed the contact that the transmission needed to be replaced. The contact called the local dealer who informed her that the clutch was rusted; however, the vehicle was not diagnosed or repaired. The contact stated the failure was similar to NHTSA Campaign Number: 18V845000 (Power Train). The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 82,171,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477179August 2, 2022
POWER TRAIN
The contact's son owns a 2015 Ford Focus. The contact stated while her son was driving 65 MPH, the vehicle decelerated to 20 MPH independently. The contact did not know whether there was a warning light illuminated. The contact's son drove to the dealer but the vehicle was not diagnosed or repaired. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer where the gearbox and the transmission clutch were replaced; however, the failure reoccurred. The contact stated that the vehicle was shuddering and jerking significantly while driving. The contact stated that while her son was attempting to reverse, he moved the gear shifter into reverse but the vehicle failed to respond. The vehicle was taken back to the dealer. The vehicle was not repaired. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477219August 2, 2022
POWER TRAIN
Ford extended the warranty for the Transmission Control Module to 150,000 miles. Mine has failed at 160,000 miles but there is possibility for extension through Ford, they stated that this mileage is set by NHTSA. I don't mind repair cost, but to add insult the part is not available for 2 months as stated by the service department at the dealership. With current market situation, the mileage should be extended. This failure makes the car unsafe to drive, Ford should extend the warranty mileage further, especially in the current market of vehicle availability. Also, Ford needs to work with a supplier to improve lead times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476944August 1, 2022
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated that while driving approximately 40 MPH and merging into traffic, the vehicle inadvertently shifted out of gear and the engine started revving loudly. The contact depressed the accelerator, and the vehicle failed to respond. The contact stated that the vehicle decelerated to 25 MPH and the transmission independently shifted back into drive (D). The contact stated that no warning light was illuminated. The failure had become recurring. Additionally, the contact stated that it then became difficult to shift into reverse (R). The vehicle was also occasionally difficult to start. The contact stated that after shifting from park (P) to drive (D) with the vehicle turned off, there was a message displayed stating that “Transmission Ready”, start the vehicle. The contact drove the vehicle to a dealer; however, the vehicle had not been diagnosed or repaired. The manufacturer had been informed of the failure. The contact researched the failure online and related it to NHTSA Campaign Number: 22V413000 (Power Train). The failure mileage was approximately 90,000. The contact stated that the part necessary to repair the vehicle is the same one Ford includes in the extended warranty. So, they are unsure as to why their VIN is not included in the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476963August 1, 2022
ENGINE, FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
The contact owns a 2018 Ford Focus. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to the dealer who diagnosed that the EVAP system was leaking and that the fuel tank needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 76,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476986August 1, 2022
POWER TRAIN
I own a 2018 Ford Focus and am experiencing the same symptoms as other 2018 Focuses involved in NHTSA Campaign #18V845000, however my VIN was not part of the batch that was recalled. The car stutters/shudders when accelerating at low speeds/take off. It switches gears hard, often with a jerk or a clunk. It also switches gears inconsistently, ramping the RPMs at times. We visited the Ford dealership on 3 separate occasions to address this issue to no avail. The third time was 7 months after I purchased the vehicle - 1 month too late to qualify as a lemon under my state's lemon laws. I believe this recall needs to be expanded to include other 2018 Ford Focuses sooner rather than later.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477015August 1, 2022
FUEL/PROPULSION SYSTEM, POWER TRAIN
01/08/2019- Vehicle was checked for fuel tank deformation (18S32) Vehicle Mileage 65,162 the technician comments read as follows (check dtcs, check for available PCM software update, no available software update, no parts replaced) 07/26/2022- Vehicle was brought to Billy Howell Ford Lincoln Dealership for a permanant emmissions code PO442. Ford Corporate arranged the Diagnostic appointment. The technician comments read as follows (checked dtc's. found multiple DTC's set in various modules. PO442 is only fault set in PCM. checked OASIS, no relevant information found. performed EVAP system test, passed. performed EVAP purge and seal test, passed. connected smoke machine to test for leaks. EVAP smoke machine measured a leak of approxamitely .040", near acceptable range. visual inspection during EVAP leak test, found smoke emitting from vapor canister fresh air vent tube, indicating EVAP vapor canister vent leakage. recommend replacing EVAP vapor canister and retesting. 07/30/2022- I took vehicle to have the EVAP vapor canister replaced mechanic noticed that the fuel tank was slightly deformed. I drove the vehicle approxamitely 120 miles so the PCM would cycle and clear the permanent code . Fuel guage was on empty w/light on. I stopped at gas station I put 26 dollars of e-85 in vehicle. when i returned to car the fuel gauge was reading full DTE 418 miles. The gauge was reading innacurate. I drove the car about 40 miles before it stalled and it would not start. I waited a few minutes and tried to start the vehicle and it started . Iimmediately drove home and parked it in the garage. All of these symptoms point to the recall (18S32) Billy Howell Ford say's my recall was already completed and I cant recall it again. The vehicle has never received a PCM reprogramming for the fuel tank (19S22) Ford was supposed to reprogram the PCM software back in 01/08/2019 when they checked for the tank deformation . Withouty the software update and necessary repairs. its a risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477022August 1, 2022
POWER TRAIN
The contact owns a 2015 Ford Focus. The contact stated while driving at an undisclosed speed and attempting to accelerate, the vehicle failed to respond. The vehicle was taken to the dealer and the contact was informed that the vehicle was included in NHTSA Campaign Number: 18V169000 (Power Train). The vehicle was repaired however, the failure persisted. The vehicle was taken back to the dealer and received a second repair for the failure. The failure recurred after the repair. The dealer was contacted and informed of the failure. The contact was referred to the manufacturer. The manufacturer was contacted and stated that the vehicle was no longer under warranty. The failure mileage was 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476840August 1, 2022
POWER TRAIN
The contact owns a 2014 Ford Focus. The contact stated that she was unable to start the vehicle. The contact stated that the parking aid malfunction warning message was displayed. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the transmission control module to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 50,700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476759July 31, 2022
POWER TRAIN
I was at stop light. When I accelerated the car jerked then went into gear. It was fine until I had to stop and go again. Then an engine light came on. Then it said the trans is to hot, Pull over safely. Then it said to wait 5 minutes to let it cool down. Now I have to find a way to get it to a shop and try and repair it. It's a 2014 Ford Focus with 70.000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476643July 30, 2022
POWER TRAIN
Same transmission fluttering when you take off as the recalls for up to 2016 years, but for some reason my car’s vin doesn’t show up as covered. Help!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476676July 30, 2022
POWER TRAIN
On Friday July 15th around 7PM, my wife and I were driving out of town to visit family. We stopped at a gas station along the highway to make sure we had gas an everything before getting too far out of town. We had no issues when we stopped but after leaving we tried getting on the highway and after merging the car reved up very high and seemed to have dropped into a low heat like 1st or 2nd. We attempted to get off the highway but with this low gear the car could not do more than about 20Mph. We finally made it off the highway and checked everything we could think of that could cause this issue but found nothing. We had to get the car towed home because besides being stuck in a very low forward gear when shifting to drive, we also lost reverse. After being towed home we parked the car to see if this just needed to cool off and come back to it later. We let it sit for a few days and now the car is disabled. It turns on and runs smooth but the transmission is non-operational. We no longer have any gear control and can only turn the engine on. I called Ford about this issue but was not helped in any way. Just asked to pay for a diagnostic.I don’t think I will be buying any more Ford vehicles since they could not fix this issue after so many years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476680July 30, 2022
FUEL/PROPULSION SYSTEM
Car turns off after filling with gas. Does not start properly after refilling tank. If I stop sometimes even in traffic it’ll automatically turn off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476492July 29, 2022
POWER TRAIN
The contact owns a 2017 Ford Focus. The contact stated while driving approximately 15 MPH, the vehicle was shuddering while shifting gear. There was no warning light illuminated. The vehicle was previously diagnosed with transmission failure. The vehicle was repaired with a new clutch and linkage; however, the failure recurred. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476498July 29, 2022
POWER TRAIN
Failure of the encase power train transmission. Delay is shifting & transmission to shift gears gets stuck. COMPLETELY unsafe when pulling out into traffic. Driver is unsure if the transmission will engage or not. Unable to accelerate at times until transmission engages. Sounds like gears are being stripped on the automatic Transmission. Started in May 2021 & continues to happen daily.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476543July 29, 2022
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
The vehicle needs PCM and TCM replacement. Stalls while braking or apply pressure to gas peddle while driving, faulty gear changing mechanism has issues switching to proper gear due to the underlying problems above. It has turned off while driving on the interstate without warning. May instantly stop while applying minor pressure to brakes. Has been inspected by mechanic and AutoZone employees confirming the issues. It is unsafe due to the instant stopping or applying to breaks behind another driver almost hitting them or causing someone to hit from behind. Furthermore, inaccurate gear changing causes an increase rapidly in speed or very slow in speed which could lead to accidents.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476548July 29, 2022
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2012 Ford Focus. The contact stated while driving at approximately 60 MPH, the vehicle shuddered and inadvertently downshifted. The contact stated that the downshifting occurred while accelerating to merge into traffic. The contact stated that the failure was intermittent but had since become constant. The contact stated that the transmission control module warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission control module needed to be replaced. The dealer informed the contact that the part was not available and he would be placed on a waiting list. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 101,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Focus