Ford Bronco Sport Complaints

1,315 consumer complaints on file.

#11699101November 13, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Bronco Sport. The contact stated that occasionally, while driving at various speeds uphill, the vehicle hesitated to accelerate as intended while the accelerator pedal was depressed. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The engine temperature gauge warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698868November 12, 2025
SERVICE BRAKES
On November 11, 2025, my 2021 Ford Bronco Sport experienced a complete brake system failure while driving. The brake pedal suddenly became extremely hard, and there was no braking power at all. The vehicle had to be stopped using the parking brake. This same issue occurred previously in July 2025, when the brake vacuum booster failed and was replaced at the Ford dealership. The problem has now recurred less than six months later. The vehicle is not safe to drive and is available for inspection upon request. My safety and the safety of others were put at risk because the brakes failed completely without warning while the vehicle was in motion. If traffic conditions had been heavier, a collision could have occurred. The issue has not yet been confirmed by the dealership for this most recent occurrence, but the same Ford dealer that repaired it in July handled the prior failure. The vehicle will be towed there again for inspection. No warning lamps or dashboard messages appeared before or during either failure. The only symptom was a sudden loss of brake assist and a hard, unresponsive brake pedal. This appears to be a repeated failure of the brake vacuum or brake assist system, which I understand has been part of a previous Ford recall (21C31) affecting 2021 Bronco Sport models. But my VIN number was not included in the Recall. This is my second reporting and needs to be recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698649November 10, 2025
STRUCTURE:BODY
The firewall on the passenger side was not sealed correctly causing water to enter behind the glove box affecting the blower motor and causing water to enter the vehicle. Causing mold under the carpet. The leak was confirmed at the Ford dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698200November 7, 2025
FUEL/PROPULSION SYSTEM
When I try to pump gas, I often will start the gas pump and then it will stop after only filling up about a third of a gallon. It doesn’t happen with every gas pump, but it happens frequently enough that it has become very frustrating. I end up not being able to put gas in my car at times and I have to drive to another gas station. I thought there had been a recall on this issue before and it had been resolved, but I have still been experiencing issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698123November 7, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697990November 6, 2025
ELECTRICAL SYSTEM, ENGINE
In 2024, we had our battery replaced in our 2021 Bronco Sport by the Ford certified dealer in response to Recall Number 24S24. We did not have any issues with the previous battery. They replaced the original battery with the AGM battery, which they represented would prevent the issues that necessitated the recall - catastrophic degradation of the battery and complete loss of drive power. In mid-October 2025, my wife experienced unexpected and complete loss of drive power when exiting the interstate in the car, and was stuck in the freeway exit lane as oncoming traffic was exiting at high speeds with minimal time to avoid the stalled car. It was a dangerous situation and the car was almost struck numerous times. No warnings or messages appeared - even the hazards did not work. After about 20 minutes, we were finally able to obtain assistance from a police officer and had the car towed to a Firestone a few blocks away. Firestone confirmed that the AGM battery had failed which caused the complete loss of drive power. They replaced the battery and reprogrammed the car as best they could, but the failure of the battery also destroyed a few computer chips that needed to be replaced by Ford in order to fully reprogram it. We took it to the Ford dealership that initially replaced the battery (10 miles away) the next day, and Ford refused to refund us the costs for towing the car and replacing the battery at the Firestone, claiming our situation did not constitute an "emergency" since we could have had it towed 10 miles to the Ford dealer rather than a few blocks to the Firestone. As we did not know what was wrong with the car, we reasonably chose the Firestone as the best option, since it was only a few blocks away. Ford replaced the computer chips under the recall, but we have still paid over $600 out of pocket due to this incident that Ford refuses to pay us. The Ford dealership also took the battery when we requested the refund, and has not returned to us the battery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697695November 5, 2025
FUEL SYSTEM, GASOLINE
The contact wife owns a 2023 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, there was an abnormal fuel odor entering the interior cabin through the air vents. No warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697604November 5, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer and two other dealers were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697602November 5, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Bronco Sport. The contact stated that while driving approximately 35 MPH, the check engine warning light illuminated, and it felt as if there was no gasoline going to the engine. The contact stated that while depressing the accelerator pedal there was an abnormal sound coming from the engine compartment. The contact had not taken the vehicle to a local dealer or an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The contact was aware of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part for the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696884October 31, 2025
POWER TRAIN
I am submitting this letter to report a potentially widespread safety defect in the 2021 Ford Bronco related to the rear differential assembly. Many owners, including myself, have experienced or are concerned about premature failure of the rear differential under normal driving conditions. This issue can lead to loss of vehicle control and represents a significant safety risk on public roads. Ford Motor Company appears aware of the recurring nature of this defect but has not, to date, issued a recall or extended coverage for affected vehicles. I am requesting that NHTSA investigate this issue as a possible design or manufacturing defect that warrants a formal recall or technical action from Ford. Description of Issue: Premature rear differential failure / widespread owner reports Problem has been reported to Ford Motor Company as well as Sutton Ford Dealership. They did the inspection and diagnosed it. I took my vehicle to that dealership numerous times and told them about the noise I was experiencing and it came back no problems found. This truck has had several recalls and problems since it rolled off the assembly line.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696743October 31, 2025
SEAT BELTS
I removed a car seat from back passenger seat, closed the door, buckled another child into the rear drivers side , drove to grocery no more than 25mph, as I was pulling into parking spot, car came to hard stop, jerked us, got out walked around the car to find that the rear passenger seatbelt did not retract yet was long enough to get caught under my back tire causing the car to stop hard while foot was in gas. Safety concern, what if we were in the highway going hi speeds? Why are the seatbelts that long that it can get caught under a tire? There is no person that would need that much belt who could even fit in the back of this tiny car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696691October 30, 2025
POWER TRAIN
Vehicle is experiencing issues with shuttering from the rear differential and a 4wd fault code with vehicle just out of warranty. Rear differential speed sensor has failed and possibly need entire rear differential unit relaxed I’m told. Also water pump on engine has failed prematurely with ford avoiding responsibility
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696609October 30, 2025
UNKNOWN OR OTHER
extreme loud vibrating noise coming from sunroof while driving at or above 35 mph. it may be bad design for rubber seal and body trim for the sunroof. for example: automatic car washing - hard rolling brushes hitting the top of the vehicle during the wash process, then there is the high pressure water rinsing from different directions, followed by a high wind vortex that causes every exterior surface extreme pressure and force. so, a few trips to the car wash, now causes your sunroof seal failure which may lead to a sunroof blow out while driving at 60mph on the high way... please ALERT ALL to this danger. sunroof seal failure. sunroof blowout. sunroof vibrating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696303October 29, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696211October 28, 2025
SEAT BELTS
The middle seat belt doesn’t function and the dealership will not address this safety problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696176October 28, 2025
ENGINE, POWER TRAIN
On 7/22/2025 Luther Ford, When asked to drive the vehicle into the service area, the car would not go in to drive. It would not move at all. The service advisor stated we need to have the transmission taken out and taken apart to see what the issue is. He said that the transmission was needing to be replaced, and with the transmission, it is mostly because of an issue with the motor as well, but this cannot be diagnosed until the transmission issue is corrected. The vehicle is still at Luther Ford in Fargo waiting on repair. Ford offered limited financial assistance for this. With myself still owing $5758.38. There have been multiple times that I have requested the dealership drive the vehicle because of the vehicle shifting hard or cutting out when stepping on the gas. On 3/3/2023 20,991 miles I had taken the vehicle in to RM Stoudt in Jamestown, ND because the car was shifting hard, and was cutting out while in low gear/speeds. I do have documentation of this. Nothing was done at this time by the dealership. 10/3/2024 46,277 miles I had the bronco into Devils Lake Cars for an issue with the CV Shaft and warranty work. I also asked them to drive the vehicle because it is STILL not driving correctly and is not shifting correctly and wanted it to be corrected before warranty was up. Nothing was done at the dealership. Before 60,000 I called Devils Lake Cars. I stated that the vehicle is still having issues. I was not going to be able to get to the dealership as I live in a remote area, until after it goes over the 5/27/25 62,354 miles I finally got an appointment and the vehicle in at Devils Lake Cars, they documented thatthey drove the vehicle and there were NO issues. I requested the next time that we are in, that we ride with the service agent so we can prove the issues we are constantly having. 7/22/25 2500 miles later, the car is no longer able to even be put into drive and this brings us to the current situation and the transmission is needing to be replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696088October 28, 2025
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
I took my vehicle into my local ford dealership to get three active recalls remedied. Within 24 hours, my check engine light reappeared as well as "service engine soon" on my way into work. Upon leaving work, the dash lights were gone. They would come and go periodically. After about a week, it would pop up "service engine soon" and within ten minutes, regardless of speed, the RPMs would fly all the way up and the vehicle would act as if I took my foot off of the gas, almost immediately stopping on the highway. I would have to almost immediately pull off of the road and my vehicle would stall, flashing "shift system failure" as well as failing to let me put the vehicle into park or any other gear. Taking it into the shop, they told me that was due to a software bug WHICH THEY JUST "FIXED" with a recall update. They also proceeded to tell me there is metal debris in my oil and I need my transmission rebuilt, quoting me $13,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695797October 27, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Bronco Sport. The contact was made aware of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The contact had not received the recall letter from the manufacturer. The contact called the local dealer and was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695272October 23, 2025
FUEL/PROPULSION SYSTEM
After Ford completed Recall 25S76 on my 2021 Ford Bronco Sport (VIN [XXX] ), which involves replacing high-pressure fuel injectors due to the risk of cracking and fuel leaks, the check engine light returned immediately after the road test. The Ford dealer’s diagnostic confirmed: “After installing high-pressure fuel injectors, cleared codes, road tested and check engine light came back on, performed further P/P test, found high-pressure fuel pump with internal fault which caused a back-pressure concern and took out low-side fuel pump.” The high-pressure fuel pump and low-side fuel pump both failed immediately following the recall injector replacement, which appears to indicate a related fuel-system failure. Ford has stated these are not related issues and has only offered partial goodwill assistance, leaving a significant cost for the customer. Component/system that failed: Fuel system – high-pressure fuel pump and low-side fuel pump (available for inspection). Safety risk: A fuel-system failure can cause stalling or loss of power while driving, increasing the risk of an accident. Confirmed by dealer: Yes – documented in the Ford dealer’s diagnostic notes. Inspected by manufacturer: Yes – Ford dealer completed the diagnostic under Ford’s guidance. Warning lamps or symptoms: Check engine light returned immediately after recall work. No prior symptoms before recall repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695194October 23, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport