Chevrolet Tahoe Complaints (2024)

61 consumer complaints on file.

#11759981August 27, 2026
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Engine locked up from crankshaft bearing failure, mega fuse blown My wife and I were driving 70mph on a highway when I lost the throttle and other power. I pulled over to the side the best I could but barely over the white line. It was a dangerous situation for us & tow trucks, the engine was locked up & the flat bed truck couldn't tow vehicle. The 2nd truck was a reaper style truck which was dangerous to setup on the side of highway. The dealership diagnosed and replaced engine to their guidelines. I requested the oil cooling lines & housing be replaced as well to avoid metal debris to enter new engine to avoid recurring engine failure. At first both requests were denied, then another dealer represntive said the oil lines would be replaced but the housing would not be. I even offered to pay for that replacement which was denied. I invested a lot into the vehicle, I was assured the original recall and engine oil change would be sufficient. I also purchased to dealer premium care package to really take care of my vehicle investment.Engine failure was around 29,000 miles. The engine failure happened on a Sunday morning, I didn't receive any loaner car or rental car until Thursday affecting my work transportation. Once the dealer rented me a car, I asked if I needed anything to pick up the car, dealer rep said no. Once at rental car place, I needed a credit card and ID, I was charged $250 for the time I had the rental car. The rental car was not close or comparable to my vehicle, which I still had to make payments while it was broken at the dealership. I really worry about my safety, reliability and travel going forward with this vehicle. I also am very concerned about the vehicle losing value due to known issues. There was no warning signs until the failure, I believe the dash message said 'please press start' or 'press start'. Overall this has been a tough and stressful situation with my expensive vehicle investment. Vehicle unavailable- 7/26-8/17
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748409July 6, 2026
ENGINE
While driving, my Chevrolet Tahoe suddenly developed a severe, rhythmic bottom-end engine knock, indicating a catastrophic internal mechanical failure. I immediately took the vehicle to an authorized Chevrolet dealership on May 29, 2026, for emergency diagnosis.The dealership technicians officially diagnosed the issue as a severe lower-end engine failure. They deemed the engine unrepairable and determined that a complete long-block engine replacement is required.As of today, July 6, 2026, the vehicle has been sitting at the dealership for over 5 weeks and has yet to be fixed. The prolonged delay and sudden mechanical failure present a severe safety hazard, leaving me without a vehicle due to known GM manufacturing defects currently under NHTSA investigation. This report is being filed to document the failure of the 6.2L engine lower end, the necessity of a full long-block replacement, and the ongoing repair delay.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740973May 30, 2026
UNKNOWN OR OTHER
Vehicle: 2024 Chevrolet Tahoe RST The backup camera and HD Surround Vision system on my 2024 Chevrolet Tahoe have experienced repeated failures despite multiple repair attempts by an authorized Chevrolet dealership. The failure presents as a black screen displaying a red warning triangle and a crossed-out camera icon when the vehicle is placed in reverse or when camera views are selected. The parking sensors continue to function, but no camera image is available. The vehicle was first repaired in July 2025 (6705 miles) after the dealership diagnosed heat damage to the rear camera coaxial cable located in the liftgate area. The cable was replaced, and the vehicle was returned to service. The camera system failed again the same day. The vehicle was subsequently returned to the dealership, where the liftgate harness was replaced in Aug 2025. Following the repair, the camera system operated normally for a period of time before the same failure condition returned. At approximately 16,500 miles (May 2026), the backup camera and HD Surround Vision system have again become inoperative. This represents at least the third occurrence of the same issue despite prior repairs involving replacement of camera-related wiring components. The loss of the backup camera and surround vision system significantly reduces rearward visibility while backing, parking, and maneuvering the vehicle. Because the condition is intermittent and recurring, the driver cannot reliably depend on the camera system to function when needed. I am submitting this complaint because the issue has recurred multiple times after repair attempts and may indicate a broader defect affecting the vehicle's camera system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739755May 23, 2026
STRUCTURE:BODY
I am reporting a serious safety concern involving a 2024 Chevrolet Tahoe with approximately 23,000 miles.I have a video recording of it . While the vehicle was being driven, water suddenly began actively dripping from the rear cabin light/headliner area into the interior of the vehicle. There were children inside the vehicle at the time, including a child seated directly underneath the area where the water was dripping near the child seat. A significant amount of water is entering the vehicle and continues dripping throughout the interior cabin area. The water appears to be coming from the upper rear cabin/light area and may have entered the electrical system or interior electronic components of the vehicle. I am extremely concerned about potential electrical hazards, safety risks, corrosion, and malfunction of electronic systems caused by water intrusion inside the vehicle. This vehicle has relatively low mileage for its age and has not been modified. The condition appears to involve a possible manufacturing, sealing, or drainage defect. Because children are transported in this vehicle daily, I believe this issue presents a serious potential safety concern and should be formally investigated. [XXX] Phone # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739347May 21, 2026
ENGINE, FUEL/PROPULSION SYSTEM
On Saturday, April 25, 2026, I experienced engine failure on my 2024 Chevrolet Tahoe 6.2L V8. This was a very dangerous situation, and could of been potentially dangerous to others around me on the highway. There was no warning just complete loss of engine propulsion at highway speeds. It was towed to the dealership on this same date. On Monday, April 27, 2026, it was confirmed by the Chevrolet Dealership that this vehicle suffered catastrophic engine failure and that the engine was seized up. Inspection would be available upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739145May 20, 2026
FUEL/PROPULSION SYSTEM, POWER TRAIN
My vehicle started having stuttering/shifting issues back in August 2025, I was advised the vehicle did not need new engine but upgraded oil. I continued to have the issues and have continued to bring back to dealer for constant software updates - cannot duplicate issue meanwhile the stop sale order was issued and I was not advised. The vehicle then experienced very hard jerking- stall- that lead to the dealership putting an AWD IN 2WD calling it a fix! Just got vehicle back again after a complete stall at a stop sign- causing vehicle to roll back and cut back on! Dealer stated the vehicle showed the stall/shutter but could not duplicate on road test. This is a serious safety issue!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727874March 30, 2026
ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM, ENGINE, POWER TRAIN
The contact owns a 2024 Chevrolet Tahoe. The contact stated that while driving approximately 55-60 MPH, the vehicle stalled. No warning lights were illuminated. The vehicle was taken to the local dealer 10 times and the dealer retrieved diagnostic trouble codes for the control module, body control module, rear parking assistance, loss of communication, and transmission solenoid. The vehicle was not repaired. While driving at an undisclosed speed, the vehicle shifted out of the intended gear and shifted into neutral. The vehicle then went into LIMP Mode. The manufacturer was contacted and opened a case. The failure mileage was approximately 30,837.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723305March 10, 2026
ENGINE
The contact owns a 2024 Chevrolet Tahoe. The contact stated that while driving at 76 MPH, the vehicle was driving abnormally rough. The RPM increased, and the message to shut-off engine and restart the vehicle was displayed. The contact stated that the failure occurred while the two minor children and their friends were inside the vehicle. The contact's daughter stated that the vehicle was in neutral after leaving the car wash. In addition, the failure occurred while driving on a busy two-lane highway. The vehicle was almost involved in a crash twice when the engine seized in the middle of the left lane. The contact stated that while attempting to drive the vehicle to the shoulder of the road, the engine seized. The contact stated that while attempting to start the vehicle, the vehicle failed to restart. The local Police assisted with traffic control. The vehicle was towed to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was informed that the Mobile App indicated a transmission and engine failure. The dealer informed the contact that because the engine seized, the engine needed to be replaced. The dealer informed the contact that there was no indication of what caused the engine to seize. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall with a similar description; however, the VIN was not associated with the unknown recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 16,988.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723262March 10, 2026
FUEL/PROPULSION SYSTEM, POWER TRAIN
PICOSCOPE test passed on 2/3/2026 with mileage of 58061 at Everett Chevrolet, Benton, AR. On [XXX], while driving received an error code, no oil pressure and vehicle became disabled in the middle of the road. Tahoe was towed to Teeter Chevrolet in Malvern, AR. We were notified on Friday that the engine was bad and would need to be replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720018February 23, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, STEERING
SUV states brake system failure, tell driver not to drive over 43 miles per hour, attempted to have repairs continue to have repeat service with same issues, notified gm customer service of concerns regarding safety of vehicle with no brakes or steering control however vehicle states owner can drive, this is not safe to general public nor myself and family, gm staff stated could have towed did not seemed concerned for safety of the alert given as there is no current recall on this vin
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719850February 23, 2026
POWER TRAIN
The contact owns a 2024 Chevrolet Tahoe. The contact stated that on four occasions while in reverse (R), the "Service Transmission" message was displayed, and the vehicle failed to reverse. The contact was able to shift into drive(D). The vehicle was taken to a dealer on four separate occasions, where it was diagnosed and determined that the transmission shifter had failed and needed to be replaced. The vehicle was repaired all four times, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was approximately 4,293.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717751February 13, 2026
ENGINE
Dealer checked the 6.2L motor for known defects. It "passed" inspection on 11/20/25 and got the thicker oil (OW-40). The engine lost propulsion ("died") 3 times on a 55mph State Highway on 02/09/26 with my 4 year old in the car with me. It died and came to a complete stop in one lane and would not re-start initially with cars almost rear ending us and needing to aggressively swerve to avoid hitting us. After 4 or 5 attempts it started again (making terrible grinding noises) so I could get it off the road before it died again. It started again to drive home on the back roads approximately 1 mile. Low oil pressure and check engine lights came on. I also received notifications from onstar and from the my Chevy app that there were severe motor or transmission problems. I scanned it with an OBD II Scanner and it has code P00016 (Camshaft Position Correlation - Bank 1 Sensor A). It got towed to the dealer and is now confirmed it is in need of a full motor replacement less than 3 months after they told me the motor passed inspection! This is not acceptable. To be told it's fine and then have it fail with my child in the car is extremely unsafe. Now I'm stuck trying to get a comparable loaner vehicle from the dealer to drive in the snow and mountains with my family safely while they expect to have the vehicle at minimum of 6 weeks. So far they have not found a loaner potentially putting my family in further danger by not having a 4X4 vehicle in a snowy climate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716285February 6, 2026
SERVICE BRAKES, UNKNOWN OR OTHER
I have a 2024 Tahoe that was purchased new from the dealer and has 13,700mi. The first service was completed as required in December with no issues identified. Less than 2 months later the front wheels started making a squeaking sound intermittently when accelerating, coasting or breaking. There were no warning messages. The dealership/mechanic looked over the car & said that the front brakes were measuring 2mm (completely worn out) but no other issues. Before drop off the car computer said above 75% or more for front and rear breaks (green). I have been driving the car in normal condition in southern ca. It seems that the break pads were defective and degraded at an alarming/unsafe rate or that a different component on the car caused them the continuously rub and wear down. The dealership blamed it on owner operation even though they supposedly checked them 2 months before and didn't see abnormal signs of wear. I am very concerned with the QUALITY, RELIABILITY & SAFETY of the front breaking system due to the fact that the breaks wore out so fast. I am worried that the problem has not been properly identified and that that breaks will continue to have this problem if it wasn't caused by faulty pads. I have never had a break wear problem like this before on any of the other 5 new cars that I have owned. This is the first American brand car I have owned and hopefully it's not a sign of things to come.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715534February 4, 2026
ENGINE
Driving on the New jersey Turpike I passed through the ez pass tolls traveling west bound on Bayview Ave bridge, the vehicle shut off without warning. No check engine light or noise, just no propulsion or anything. Dead in the water. Vehicle would not restart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715091February 2, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Vehicle lost all braking capability while in motion. Vehicle rolled to a stop with no brakes with warnings for brake system failure, no front collision active. Upon restarting the vehicle the warnings didnt not go way for 1hr. 2 hours later the warnings cleared from the information system but codes remains. Vehicle was taken to Uptown Chevrolet, Slinger WI and was informed of a bad battery as the "cause" of the issue. A bad battery should not result in the loss of braking capability on any vehicle!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713712January 27, 2026
WHEELS
Front passenger wheel has a fracture. The structural integrity of the wheel is compromised and is causing the tire to leak air, which is dangerous and can cause loss of vehicle control and damage to suspension or brakes. It could also cause dangerous blowouts, which causes a safety concern for me and others on the road if that happens. The problem has been confirmed by the dealership where the vehicle was purchased. Photos were taken and submitted to GM for warranty. The warranty was denied. The vehicle has not been inspected by anyone else other than the dealership where the vehicle was purchased. The only warning lamps were low tire pressure warning. The fracture was found during inspection as to the cause of the low tire pressure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711618January 17, 2026
ENGINE
The vehicle in question had approximately 5000 miles when low oil light came on, it was 2 quarts low. this was after the first oil change at around 3500 miles. I had the dealer do an oil consumption evaluation. They check the oil every 500 miles and confirmed it was using 2 quarts every 2500 miles. They informed me GM says this is normal. I cannot disagree more with that claim. GM knows they have a problem with the 6.2-liter engine. I have researched the issue and found they have a problem with the crankshaft machining and the oil delivery port beveling that delivers lubrication to the connecting rod bearing appears to be too large that causes the motor oil not to consistently keep the bearing lubricated. This causes the engine to be an "oil burner" and premature failure of the bearing. They think putting a heavier viscosity of oil in will delay the inevitable engine failure, which makes me believe they are aware of the faulty manufacturing and want to run from their warranty responsibilities.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700401November 19, 2025
ENGINE AND ENGINE COOLING, EQUIPMENT:ELECTRICAL:INFOTAINMENT, EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
See attached document for complaint. We are writing to express our concerns regarding ongoing and unresolved issues with our 2024 Chevrolet Tahoe High Country Deluxe Package, which we purchased on [XXX] from Titus-Will Chevrolet in Olympia, Washington. Our vehicle was ordered on [XXX] and delivered with 12 miles on the odometer [XXX]. The total purchase price was $97,889.61. This vehicle is equipped with a 6.2-liter Ecotec VB engine and a 10-speed automatic transmission. Since shortly after purchase, we have experienced intermittent audio output problems. With these problems, there is no audio for the radio, phone calls or mapping directions from any of the apps. Incoming phone calls do not connect and outgoing calls cannot be made. Despite multiple service visits-[XXX] as well as documented audio output issues my wife recorded and dated due to the fact that the dealership is 50 miles away: [XXX] We have also driven our vehicle into the Titus Will dealership service department twice when the audio output was not working so the service techs were able to see exactly what was not working-the issues are still unresolved even after updates from the service department and over the air updates that were to "FIX" the issues per GMC/Chevrolet. Our dealership has been unable to identify or correct the defect. Additionally, we received a Safety Recall Notice (N252494000) on May 20, 2025, concerning a potential loss of propulsion in the 6.2-liter engine, which may lead to catastrophic engine failure and increased risk of a crash or harm. We were surprised to learn that this recall was issued on April 24, 2025-prior to our purchase date-yet was not disclosed by the dealer at the time of sale, which also appears to be deceitful on GMC's part. We would not have accepted the vehicle knowing there were catastrophic engine problems as we travel the highways often visiting family in Idaho and Spokane as well as taking care of our elderly parents this last year with their medical care transports. When we contacted Titus-Will Chevr
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698728November 11, 2025
ENGINE
Purchased new vehicle in September 2024, immediately after purchasing the vehicle the engine had a clanking noise. Took the car back to the dealership where they explained the noise was normal. The car continue to make clanking noise, but noise continued to get louder, took the vehicle back to the dealership for first oil change, verify the noise, and discuss safety recall received on the vehicle. Dealer told me the car was ok to drive. In October 2025, the vehicle loss power during acceleration with immediate re-start. After this incident, took the vehicle to another dealer where they inspected the vehicle again. The test failed and the car now needs a new engine. Car has now 10K miles in the odometer and has been sitting in the dealership for 3 weeks now waiting for an engine replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696588October 30, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2024 Chevrolet Tahoe. The contact stated that while driving approximately 35 MPH, there was an abnormal knocking sound coming from the vehicle. The vehicle stalled, and the message to "Press the Start Button” was displayed. The contact was able to restart and drive the vehicle. The contact stated that the following day, while driving and depressing the accelerator pedal, the vehicle hesitated before accelerating, with a rattling and tapping sound coming from the vehicle. The contact continued driving; however, the vehicle stalled with the message to “Press Start Button” displayed. The contact attempted to restart the vehicle however, the check engine warning light illuminated. The vehicle was towed to a dealer, but was not diagnosed. The vehicle was not repaired. The contact stated that prior to the failure the contact experienced failures with the vehicle related to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The contact had taken the vehicle to the same dealer approximately 3 months prior for the recall inspection. The dealer stated that the engine had passed the inspection, and an oil change to a higher viscosity oil was performed. The contact then noticed the abnormal engine ticking sound and became aware that the engine was not responsive while depressing the accelerator pedal following the inspection. Additionally, the engine was idling roughly. The dealer was contacted, but informed the contact that the engine had passed the inspection. The contact stated that the recall had been removed from the VIN and was listed as completed; however, the vehicle experienced engine failure and was currently at the dealer. The manufacturer was informed of the failure. The failure mileage was approximately 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Tahoe