Chevrolet Colorado Complaints

411 consumer complaints on file.

#11707599December 29, 2025
STEERING
Beginning in Nov 2025 my steering wheel occasionally catches, grabs or gets stuck at slow speeds in forward or reverse as I turn the wheel like pulling into a parking space. A loud noise also occurs as I ease the wheel off a little then power through the grab, which then returns to normal steering. I've been able to overpower the grab by powering through it. I brought my truck to an auto repair shop. The tech experienced one episode on a test drive. He could not identify any issues and no warning lights. I contacted General Motors problem resolution team in Detroit. They had me take my truck to a Chevy Dealership which I did. The truck was at the dealership from 7:30 in the morning till almost 4pm. The dealership experienced one episode, thoroughly checked out the truck but could not diagnose a problem. The Chevy dealership did not charge me and did not give me any paperwork, indicating they would be willing to try again if the problem continues/gets worse. Both auto repair shop and Chevy said it was ok, safe to drive. Detroit's team spoke with the Chevy dealership and closed the ticket they had opened for me, telling me I could email the team and open a new ticket if necessary in the future.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707589December 29, 2025
SERVICE BRAKES
The front brake pads are showing extremely uneven ware. Outer brake pad is at 2mm and the inner is at 7mm due to a spring issue on the front caliper. There is also a lip on the left rotor. The tech used 25-NA-365 to help identify the issue. However, my VIN is not covered under this repair. The result is a $500 out of pocket repair for something that should be a mfg defect and not wear and tear. As this was already outlined as an issue with other 2024 Chevy Colorado's I am asking this to be expanded to cover my vehicle as well. The issues was also causing my brake sensors to "detect" new brakes and I had to inform the vehicle that I have not had brake service done to trigger this alert.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706928December 24, 2025
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
ECM Engine Control Module TCM Transmission Range Sensor TCM Transmission Control Module While driving in a 45 MPH speed zone in heavy traffic, the vehicle suddenly lost power and abruptly slowed down causing a number of other vehicles to have to break and swerve . Problem confirmed through ONSTAR Diagnosis As of this date, the GM dealer has not confirmed the problem. No other inspections have been confirmed. there were no warnings prior to the event.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706926December 24, 2025
ELECTRICAL SYSTEM
Starting on [XXX] while driving the truck, the gauge cluster and radio went completely out (black screen) and the five red automatic emergency braking LED's illuminated and stayed on for up to 5 minutes. This happened about 8 times on my commute home. This happed again on [XXX] after the dealership did a software update to resolve the issue. The truck was serviced again on 09/11/2025 and I was told that GM has no software fix for this at this time. On 09/25/2025 again the truck was serviced again to try and fix the issue. This time the radio came on and I could not turn it off or adjust the volume. I went straight to the dealer and showed the issue to the service manager James Mask. The cluster and radio to this day continue to go out (black screen), no speedometer, gauges of any sort for a period of time from 15 seconds to 30 minutes. This leaves me with no way of obeying the speed limit, fuel level, oil or temperature gauges. GM is being blasé about this. They have admitted they know the issue exists but can't or won't offer a fix for the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706413December 21, 2025
UNKNOWN OR OTHER
After the vehicle was parked and powered off for several hours, I started the truck and experienced an extreme and unexpected audio volume spike from the factory BOSE sound system. The startup sound and turn-signal chime played at an excessively loud level, far beyond normal operation. The sound was sudden and intense, causing immediate ear pain, ringing, and a headache. My dog, who was in the vehicle, became visibly distressed and shaken by the noise. This volume spike occurred before any media audio was playing and appears tied to the vehicle's startup and chime audio system, not user-adjustable radio volume. The turn-signal clicking remained extremely loud afterward, indicating the same audio channel was affected. The vehicle has been operating normally prior to this incident and had not been modified in any way. This occurred during normal use of a brand-new vehicle (purchased about a month ago) with no warning lamps/messages/ or other symptoms prior to the incident. The problem has been reproduced and was able to be recorded via phone video during a reproduction attempt to provide to dealer.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11706121December 19, 2025
SERVICE BRAKES, ENGINE
Visibly observed antifreeze / coolant leaking from top radiator hose where it connects to the radiator. Dealer replaced upper radiator o-ring but it's still leaking. At 17000 miles a service brake warning message showed up on information screen. Front brake rotors are warped. Dealer states normal wear on front brakes. Also the dealership stated the front left inner brake pad was down to 2mm of pad left. Wanted over $420 to turn rotors and replace pads. I inquired why the left front pads were worn so much than the right side. They stated this was normal!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705918December 18, 2025
SERVICE BRAKES, ENGINE
In December 2024, at under 50,000 miles, my 2021 Chevrolet Colorado suffered complete brake failure caused by vacuum pump failure. The vacuum pump failure led to irreparable internal engine damage, requiring complete engine replacement under warranty. Sudden, complete brake failure in traffic could have led to a serious accident causing injuries or death to myself and/or others. The component was inspected by the manufacturer and the service advisor at the dealership stated this was "kind of a known issue on Colorados". There were no warning lamps, messages, or symptoms of the problem prior to the failure. This vacuum pump failure is documented in GM Technical Service Bulletin #21-NA-268, which addresses vacuum pump failures on other GM vehicles. The identical failure mode in my 2021 Colorado demonstrates this is a systemic manufacturing defect, not an isolated incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705600December 17, 2025
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
Vehicle: 2023 Chevrolet Colorado Crew Cab 4WD, VIN: [XXX] , mileage: 52,877. Recurrent failure in the cooling system and engine/transmission, affecting safety and use. Check Engine Light comes on and off intermittently, code P30C5 (Coolant Flow Low). The coolant pump was replaced under warranty on March 20, 2025, at Leson Chevrolet (Harvey, LA) with 26,621 miles (attached invoice), but the same issue persists 9 months later with "Engine and Transmission System" alert in myChevrolet app. This is the 5th failed repair for the same defect since purchase (August 2023). Previous repairs include transmission wiring/sensor (January 2024) and Traction Control/ABS (December 2023). The vehicle is unsafe for daily 100-mile commute. Request investigation for potential recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704972December 14, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was driving down a hill and hit my brakes and the pushed back against me and then went right to the floor with minimal braking. I got an error message on my dash that said “brake system failure- do not exceed 62 mph” Luckily it was early in the morning and nobody was in front of me. All of the lights were green and between the engine braking and the little brake power that I had I made it up the hill (about a mile) to the Chevy dealership. I got an error notification the day prior that said there was an electrical error and my check engine light came in. I drove straight to the dealership but they couldn’t do anything since it was 4:30 and later than work hours so they made me an appointment for the next day and let me go. They told me later that day that it was an issue with the master cylinder (which with some research I found that there is an active lawsuit against this issue) I was issued a loaner vehicle with a crack straight across the entire windshield (it was all they had available and I was told it would be “okay” so I’m fine with that)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704801December 12, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, ELECTRICAL SYSTEM
Vehicle: 2023 Chevrolet Colorado Trail Boss Mileage: Approximately 14,000 miles I am submitting this complaint because the ABS braking system on my vehicle activates unexpectedly and causes a temporary loss of braking when driving over uneven pavement. When braking over potholes, bumps, or rough road surfaces at low to moderate speeds, the ABS system engages even though traction is available. When this happens, brake pressure is reduced to the point where the vehicle does not slow as expected. The ABS warning indicator flashes briefly, and there is a noticeable delay before normal braking resumes. This behavior has occurred multiple times in normal driving conditions on city streets, not during panic stops or slippery conditions. The issue feels most pronounced when approaching intersections or slowing in traffic over broken pavement, where consistent braking is critical. The momentary reduction in braking force significantly increases stopping distance and creates a safety concern. The vehicle has low mileage, has not been modified, and is maintained as delivered from the manufacturer. There are no warning lights remaining on after the event, and the issue appears to be related to ABS calibration rather than driver input or road conditions. This does not feel like normal ABS operation and gives the impression that braking is interrupted at the exact moment it is needed. Given the frequency and repeatability of the issue, I believe this represents a potential safety defect that could contribute to a collision, particularly in urban driving environments with uneven road surfaces. I am submitting this complaint to document the issue and to request that the ABS braking behavior on this vehicle be reviewed for safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704741December 12, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The contact owns a 2026 Chevrolet Colorado. The contact stated that while driving 70 MPH with the adaptive cruise control engaged, while the vehicle was approaching another vehicle from the rear, the vehicle failed to automatically slow down. The contact depressed the brake pedal to get the vehicle to slow down as needed. No warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed with a defective module, and that there was no replacement part available to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 2,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704603December 11, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
Forward collision braking activated for no reason and will hard brake. Has done it in the middle of an empty parking lot as well as when driving 65 MPH down the highway, twice. No major injuries happened either time other then sore necks and seatbelt marks. On 2 incidents only the driver was in the vehicle, the other incident consisted of the driver, front seat passenger and 2 children in the back seat. The vehicle has been inspected by dealership. The vehicle now has brake and router problems, which the dealership has said is from hard braking. The vehicle has a bad vibration when applying the brakes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704600December 11, 2025
STRUCTURE:BODY
My 2025 Chevrolet Colorado continues to experience roof denting caused by the vehicle’s structural weakness in the roof panel when exposed to normal car-wash air dryers. This problem began in 2023 with my previous model year Colorado, and it has carried into the 2025 model despite GM having issued an internal service advisory in 2023 describing the need to install additional roof braces to prevent this exact failure. GM acknowledged the issue two years ago but did not incorporate the recommended reinforcement into manufacturing. As a result, even routine exposure to the forced air from automated car-wash dryers causes the roof to bend inward. I have had this inspected multiple times, and the root cause has been consistently identified as inadequate roof support. The problem has not been corrected at the design or production level, and dealerships are not taking further action. The roof denting raises concerns about structural rigidity, potential weakening over time, and whether the roof would perform correctly in rollover or impact scenarios. This is an ongoing defect affecting normal use of the vehicle, with no resolution provided by GM despite documented awareness since 2023.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703437December 6, 2025
ENGINE
The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 20K miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 7-10 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703339December 5, 2025
SERVICE BRAKES
When you have your foot on the break engine running within about 5 mins the breaks release for a second all the light on the dashboard kick on then the breaks feel spongy, you have to then turn the truck off the computer resets check engine light will still remain but the breaks will now be functional again. When taking it to the dealer they stated there was a software recall and they reset the light called it a day.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702710December 3, 2025
VISIBILITY:WINDSHIELD WIPER/WASHER
The contact owns a 2024 Chevrolet Colorado. The contact stated that while attempting to add windshield washer fluid to the windshield washer fluid reservoir. The contact stated that the washer fluid failed to pass through the filler neck and enter the reservoir. The vehicle was taken to the dealer, who informed the contact that the failure was due to a poor design flaw and that there was no repair available currently. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 14,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701525November 25, 2025
ENGINE, SERVICE BRAKES, HYDRAULIC
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at an undisclosed speed, the vehicle shuddered and failed to decelerate as intended while the brake pedal was depressed. An unknown message was displayed. In addition, the contact stated the vehicle failed to respond properly while the accelerator pedal was depressed. Upon inspection, the contact noticed an abnormal engine oil leak. The vehicle was towed to the residence. The vehicle was later towed to a local dealer, where it was diagnosed with an exploded brake booster and metal shavings inside the engine. The vehicle remained at the local dealer unrepaired due to the cost. The local dealer could not guarantee that the repairs would correct the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700245November 19, 2025
EXTERIOR LIGHTING
After completing a right turn with a right turn signal, the vehicle will signal a left turn for 3 blinks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700138November 18, 2025
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, UNKNOWN OR OTHER
While driving my 2024 Chevrolet Colorado, both the infotainment system and the instrument cluster reboot unexpectedly. During these reboots, the speedometer, fuel gauge, and warning lights are unavailable for at least 30 seconds. This has occurred multiple times at highway speeds, creating a serious safety concern because I cannot see my speed or critical vehicle information while the system resets. Restarting the vehicle sometimes restores functionality, but the issue recurs intermittently. I have checked with my dealer, and no permanent fix or recall has been issued by GM at this time. This defect poses a risk to driver and passenger safety and should be investigated promptly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699539November 15, 2025
STEERING
Starting my 2021 Chevy Colorado Zr2 in the morning and noticed the "service power steering, drive with care message. 40,000 miles. No power steering. This would clear after leaving vehicle sit and restarting. After reading many articles and found the recall notice for 2015 colorados. Based off of postings I didn't drive it due to the possibility of losing power steering while on the highway, which had happened to several people after restarting and clearing the error. I think GM never corrected the issue and is present in newer models. I took my vehicle in for the repair of the power steering gear and it was very costly. I feel GM should issue another recall, specifically with the possibility of losing power steering on a crowded highway is a major safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Colorado