Chevrolet Colorado Complaints

411 consumer complaints on file.

#11740930May 29, 2026
STEERING, ELECTRICAL SYSTEM, SERVICE BRAKES
I am reporting a serious safety defect involving my 2021 Chevrolet vehicle. While driving, multiple warnings appeared including “Service Power Steering,” “Steering Assist is Reduced,” “Service ESC,” and “Service Battery Charging System.” The vehicle then lost steering assist, braking performance became unreliable, and it created a serious risk of crash. The vehicle later shut down completely and has remained inoperable. The failure appears electrical and affected multiple critical systems at once, suggesting a cascading system malfunction. Since the incident, the vehicle has not restarted or operated normally. I have replaced the battery, alternator, starter, ignition switch, brake vacuum pump, ECM, spark plugs, fuses, and relays, but the issue persists. The vehicle still shows charging system faults and severe battery drain, indicating an unresolved underlying electrical defect. I have found numerous reports from other 2021 Chevrolet owners describing nearly identical failures, including sudden loss of power steering assist, ESC warnings, charging system failures, battery drain, and complete vehicle shutdowns. This suggests a possible widespread defect affecting this model year. Given the loss of steering assist, braking irregularities, and full vehicle shutdown while driving, I request NHTSA investigate this issue for a potential safety-related defect and determine whether a recall or manufacturer action is necessary.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740775May 29, 2026
VEHICLE SPEED CONTROL
The contact owns a 2026 Chevrolet Colorado. The contact stated that while using the cruise control at 60 MPH, the vehicle began to accelerate. The contact was able to depress the brake pedal to avoid a crash. The cruise control was restarted and set to 50 MPH, and the vehicle accelerated again without warning. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 832.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740714May 28, 2026
LANE DEPARTURE: BLIND SPOT DETECTION
The blind spot indicator on my truck activates randomly without any vehicle present, and I reported this issue immediately after purchasing it. Despite bringing the truck to Boyd Chevrolet in Henderson, NC multiple times, I am repeatedly told they “can’t duplicate the problem” and therefore cannot repair it. Their only explanation has been that “maybe a future software update will fix it.” No components have ever been replaced to rule out a defective part, and I have no indication that Boyd Chevrolet has escalated the issue to Chevrolet, or anyone else, for further guidance. After nearly three years and 30,000 miles, the problem remains completely unaddressed while my warranty is nearing expiration. This is not a minor inconvenience — it is a serious safety hazard. On several occasions, I have begun changing lanes only for the blind spot indicator to suddenly illuminate, causing me to jerk the wheel to avoid a car that isn’t there. The unexpected false alerts create a dangerous overreaction that puts me and others at risk. I want my truck properly diagnosed and repaired, but I have been unable to find a solution through the dealership. I have detailed service records documenting every visit and every time I reported this issue. At this point, I need meaningful action taken to resolve this ongoing safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740148May 26, 2026
ELECTRICAL SYSTEM, SERVICE BRAKES
The contact owns a 2024 Chevrolet Colorado. The contact stated that while driving on several occasions at various speeds, and the brake pedal was depressed the pedal remained floored. The contact stated that the vehicle eventually slowed down on its own and came to a complete stop. The was towed to a dealer where it was diagnosed that the master cylinder needed to be replaced. The vehicle was repaired but the failure reoccurred a little over a month later. The vehicle was towed back to the same dealer where it was diagnosed that the battery was dead and the battery needed to be replaced. The vehicle was repaired but the failure reoccurred approximately 17 days later. The vehicle was taken to the same dealer where it was diagnosed that the drivers door wire harness needed to be replaced due to an electrical issue that killed the battery. The vehicle was repaired but the failure reoccurred approximately four months later. The vehicle was towed to the same dealer where the vehicle has yet to be diagnosed as of yet. The manufacturer notified of the failure. The failure mileage was approximately 8,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739365May 21, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My truck has used automatic emergency braking multiple times while driving at variable speeds with no obstacles or vehicles in front of me causing whiplash and further damage to my neck that has 5 budging discs. Since I’m only allowed to add a specific mileage and speed below, I’ll note here that it’s happened since I purchased the truck with roughly 35000 miles on it to the current mileage of 44000 and between speeds of 30mph-75mph.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11739233May 21, 2026
SERVICE BRAKES
My 2023 Chevy Colorado developed a rear brake squeal when backing up at approximately 20,000 miles. The dealer found nothing wrong at my next appointment. By 30,000 miles, the rear pads and rotors required replacement, at partial cost to me. The new rear brakes are already squealing again after just a few thousand miles. This isn't an isolated issue. A Chevy Colorado forum I follow has documented multiple owners experiencing the same pattern: rear brake squealing beginning around 20,000 miles, followed by premature pad and rotor failure shortly after. Notably, front brake wear is normal across all reported cases, including my own, pointing directly to a rear-specific defect rather than general driving habits or conditions. The rear brakes on the 2023 Chevy Colorado appear to be failing well ahead of any reasonable service interval, and the consistency of this pattern across multiple owners strongly suggests a systemic problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738935May 20, 2026
SERVICE BRAKES, POWER TRAIN
Brake vacuum pump appeared to fail creating brake system malfunction. Appears determined by mechanics to have seized and caused damage to cam shaft. Driver’s safety issue caused when trying to brake vehicle not functioning. Vehicle was towed to mechanic shop. There were no warning signs of impending failure of system. Note that earlier years for this model may have had recalls for safety issue and malfunction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738638May 18, 2026
ENGINE
Engine light came on. Fan ran high. Had it towed to the dealership. Has 39,000 miles on it. Needs a new upper radiator hose due to a defective hose. Apparently, after reading online, GM is aware of this issue. Now we have to pay the diagnostic fee and $850 for a new hose and a flush, as well as the tow bill! Now can’t get the part for a week or 8 days and then have to wait on the repair. This is unsatisfactory that there is a known problem and isn’t covered or hasn’t been a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738351May 16, 2026
UNKNOWN OR OTHER
Check engine light came on and the dealership said it was because the coolant was low due to the radiator hose leaking. I was told by the actual mechanic that they’ve had to do a lot of radiator hoses and that it is a known defect with the Colorados and the traverses but that GM hasn’t done a recall on them yet. That is what brings me here. My truck is only 2 years old and this shouldn’t be happening right now. Thank you for taking the time to review this and I hope GM addresses the matter promptly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737826May 14, 2026
ELECTRICAL SYSTEM
When turning off the ignition, the key will not go all the way "off" and the key will not release. If I turn the ignition back on and drive forward and backwards and SLOWLY put the vehicle into Park, and then attempt to turn off the vehicle, it will occasionally allow it at that point. It appears to be a disconnect of the system recognizing the vehicle is truly in Park and when it isn't and thereby releasing the ignition off function. the engine does shut off but I think it remains in ACC and will not release. Maybe safety switch in the shifter assembly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737678May 13, 2026
ENGINE, UNKNOWN OR OTHER
The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 35k miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 7-10 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736022May 6, 2026
ENGINE, UNKNOWN OR OTHER
Faulty Radiator Inlet Hose, upper radiator hose failure, outlined in PIT6494A. This is the third time that the light on the dashboard has come on for failure, the first time they "Fixed it" the second time they said it was the Battery, it was NOT!! This time they are saying what it really is, The Radiator Hose FAILURE, since the vehicle is only 3 years old but over the 36k mile WARRANTY, they will NOT fix! failure on their part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735626May 4, 2026
ENGINE
Truck has 36,669 miles check engine light came on and was idling loud, after being looked at my a Chevrolet dealership came back a faulty radiator hose, and coolant was leaking. Too new of truck for this kind of problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733820April 26, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The automated emergency breaking system has been triggered unintentionally twice traveling at speeds of 50 miles per hour. There was no vehicle or object that entered our path. We were traveling behind cars at least three car lengths behind that remained at the same speed. Had there been vehicles behind us, we would have been rear ended at high speeds as the truck came to almost a complete stop on its own immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732461April 20, 2026
ELECTRICAL SYSTEM, LANE DEPARTURE: BLIND SPOT DETECTION
Blind spot monitoring system consistently malfunctions, illuminating the driver mirror warning light when no other vehicles are present. It occurs more frequently after dark, which flickers the bright light continuously, or leaves it on constantly, creating a significant distraction and mistrust of the systems reliability. Dealer had no recommendation for fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732446April 20, 2026
SERVICE BRAKES
The vehicle is registered to me; my mother was the driver at the time of the failure. At ~2,963 miles, the truck developed intermittent check engine and ABS warning lights. The dealer pulled DTC C058A (brake system control module) and P25A2. Per GM bulletin PIT6012A, the battery was replaced and a brake plunger motor sensor learn was performed. The same codes returned within weeks. The dealer then diagnosed internal failure of the brake master cylinder and reservoir, documented the vehicle as "unsafe to drive," and replaced both under warranty. The truck sat at the dealer over six weeks due to a nationwide parts backorder. Repairs were completed April 4, 2025. On May 2, 2025, at ~6,500 miles, the driver was traveling downhill on a city street in the rain at roughly 20 mph. The brake pedal suddenly became hard and resistant. Despite full-force pedal pressure, the vehicle could not be stopped. It entered an intersection, struck another vehicle, then struck a tree. Front and side airbags deployed; the vehicle was totaled. The driver sustained a concussion, broken finger, and severe back and knee injuries, was transported by ambulance, and required months of concussion treatment including vestibular therapy. The hard, resistant pedal is consistent with failure of the electronic brake boost assist (eBoost) system, leaving only unassisted hydraulic braking (roughly 4–5x normal pedal force). This matches other owner reports and the class action in Barron et al. v. GM LLC, which cites defective master cylinders with a missing internal cartridge seal on the same platform. The vehicle is no longer available for inspection. The driver was concussed with significant short-term memory loss at the scene; statements in the police report may not reflect the mechanical failure. Full police report available on request (exceeds 10 MB limit).
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11732332April 20, 2026
ENGINE
Coolant leaking from the upper radiator inlet hose connection. The Malfunction Indicator Lamp (MIL) illuminated in the Driver Information Center (DIC).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732223April 19, 2026
ELECTRICAL SYSTEM
The backup camera view does not appear on my dash screen along with all other camera views. There were no warnings or indicators. It was working the last time the vehicle was driven and then failed on the next vehicle start up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732174April 19, 2026
POWER TRAIN
Check engine light with codes p0700 and p2796 has been happening for months with multiple failed repair attempts. Vehicle was returned to me by the dealer supposedly fixed. I drove it 15 minutes to the high school for an art fair my daughter was in. They (my family) rode with me home. Check engine light was on again. On the way home, the transmission was acting strange, not shifting properly. About half way home, it got stuck in a gear at 3500 or so rpms and would not shift. I tried the manual shifter, and it didn’t work. Stuck in gear. Concern was that we were approaching a hill when it did this, and I could not get the vehicle to shift to deliver the appropriate level of power I needed to ascend the hill. It thankfully did eventually shift, but it was scary for a few seconds, especially since I had my wife and all three of my kids in the vehicle. I dropped the vehicle off the next morning. It got stuck in gear at 3500 RPMS again on the way to the dealership. Two dealerships have made multiple failed attempts to fix the transmission issues. Several attempts to contact GM have gone without a response. No one in my family feels safe in the vehicle after what happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731914April 17, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Traveling approximately 45 mph on a main road and brakes automatically engaged causing vehicle to abruptly stop. This due to faulty Automatic Emergency Braking system that has allegedly already been repaired with a software update. My child and I were in the vehicle and had another vehicle been directly behind us or even oncoming we would have likely been involved in a collision. There was no warning that came on other than the red flashing lights and beeping that engaged the same time as the automatic braking. I will likely have to go to seek medical care for soreness in my neck and back from the jarring of my body from the abrupt stop. Waiting to hear if daughter is feeling any pain as well, as mine onset through the day after the incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Colorado