Volvo XC90 Complaints

1,540 consumer complaints on file.

#10538331September 2, 2013
ELECTRICAL SYSTEM, POWER TRAIN
WHILE DRIVING 70 MPH ON I-5 WE HEARD A LOUD THUMP IN THE ENGINE COMPARTMENT AND WE SUDDENLY WENT TO ABOUT 25 MPH ALL OF OUR ELECTRONIC SYSTEMS SHUT DOWN, THERE WAS AN EXTREMELY LOUD GRINDING SOUND FOR APPROX. 2-3 SECONDS. NOW I THINK MY TRANSMISSION IS DAMAGED AND THE ELECTRONICS SYSTEM SHUTS DOWN PRETTY FREQUENTLY. I AM TOTALLY DISAPPOINTED TO READ THAT THIS HAS HAPPENED TO NUMEROUS OTHER FAMILIES. THANK GOD NO ONE HAS DIED FROM THIS.....THIS IS VERY IRRESPONSIBLE AND NEGLIGENT FROM A REPUTABLE AUTO COMPANY. IS IT GOING TO TAKE SOMEONE OR FAMILY TO GET SERIOUSLY INJURED OR DIE BEFORE THEY ACKNOWLEDGE THIS VERY SERIOUS ISSUE. ITS TIME FOR SOMEONE TO BE ACCOUNTABLE FOR THIS. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10538395September 2, 2013
FUEL SYSTEM, GASOLINE
FOR ABOUT 2 MONTHS NOW I HAVE BEEN SMELLING LOUD ODORS OF GAS/FUEL INSIDE THE CAR COMING FROM THE LEFT SIDE OF MY 2004 VOLVO XC90. THE SMELL IS BECOMING UNBEARABLE CAUSING HEADACHES. I HAD MY HUSBAND LOOK UNDER MY CAR TO SEE IF THERE WAS AN OBVIOUS LEAK. HE NOTICED THAT THE SIDE OF THE FUEL TANK WAS WET, HE WIPED THE TANK OFF MAKING IT DRY DROVE THE CAR AROUND A COUPLE BLOCKS PARKED IT & CHECKED UNDER THE CAR AGAIN, THE TANK WAS WET ON THE SIDE OF THE FUEL TANK AGAIN WITH FUEL LEAKING FROM SOMEWHERE. AGAIN NO OBVIOUS SPOT OR LOCATION OF THE LEAK WAS SEEN & ITS NOT A BAD LEAK WHEREAS YOU CAN SEE IT DRIPPING, BUT IT IS LEAKING FROM SOMEWHERE. MY CAR IS ALSO EXPERIENCING A SLOW SLUGGISH START IN MY OPINION DUE TO THE FUEL ISSUE. I'VE DONE SOME RESEARCH & FOUND OUT THIS IS A COMMON PROBLEM WITH CERTAIN VOLVO'S (01-05 S80, 01-04 V70/S60/XC70, 03-05 XC90) WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITION FOR EXAMPLE HOT CLIMATES & TEMPERATURES. WHEN VOLVO VEHICLES ARE EXPOSED TO THESE CONDITIONS IN COMBINATION WITH FUEL QUALITY THERE'S A HIGHER/GREATER CHANCE THAT THE FUEL PUMP CAN DEVELOP/BECOME CRACKED, DAMAGED, OR PINCHED IN THE FUEL PUMP FLANGE OF WHICH CAUSES AN AIR LEAK IN THE FUEL VAPOR SYSTEM. ALSO 2004 XC90 MODELS HAS THE MOST OVERALL COMPLAINTS. I NEED MORE INFO ON HOW & WHERE VOLVO CAN FIX THIS ISSUE BECAUSE AGAIN UPON RESEARCHING THIS VOLVO HAS DONE A MAJOR RECALL FOR A FAULTY FUEL PUMP OF WHICH INCLUDES MY CAR BASED OFF INFO I HAVE FOUND. HOPEFULLY I WILL BE CONTACTED IMMEDIATELY BECAUSE FROM WHAT I UNDERSTAND THIS ISSUE WILL ONLY BECOME WORSE & IN SOME CASES UPON STARTING THE IGNITION CAN STRIKE OR CAUSE A FIRE. THANKS. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10537740August 28, 2013
SEAT BELTS
TL* THE CONTACT OWNS A 2008 VOLVO XC90. THE CONTACT STATED THAT THE DRIVER AND PASSENGER'S SIDE FRONT SEAT BELT BUCKLES WERE DEFECTIVE. THE SEAT BELTS HAD TO BE RELEASED FROM THE BUCKLE WITH ABNORMAL FORCE. THE SEAT BELTS BUCKLES WERE NOT REPLACED. THE FAILURE AND CURRENT MILEAGE WAS 35,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10537349August 26, 2013
ENGINE
I OWN A 2005 V8 XC90. LIKE SO MANY OTHERS I AM A RECENT MEMBER TO THE CB FAILURE CLUB. YEP. IT'S A CLUB. THE COUNTER BALANCE SHAFT FAILURE CLUB. THIS IS A DESIGN DEFECT THAT VOLVO IS AWARE OF AND DOES NOTHING TO REMEDY THE POOR SAPS WHO OWN A 2005 WITH THE FIRST 6883 ENGINES PRODUCED BY YAMAHA FOR VOLVO. AFTER 6883 VOLVO MADE CHANGES TO THE DESIGN OF THE COUNTER BALANCE SHAFT, BY DRILLING A WEEP HOLE TO LET MOISTURE OUT. UNFORTUNATELY, MY ENGINE WAS IN THE 4000S. I LIVE IN SOUTHERN CALIFORNIA. ABOUT THE DRIEST CLIMATE YOU CAN GET, BUT YET RUST HAS DESTROYED MY COUNTER BALANCE AND THUS DESTROYED MY ENGINE WITH ONLY 80000 MILES ON IT.BTW, I HAVE HAD MY ENGINE SERVICED REGULARLY. BUT THE COUNTER BALANCE SHAFT IS SOMETHING THAT CAN NOT BE SERVICED WITHOUT TEARING THE ENGINE APART. IT LIES IN THE VALLEY OF THE V8. IN MY CASE, AND IN ALL THE OTHER CASES I AM READING ABOUT, THE BEARINGS RUSTED AND THE SHAFT RUSTED AND IT TORE APART MY ENGINE BLOCK. HAD I BEEN DRIVING ON A FREEWAY WITH MY CHILDREN AND LOST POWER IT COULD HAVE BEEN FATAL. HOW IS IT THAT THIS DESIGN FLAW WHICH CAUSES CATASTROPHIC ENGINE FAILURE CAN BE ALLOWED NOT TO BE RECALLED? IN FACT, THANKS TO A OVERCHARGED ALTERNATOR, I HAD JUST PUT A NEW $1400 COMPUTER IN THE CAR. YET, THE COMPUTER NEVER READ CHECK ENGINE. WHY? BECAUSE THE COMPUTER IS NOT MONITORING THE LUBRICATION IN A SEALED BEARING. AND IT IS IMPOSSIBLE WITHOUT TEARING THE ENGINE DOWN FOR 10 HOURS (1200.00 IN LABOR) TO GET TO THE COUNTER BALANCE SHAFT TO SEE THE CONDITION OF IT. PLEASE, FOR THE SAKE OF OTHERS WHO MIGHT BE UNFORTUNATE ENOUGH TO DRIVE THIS CAR AND FIND THEMSELVES ON A FREEWAY WHEN THE ENGINE BLOWS DUE TO CHEAP RUSTED BEARINGS -- ISSUE A RECALL!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10536242August 20, 2013
SEAT BELTS
ADVISED BY SERVICE DEPARTMENT THAT SEAT BELTS WERE REPLACED BECAUSE LOCKING MECHANISM TENDED TO HANG-UP. HOWEVER WE DID NOT QUALIFY BECAUSE WE DIDN'T REQUEST REPLACEMENT WITHIN THE WARRANTY PERIOD. VEHICLE HAS REGULARLY BEEN MAINTAINED BY VOLVO DEALER AND THEY WERE IN THE KNOW IF THE BELTS WERE BEING RECALLED. WE WERE NOT TOLD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10535536August 15, 2013
FUEL SYSTEM, GASOLINE
BACK IN SEPTEMBER OF 2012 MY CAR STARTED STALLING OFF AND ON. IT CAN HAPPEN SEVERAL TIMES A DAY OR ONCE A WEEK OR ONCE A MONTH. I HAVE PUT THOUSANDS OF DOLLARS INTO TRYING TO REMEDY THE PROBLEM WITH NO SUCCESS. I FINALLY TOOK MY CAR TO THE VOLVO DEALERSHIP WHERE I PURCHASED MY CAR IN 2003. THEY INFORMED ME THAT THE PROBLEM IS RELATED TO A DEFECTIVE FUEL PUMP THAT VOLVO WAS REQUIRED BY THE NHTSA TO NOTIFY OWNERS OF MY SAME VEHICLE, (AS WELL AS MANY OTHER MODEL VOLVOS), THAT THE WARRANTY WAS EXTENDED TO 10 YEARS/150,000 MILES. I NEVER RECEIVED THAT NOTICE FROM VOLVO. I HAVE HAD THE SAME ADDRESS SINCE I PURCHASED THE CAR SO THERE IS NO EXCUSE WHY I SHOULD NOT HAVE RECEIVED IT. IF I HAD KNOWN THAT THIS PROBLEM EXISTED I WOULD HAVE CONSIDERED HAVING THE FUEL PUMP CHECKED OUT AND SAVED MYSELF THOUSANDS OF DOLLARS. THE STALLING ISSUE HAS BEEN VERY DANGEROUS, AND ALMOST COST ME AND MY FAMILY OUR LIVES. AT TIMES IT HAS STALLED IN THE MIDDLE OF INTERSECTIONS AND I'VE COME CLOSE TO BEING REAR ENDED AND HIT ON THE PASSENGER OR DRIVER SIDE DOOR. MOST RECENTLY IT STALLED AFTER I STOPPED AT A T IN A HWY AND WAS TRYING TO TURN LEFT. IT LEFT ME IN THE MIDDLE OF A TWO LANE HWY, ON A BLIND CURVE, THAT PEOPLE COMING EITHER DIRECTION COULD NOT SEE MY CAR. I COULD HAVE BEEN HIT BY A CAR COMING AT LEAST 55 MPH AND IT COULD HAVE TURNED INTO A VERY NASTY ACCIDENT. ANGELS WHERE WATCHING OVER ME AND MY FAMILY THAT DAY. I HOPE THAT THE NHTSA LOOKS INTO WHY VOLVO DID NOT FOLLOW THROUGH ON THEIR AGREEMENT TO NOTIFY ALL OWNERS OF VEHICLES INVOLVED IN THE EXTENDED WARRANTY. I PURCHASED A VOLVO MAINLY BECAUSE THEY HAVE A REPUTATION OF BEING A SAFE CAR BUT LATELY IT HASN'T BEEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10534670August 10, 2013
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
MY XC90 VOLVO IS VERY DISAPPOINTING THE DASH BOARD ON THE CAR COMPLETELY FAILS NO NOTHING NO GAS, SPEEDOMETER EVERY THINGS GOES OUT. IN THE NIGHT TIME ITS VERY SCARY ITS COMPLETELY DARK I DON'T KNOW HOW FAST I'M GOING HOW MUCH GAS I HAVE ITS SCARY. NOW THE FUEL PUMP IS GONE AND THE NAVIGATION SYSTEM BURNED OUT I CUT THE CAR ON HEARD A POP THEN I SMELLED SOMETHING BURNING THE NAVIGATION SYSTEM HASN'T WORKED SINCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10534206August 8, 2013
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2007 VOLVO XC90. THE CONTACT STATED WHILE DRIVING 45 MPH HE ATTEMPTED TO ACCELERATE; HOWEVER, THE VEHICLE FAILED TO MOVE FORWARD. THE CONTACT HEARD A LOUD BANGING NOISE AND THE VEHICLE BEGAN MOVING FORWARD. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER SEVERAL TIMES OVER THE COURSE OF FIVE YEARS BUT NO CAUSE FOR FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 09/10/13*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10526300July 23, 2013
ELECTRICAL SYSTEM
ENGINE PASSENGER SIDE CAUGHT FIRE IN THE AN ELECTRICAL COMPONENT, FLAMES SHOOTING OUT THE WHEEL WELL. OTHER DRIVERS FLAGGED TO PULL OVER, TURNED OFF IGNITION KEY AND REMOVED TO GET OUT OF VEHICLE. ENGINE WOULD NOT TURN OFF, CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE FOR FEAR OF EXPLOSION. FIRE DEPARTMENT USED AN AX TO STOP THE ENGINE. CAR WAS TOTALED. NO ONE WAS INJURED. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10526190July 22, 2013
ELECTRICAL SYSTEM, ENGINE, AIR BAGS
AT HIGHWAY SPEEDS, THE WINDSHIELD WIPERS RANDOMLY START, FOLLOWED IMMEDIATELY BY A LOUD THUMP SOUND FROM THE ENGINE, ALSO IMMEDIATELY FOLLOWED BY ALL THE ELECTRICAL ITEMS ON THE INSTRUMENT PANEL GOING DARK, ALL GAUGES GO TO ZERO, SPEEDOMETER DOESN'T WORK, RADIO GOES DARK AND STOPS WORKING ALONG, A/C STOPS WORKING, ERROR MESSAGE APPEAR FOR THE ABS AND SRS. THERE IS ALSO AN SLIGHT LOSS OF ENGINE POWER. PROBLEM HAS OCCURRED 4 TIMES OVER THE LAST YEAR. DEALER COULD NOT REPLICATE THE PROBLEM ON THE FIRST VISIT WHICH IS NOT SURPRISING SINCE THE PROBLEM IS COMPLETELY RANDOM. ON A MORE RECENT VISIT DEALER SAYS CAR NEEDS A INSTRUMENT PANEL MODULE REPLACEMENT AT A COST OF $1,500. ACCORDING TO MY ONLINE RESEARCH, THIS COMPLAINT IS BY FAR THE MOST PREVALENT PROBLEM WITH THIS YEAR AND MODEL BY MAYBE A 20 TO 1 MARGIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10522327June 28, 2013
ELECTRICAL SYSTEM, SERVICE BRAKES, ENGINE
WAS DRIVING IN NEIGHBORHOOD AT ABOUT 20 MPH, WHEN RADIO SHUT OFF AND THEN ALL ELECTRICAL SHUT OFF, CAR DID NOT RESPOND TO EITHER GAS OR BRAKES, THEN THERE WAS A THUMP FROM THE FRONT OF THE CAR, WHICH BROUGHT THE DASH LIGHTS BACK ON. I THEN WAS ABLE TO PULL OVER AND TURN OFF CAR. RESTARTED THE CAR AND THERE WERE A SLEW OF ERROR MESSAGES ON THE DASH, INCLUDING A BRAKE WARNING. ATTEMPTED TO CONTINUE TO DRIVE CAR, ISSUE HAPPENED AGAIN AND AGAIN ON MY DRIVE HOME. VERY UNSAFE TO BE DRIVING AND NOT SURE IF YOUR BRAKES OR STEERING ARE GOING TO CUT OUT. DID SOME RESEARCH WHEN I GOT HOME AND REALIZED THIS IS A WELL DOCUMENTED ISSUE WITH THE CEM OF VOLVOS. I HOPE NHTSA IS INVESTIGATING. IF THIS HAPPENS TO SOMEONE DRIVING ON THE HIGHWAY IT COULD BE A VERY SERIOUS SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10521129June 21, 2013
TIRES, TIRES:TREAD/BELT
MICHELIN CROSS TERRAIN WITH < 39K MILES ON 2008 VOLVO XC90 HAD A TREAD SEPARATION AT INTERSTATE HIGHWAY SPEED DURING BUSY DOWNTOWN TRAFFIC NEARLY CREATING AN ACCIDENT FOR ME AND TWO OF MY CHILDREN. VEHICLE DAMAGE CAUSED SOLELY BY THE TIRE FLAILING THE RIGHT REAR OF MY VEHICLE EXCEEDED $3500. TREAD COMPLETELY SEPARATED FROM THE STEEL BELTS AS A CONTINUOUS RING. TREAD LUGS CAN BE PULLED AWAY BY HAND FROM THE LOWER RUBBER THEY APPEAR TO BE BONDED TO AND THIS UNDERNEATH RING OF RUBBER HAD VERY CLEANLY PULLED AWAY FROM THE BELTS. TIRE REMAINED INFLATED. EVIDENCE OF IMPENDING FAILURE WAS NOTED AS I WAS FEELING VIBRATION FROM THE TIRE FOR 30 MINUTES PRIOR TO CATASTROPHIC FAILURE AND HAD EVEN STOPPED TO INSPECT THE WHEEL FOR A PROBABLE CAUSE. PHOTO DOCUMENTATION AVAILABLE. INTERNET SEARCHING IS CLEARLY SHOWING THAT, FOR THIS MODEL TIRE, THIS IS A COMMON OCCURRENCE. DOES ANYBODY REMEMBER THE OVER 250 DEATHS ATTRIBUTED TO THE TREAD SEPARATION OF BRIDGESTONE TIRES ON FORD EXPLORERS? I DO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10519356June 11, 2013
STRUCTURE:BODY
TAILGATE STRUT MOUNTING BOLT BECAME DETACHED FROM CAR BODY AS I OPENED THE TAIL GATE.THE TAILGATE STARTED TO FALL CLOSED BUT I WAS ABLE TO STOP IT BEFORE IT HIT ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10515377June 5, 2013
ENGINE
EVERY TIME I DO NOT TURN MY CAR ON FOR 2 OR MORE CONSECUTIVE DAYS MY CAR BATTERY DIES. THIS HAS HAPPENED TO ME 7 TIMES IN THE COURSE OF MY 2 YEAR LEASE. EACH TIME IT IS TOWED AND SENT TO VOLVO FOR SERVICE THEY REPORT THAT THEY HAVE SOLVED THE PROBLEM. ONE TIME THEY CLAIMED IT WAS MY BLUE TOOTH DRAINING THE BATTERY. THE NEXT TIME IT WAS SIRIUS RADIO DRAINING THE BATTERY. THE LOST GOES ON AND ON. CLEARLY THERE IS A PROBLEM WITH NO SOLUTION AS MY VAR BATTERY DIES EVERY TIME IT IS LEFT UNATTENDED. WITHOUT FAIL! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10514955June 4, 2013
UNKNOWN OR OTHER
JUST PURCHASED THIS CAR AND FOUND THAT THERE WERE RECALLS. I WOULD LIKE TO FIND OUT IF MY CAR HAS HAD THEM FIXED. THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10513661May 27, 2013
POWER TRAIN, ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL (ESC)
AFTER SEVERAL HOURS OF DRIVING IN THE GEORGIA / NORTH CAROLINA MOUNTAINS WITH THE WIFE AND 2 KIDS IN THE BACK, THE AIR-CONDITIONER AND RADIO ON WITH THE 2004 XC90, THE CAR STARTED EXPERIENCING WEIRD BEHAVIOR. SHORTLY AFTER CROSSING THE GEORGIA BORDER INTO THE MOUNTAINS OF NORTH CAROLINA THERE WAS A LOUD NOISE UNDER THE HOOD OF THE CAR AND THE VEHICLE JERKED VIOLENTLY. THE CAR IMMEDIATELY LOST ALL ELECTRICAL POWER (NO DASHBOARD, HAZARD LIGHTS, BLINKERS, WINDOWS AND DOOR LOCKS, SUNROOF, ETC.). THE DRIVE TRAIN ALSO SEEMED STUCK IN A HIGH GEAR AND WOULD NOT DOWNSHIFT WHICH MADE NORMAL DRIVING CLOSE TO IMPOSSIBLE ESPECIALLY ON MOUNTAIN ROADS. ABOUT 15 MINUTES LATER, THE CAR MADE THE VIOLENT NOISE AGAIN UNDER THE HOOD AGAIN AND JERKED VIOLENTLY AGAIN. LUCKILY THERE WAS AN AUTOZONE IMMEDIATELY AFTER THE SECOND INCIDENT AND I HAD THEM READ THE ENGINE CODES WHICH WAS ONLY SHOWING A 'DSTC FAILURE' (DASHBOARD WAS NON-FUNCTIONAL). I DECIDED TO REPLACE THE BATTERY WITH A NEW ONE IN HOPES THAT THE FAILURE WAS BECAUSE OF A WEAK BATTERY TRICKING THE COMPUTER TO GO INTO SURVIVAL MODE. UPON RESTARTING THE CAR, POWER WAS RESTORED TO THE CABIN (AC, RADIO, AND DASH WERE ALL WORKING AGAIN) AND THERE WAS NOW A 'SRS AIRBAG SERVICE URGENT' MESSAGE WHICH I COULDN'T CLEAR FROM THE DASH, NOR COULD THE TOOL FROM AUTOZONE DETECT OR CLEAR VIA THE PLUG TO THE COMPUTER PORT. THERE WERE NO ENGINE CODES IN THE AUTOZONE COMPUTER AFTER THE BATTERY CHANGE BUT WE STILL HAD THE SRS WARNING LIGHT / MESSAGE ON THE DASH. THE NEXT DAY, WE HAD THE SAME ISSUE ABOVE DRIVING HOME FROM OUR DESTINATION. WE WERE HOPING THAT NEW BATTERY WOULD SOLVE THE ISSUE, BUT I NOW BELIEVE IT'S THE CEM. CAR IS GOING TO THE DEALER TOMORROW TO INVESTIGATE SINCE OF COURSE IT HAPPENED ON MEMORIAL DAY WEEKEND AND NOTHING WAS OPEN OTHER THAN SOME STORES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10512858May 20, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 VOLVO XC90.THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 57 MPH, ALL OF THE DASHBOARD WARNING LIGHTS FAILED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CENTRAL CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 106,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10512481May 17, 2013
ELECTRICAL SYSTEM, ENGINE, EXTERIOR LIGHTING
I WAS DRIVING ON THE HIGHWAY AT 60 MILES AN HOUR AND THE CAR COMPLETELY SHUT OFF. NO LIGHTS, NO ENGINE, NO POWER STEERING, NO DASH LIGHTS. THE CAR WENT COMPLETELY DEAD. I PULLED OVER AND LET THE CAR REST AND THEN IT STARTED UP AGAIN. I NOTICED THE SECOND TIME IT HAPPENED WHEN I TOOK MY FOOT OFF THE ACCELERATOR. I TOOK IT TO ARBORMOTION IN ANN ARBOR MI AND THEY TOLD ME A CODE CAME UP AND SOME PART HAD TO BE CLEANED. WHEN I TOOK MY FOOT OFF THE ACCELERATOR THERE WAS NOT ENOUGH AIR GOING THROUGH THE PART TO ALLOW GAS TO FLOW. THEY FIXED THE PART AND A MONTH LATER, THE SAME THING HAPPENED ON THE HIGHWAY ONLY THIS TIME HOWEVER, UNLIKE THE FIRST TIME, JUST THE LIGHTS STAYED ON. I WENT TO THE SAME SHOP AND THEY SAID IT WAS ANOTHER CODE. I COULD HAVE BEEN KILLED ON THE HIGHWAY. THIS SHOULD NOT HAVE HAPPENED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10510657May 5, 2013
ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL (ESC), ENGINE
I WAS DRIVING MY XC90 2004 AND SUDDENLY THE UNIT JUST TURNED OFF COMPLETELY. I HAD TO CONTINUE DRIVING WITH THE VEHICLE WITHOUT ANY KIND OF POWER. I PARKED THE CAR BESIDE THE HIGHWAY AND TRIED TO TURNED ON THE CAR AGAIN, THE CAR STARTED TO FUNCTION NORMALLY. I CHECKED THE POLE OF THE BATTERY BUT THEY WERE OK AND THE BATTERY ITSELF IT'S NEW. THIS IS NOT THE FIRST TIME THAT HAPPENS, IT IS VERY UNPREDICTABLE AND SPORADIC.WHEN I WENT TO THE VOLVO DEALER SOME MONTHS AGO TO FIX A CAMPAIGN THAT HAVE THE XC90, I TOLD THE MECHANICS WHAT HAPPENED AND TOLD THEM TO CHECK THAT ISSUE. THE TOLD ME IT WAS VERY STRANGE AND WHEN THEY FIXED THE CAMPAIGN THEY TOLD ME THEY DIDN'T FOUND ANYTHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509963April 29, 2013
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
2006 VOLVO XC90 T6 AWD APRIL 21, 2013 APPROX 8:30 PM DRIVING AT APPROX 8:30 PM, TRAVELING AT ABOUT 55 MILES PER HOUR, REMOTE 2-LANE HIGHWAY (US191, EASTERN ARIZONA) ON TWISTY MOUNTAINOUS ROAD, SWITCHED FROM HIGH-BEAM TO LOW-BEAMS TO ACCOMMODATE ONCOMING VEHICLE APPROACHING AROUND A BEND. A MOMENT OR TWO AFTER SWITCHING TO LOW BEAMS, THE VOLVO'S HEADLIGHTS LIGHTS FLICKERED AND WENT OUT ALL-TOGETHER. ERROR MESSAGE READING SOMETHING TO THE EFFECT OF "LOW BEAM BULB FAILURE" APPEARED ON MESSAGE SCREEN. HIGH-BEAMS DIDN'T APPEAR TO BE OPERABLE EITHER. I ACTIVATED FOG LAMPS AND PROCEEDED CAUTIOUSLY TO DESTINATION (APPROX 25 MILES AWAY). APPROX 15 MILES FROM THAT POINT, I WAS PULLED OVER BY DPS PATROL ADVISING I HAD NO HEADLIGHTS...AND THAT MY LICENSE PLATE LIGHT WAS ALSO NOT OPERATING. THE NEXT MORNING, INVESTIGATED FURTHER, DISCOVERED THERE WERE NO ISSUES WITH THE HEADLIGHT BULBS (LOW BEAM AND HIGH BEAM) OR WITH LICENSE PLATE BULBS SPECIFICALLY (THEY WERE NOT BURNT OUT), NOR WERE THERE ANY ISSUES WITH ANY BLOWN FUSES RELATED TO THOSE EXTERIOR LIGHTS. I DID DISCOVER THAT THE DRL (DAYTIME RUNNING LIGHTS) WERE STILL OPERATING AS NORMAL (WHICH UTILIZE THE SAME BULB AS THE LOW HEADLIGHTS) CONFIRMING THAT THERE WERE NO ISSUES WITH THOSE BULBS. ALL RESEARCH SINCE THIS EVENT IS POINTING ME TO CONCLUSION THAT THIS MONUMENTALLY UNSAFE CONDITION WAS CAUSED BY A BAD/FAULTY CEM DESIGN BY VOLVO (ONLINE RESEARCH, SPEAKING WITH VOLVO MECHANICS AND REVIEWING SIMILAR NHTSA COMPLAINTS). THERE IS NO PREVENTATIVE MAINTENANCE THAT I COULD HAVE DONE TO PREVENT THIS FROM HAPPENING. THIS IS NOT AN OWNER MAINTENANCE ISSUE, THIS IS A DESIGN OR MATERIALS ISSUE. VOLVO SHOULD BE REQUIRED TO RECALL & REPAIR TO PREVENT THIS SAFETY ISSUE. I REQUEST NHTSA OPEN (RE-OPEN?) INVESTIGATION INTO THIS ISSUE, AS THIS VERY DANGEROUS SAFETY ISSUE THAT NEEDS ADDRESSING BEFORE MUCH WORSE CONSEQUENCES RESULT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90