Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Collision avoidance system has activated nearly causing a collision with an oncoming vehicle three times. On narrow rural roads it is often necessary to steer quickly to the right when an oncoming vehicle approaches out of its lane. The car activates lane-keeping and steers to left toward approaching vehicle. If there is a bush or tall grass near roadway it also suddenly brakes as well as steers into traffic. This action nearly caused a collision today. Sensors are clean, windows clean, and no bright sunlight. All drivers aids are turned off. Each time message "Collision avoidance system activated" appeared on dash. Dealer found no problems x2.
No injuries · No fire · No crash
Vehicle is repeatedly losing functionality of features controlled by what is referred to as the infotainment system, included lane departure warning, sound associated with turn signals, sound associated with GPS, use of hands-free calling system, etc. Upon reset, functionality resumes but the reset takes a few minutes and must be performed again and again as the issue is recurring. The main problem is that you don't know the functionality is temporarily down until something causes you to notice (IE no steering wheel vibration when departing a lane without turn signal, no alerts on backup camera - objects are visible but off-screen objects don't trigger a warning like they typically do, etc) so you don't expect anything to be wrong when it is. I marked that this incident occured today - which it did, coincidentally on the way to a service appointment about this issue specifically, but it has been happening with increasing frequency over the last couple of months.
No injuries · No fire · No crash
Back to my Initial seat belt on the same car. The car went in for service. The seat belt data showed it was fine. Again the belt pulled so aggressively it tore off my insulin pump patch by sliding upward aggressive as possible. After I took the car to Volvo they had some guy from corporate come look at computer data about the vehicle and test drive it and deemed it safe. I get the car back and zero work was done to the seat belt. The seat belt is harder to pull than it was before it went in. Multiple people in the service department agreed it’s much harder to pull. And literally said there’s nothing we can do cause the data did not show a srs notification. It’s my only car, I’m pretty sure the seat belt shot off or partially did and because their computer data says it’s ok they did nothing to actually investigate it. Allowing me their customer to drive around with a broken seat belt. the belt has a permanent, severe mechanical resistance to being pulled out that occurred simultaneously with the unprovoked tightening event. the vehicle manufacturer is refusing to repair a structurally compromised, physically stiffened safety restraint due to a lack of digital software codes. Glitches in software data on cars can easily happen and Volvo is entirely relying on computer data rather then physical investigation. The worst part is that people in service agreed the belt does not pull right but will do zero to look at it.
No injuries · No fire · No crash
I was completely stopped at a left turn. The rear collision sensor went off for no reason. The seat belt locked up so aggressively I could not get a breathe in and it ripped my insulin pump patch right off my stomach. If I was a couple hours away from home my blood sugar would go through the roof and cause ketones which could be fatal. Luckily I was 20 mins away from home. Being a [XXX] since [XXX] I am now [XXX] Volvo told me this is normal safety feature after inspecting the log. I don’t think it’s normal for collision sensors to go off while not moving as well as the seat belt aggressively pulling to the point were I can’t breathe and it rips off a life depending medical device right out of my stomach. If it is normal then they should have a warning for [XXX]. I’m currently trying to get out of the car lease completely as this feature could literally kill me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
After software updates required by recall no XXX rear camera continues to not appear when shifted into reverse The is vin [XXX] vo XC60 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash