Volvo S80 Complaints

954 consumer complaints on file.

#10130593July 29, 2005
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
ELECTRONIC THROTTLE SYSTEM THE PROBLEM IS NOT BEING HANDLED RESPONSIBLY AND THE DEALERS USE INTIMIDATION AND THEN BULLY THEIR CLIENTS INTO PAYING FOR OTHER SERVICES. THEY REFUSE TO ADDRESS THIS LIFE THREATENING ISSUE. THEY ARE WITHHOLDING VALUABLE INFORMATION. I OWN BOTH VOLVO S70 AND S80 AND THEY HAVE SHUT DOWN IN HIGHWAY TRAFFIC. *THIS IS A DIRECT QUOTE I RECEIVED FROM A MASTER VOLVO MECHANIC WHEN I POSTED A QUESTION CONCERNING ELECTRONIC THROTTLE SYSTEM. " YOUR ETS LIGHT IS A LITTLE MORE SEVERE THEN THAT THIS IS A VERY COMMON PROBLEM THE MANUFACTURE KNOWS THIS AND WILL NOT STAND BEHIND PROBLEM . HOWEVER THE PROBLEM IS THE THROTTLE UNIT, IT HAS A MALFUNCTION AND NEEDS TO BE REPLACED THE DEALER WILL PROBABLY TELL YOU IT NEEDS A DOWNLOAD,THAT IS UNFORTUNATELY ONLY GOING TO FIX PROBLEM FOR A SHORT WHILE.". *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130424July 28, 2005
STEERING:LINKAGES
I WAS DRIVING ON A HIGHWAY WITHIN THE DESIGNATED 70 MILE LIMIT WHEN THE STEERING WHEEL BEGAN TO SHAKE AND THE CAR SPUN OUT OF CONTROL. IT SWERVED TO THE RIGHT AND LEFT AND LUCKILY THERE WAS NO TRAFFIC, OR A TRAGIC ACCIDENT COULD HAVE OCCURRED, SINCE MY TWO CHILDREN WERE IN THE CAR. I LANDED IN A DITCH. THE DRIVING CONDITIONS WERE SUNNY AND THE ROAD WAS CLEAR OF DEBRIS. THE DEALERSHIP REPAIRED A LOOSE GRAVE SHIELD, WHICH THEY SAID WAS CAUSED BY SOMETHING HITTING THE CAR, ALTHOUGH THE ROAD WAS CLEAR OF DEBRIS AT THE TIME OF THE ACCIDENT. I TOLD THEM THAT THERE WAS A RECALL ON YOUR SIGHT FOR S80 2004 VOLVOS, BUT THEY SAID MY VIN WASN'T PART OF THAT RECALL. WHILE THEY REPLACED THE GRAVE SHIELD AND COMMENTED THAT NO DAMAGE WAS NOTED THEY SAID THAT SOMETHING HAD "KNOCKED IT LOOSE" AND THAT MAY HAVE CAUSED THE STEERING WHEEL TO SHAKE OUT OF CONTROL. SINCE WHAT HAPPENED WAS RELATED TO THE SHAKY STEERING WHEEL, I AM CONCERNED THAT THE PROBLEM MIGHT REOCCUR AND I AM AFRAID TO DRIVE THIS CAR, EVEN THOUGHT THE VIN IS NOT PART OF THE RECALL. PLEASE ADVISE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130036July 26, 2005
ELECTRICAL SYSTEM
CAR HAS SHUT OFF 6-8 TIMES WHILE DRIVING. THE MAJORITY OF TIMES HAVE BEEN ON THE INTERSTATE IN RUSH HOUR. THE FIRST FEW TIMES THIS HAPPENED THE CAR WOULD "SURGE" AND THE LIGHTS INSIDE WOULD FLICKER BEFORE THE REDUCED PERFORMANCE LIGHT CAME ON AND THE CAR COMPLETELY SHUT DOWN. EACH TIME IT HAS TAKEN LONGER TO GET THE CAR TO START BACK UP. THE CAR WOULD TURN OVER AND THEN IMMEDIATELY CHOKE DOWN. THE LAST INCIDENT HAPPENED WITHOUT WARNING WHILE DRIVING 80 ON THE INTERSTATE AT 5:30PM ON A WEEKDAY. NOW, THE CAR WILL TURN OVER, BUT WILL NOT STAY CRANKED. I HAVE MADE THREE PAYMENTS ON THIS CAR AND HAVE NOT DRIVEN IT FOR TWO MONTHS FOR FEAR THAT I WILL BE KILLED OR STRANDED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10129439July 20, 2005
VEHICLE SPEED CONTROL, POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING
DT: THE VEHICLE IS A 2001 VOLVO S80. THE CONSUMER'S DAUGHTER WAS DRIVING THE VEHICLE IN TRAFFIC WHEN IT STALLED IN THE MIDDLE OF THE FREEWAY. SHE WAS ABLE TO GET THE VEHICLE TO RESTART BUT WHEN SHE PUT THE VEHICLE INTO DRIVE IT WENT BACKWARDS. WHEN THE CONSUMER GOT THERE HE TRIED TO GET IT TO GO FORWARD AND IT WENT BACKWARDS. THEY CALLED FOR A TOW TRUCK TO TAKE IT TO THE DEALER. WHEN THE CONSUMER TOOK IT TO THE DEALER THEY TOLD HIM THAT IT WAS THE THROTTLE BODY- ETM THAT FAILED. THIS WAS BECAUSE THE BANJO FITTING HAD CARBON BUILD UP. THE THROTTLE BODY IS COVERED BY WARRANTY. AND THE CLEANING OF THE BANJO FITTING IS NOT. THE CONSUMER FEELS THAT IT SHOULD BE PART OF THE MANUFACTURES PREVENTIVE MAINTENANCE. WHEN HE CONTACTED THE MANUFACTURE THEY TOLD HIM THAT HE COULD NOT SPEAK TO THE PEOPLE THERE THAT DECIDE WHAT IS COVERED AS NORMAL WEAR AND TEAR. THE VEHICLE HAS NOT BEEN REPAIRED AS OF YET, ALTHOUGH HE DOES INTEND TO HAVE IT REPAIRED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10128845July 15, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION, FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM, EXTERIOR LIGHTING, LATCHES/LOCKS/LINKAGES:DOORS:LATCH, ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN, VISIBILITY:SUN/MOON ROOF ASSEMBLY, EQUIPMENT:MECHANICAL
PURCHASED A VOLVO S80 IN 2001;VEHICLE CURRENTLY HAS 60700 MILES AND 3 AUTOMATIC TRANSMISSIONS & THROTTLE BODY REPLACEMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10128613July 13, 2005
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
DT: CONSUMER STATED HE IS A CERTIFIED MECHANIC AND HAS TWO SEPARATE VEHICLES THAT ARE THE SAME MAKE AND MODEL WITH THE SAME PROBLEM. THE COMBINATION UNIT OF THE FUEL PUMP ASSEMBLY HAS A MASSIVE LEAK. THERE IS A CRACK IN THE FUEL PUMP ASSEMBLY THAT IS CAUSED BY STRESS FROM THE FUEL LINE. WITH ENOUGH PRESSURE OVER TIME IT WILL CAUSE THIS CRACK. THE FUEL PUMP ASSEMBLY WILL HAVE TO BE REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10128615July 13, 2005
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
DT: CONSUMER STATES HE IS A CERTIFIED MECHANIC AND HAS TWO SEPARATE VEHICLES THAT ARE THE SAME MAKE AND MODEL WITH THE SAME PROBLEM. THE COMBINATION UNIT OF THE FUEL PUMP ASSEMBLY HAS A MASSIVE LEAK. THERE IS A CRACK IN THE FUEL PUMP ASSEMBLY THAT IS CAUSED BY THE STRESS FROM THE FUEL LINE. WITH ENOUGH PRESSURE OVER TIME IT WILL CAUSE THIS CRACK. THE FUEL PUMP ASSEMBLY WILL HAVE TO BE REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10128194July 9, 2005
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
I WAS DRIVING MY 2001 VOLVO S80 2.9L AND WAS ABOUT TO MAKE A LEFT TURN AT A FOUR WAY INTERSECTION. WHEN THE TRAFFIC FLOW WAS CLEAR I PRESSED THE ACCELERATOR BUT THE CAR DIED. THANKFULLY, I WAS NOT STRUCK BY THE ONCOMMING VEHICLE. I TOOK THE CAR TO VOLVO OF RICHARDSON IN RICHARDSON TEXAS AND WAS TOLD IT NEEDED A MASS AIR SENSOR AND ELECTRONIC THROTTLE BODY. THE FACTORY WARRANTY WILL NOT COVER THE PART SINCE IT HAS LAPSED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130227July 8, 2005
ELECTRICAL SYSTEM, SUSPENSION, EXTERIOR LIGHTING, STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS, PARKING BRAKE, ENGINE AND ENGINE COOLING:ENGINE
2001 VOLVO S80 SERIES DEVELOPED PROBLEMS WITH THE STEERING AND THE BRAKING SYSTEM.***NO ANSWER REQUIRED***. *MR WHILE EXITING A PARKING LOT, THE VEHICLE CEASED TO OPERATE. THE VEHICLE TOWED AND THE CONSUMER WAS ASSURED THE PROBLEM HAD BEEN RESOLVED, HOWEVER 8 MONTHS LATER THE INCIDENT HAPPENED AGAIN. THE CONSUMER HAD SEVERAL ELECTRICAL REPAIRS DONE ON THE VEHICLE, SUCH AS THE INTERIOR LIGHTS, THE POWER WINDOWS, THE BATTERY WAS DEFECTIVE WHICH HAD TO BE REPLACED TWICE, THE ALARM WOULD GO OFF FOR NO REASON, THE HEAD LIGHT BULBS AND TAIL LIGHT BULBS WERE REPLACED. THE KEY WOULD NOT TURN IN THE IGNITION, THE ENGINE LIGHT ILLUMINATED, THERE WAS A FRONT SUSPENSION NOISE WHEN GOING OVER BUMPS. THERE WAS A POWER STEERING LEAK DUE TO A LOOSE HOSE CLAMP. THE PARKING BRAKE NEEDED TO BE ADJUSTED, IT DID NOT HOLD ON AN INCLINE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121619June 20, 2005
VEHICLE SPEED CONTROL
THE CONSUMER STATED THAT THE VEHICLE STALLED. THERE WAS AN ISSUE WITH SURGING WHEN THE AIR WAS ON. THE ON BOARD COMPUTER DISPLAY SUGGESTED THAT THE PERFORMANCE WAS REDUCED. *JB THE ENGINE FAILURE EXHIBITED AN ENGINE SURGE OR RPM BUMP WHEN AT IDLE. NORMAL IDLE WAY 700 RPM. THE ENGINE WOULD REV UP TO ABOUT 1000 RPM, THEN DROP BACK TO 700 RPM. *SC THE THROTTLE UNIT WAS REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10125816June 10, 2005
VEHICLE SPEED CONTROL
2000 VOLVO S80 SUFFERED FROM A FAULTY THROTTLE CONTROL MODULE. *MR THERE WAS A PENDING LAWSUIT IN CALIFORNIA REGARDING THESE MODULES AND THEIR PREMATURE FAILURE RATES. *SC *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10123904June 2, 2005
FUEL SYSTEM, GASOLINE:DELIVERY, FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM, EQUIPMENT
2000 VOLVO S80 4 DR. ERRATIC IDLING/SURGING WITH ENGINE LIGHT COMING ON.LEADS TO STALLING OUT ON MAJOR HIGHWAYS ON MANY OCCASIONS NARROWLY AVOIDING LIFE THREATENING TRAFFIC ACCIDENTS TRYING TO PULL "DEAD" CAR TO SIDE OF ROAD. BROUGHT CAR TO VOLVO DEALER AND CAR WAS REPAIRED FOR $1332.50. REPAIR INCLUDED REPLACEMENT OF: ELECTRONIC THROTTLE BODY($588.50) WITH SOFTWARE DOWNLOAD($28.00) TO ALLOW ETM TO FUNCTION ALONG WITH GASKET($4.00). REPLACEMENT OF MASS AIR FLOW METER($234.21) TOTAL LABOR/PARTS= $1254.71 + $75.29 TAX + $2.50 ENVIROMENTAL FEE??= $1332.50 I UNFORTUNATELY DO NOT HAVE OLD PART. PLEASE NOTE THAT NOW @ 30,000 MILES AFTER REPLACEMNT ON 12/1/2003 THE ELECTRONIC THROTTLE BODY IS SHOWING THE "SIGNS" OF A NEED FOR REPLACEMENT AGAIN.
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#10122509May 31, 2005
UNKNOWN OR OTHER
CARRIER BIKE RACK AND 2 BIKES FLEW OFF THE ROOF OF A S-80 VOLVO(2003) WHILE DRIVING ON THE FLORIDA TURNPIKE.LUCKILY NO ONE WAS CLOSE BEHIND AND I WAS ABLE TO REMOVE THE WRECKAGE FROM THE HIGHWAY.I COMPLAINED TO VOLVO BUT THEY CLAIMED THAT IT WAS MY FAULT.NOTHING WAS REPLACED.SOMEWHERE IN THE MANUAL IT SAYS TO CHECK THE RACK.THERE IS NO WARNING LABEL ON RACK AND AS IT IS ENCLOSED THERE IS NO EVIDENT WAY TO SECURE.THERE ARE FINGERS IN THE SLOT ON TOP OF THE CAR BUT THE ROOF MATERIL IS SO FLIMSY THAT IT APPEARED TO HAVE ENOUGH GIVE SO THAT THE ROOF RACK COULD DISENGAGE.VOLVOS ATTITUDE ISS THAT THE DRIVER MUST CONSTATANTLY CHECK THE ROOF RACK. IF THIS IS SO THE LEAST THEY COULD DO IS PUT A WARNING LABEL ON SAME.I AM FOTUNATE NO ONE WAS INJURED BUT I THINK THERE IS A SERIOUS PROBLEM.I HAD A VERY LIGHT LOAD BUT I SEE VOLVOS WITH HEAVY BOXES ON THEM AND I SHUDDER TO THINK WHAT MIGHT HAPPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10122130May 25, 2005
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
RE: 2003, VOLVO S80. I HAD JUST PULLED INTO A PARKING SPACE AT MY PRESCHOOL SON'S SCHOOL, I WENT TO SHIFT GEARS AND TAKE MY FOOT OFF THE BRAKE AND MY CAR HAD A SUDDEN ACCELERTATION CAUSING ME TO BE WITHOUT CONTROL OF MY CAR FOR OVER 50 FEET, HITTING A TREE, 3 SHRUBS AND A 3000 LB. ROCK. MY PRESCHOOLER AND I SUSTAINED MINOR INJURIES BUT MY CAR IS TOTALLED. MY CAR IS IN AN AUTO BODY SHOP AWAITING INSURANCE APPROVAL FOR A TOTALLED CAR. MY SON IS TRAUMATIZED AND I WAS SHAKEN UP FOR DAYS. I AM CONCERNED THAT THERE WAS A MACHANICAL FAILURE BUT I HAVE NOT RECEIVED A CALL BACK FROM VOLVO ABOUT AN INVESTIGATION. I WOULD LIKE TO REQUEST A FORMAL INVESTIGATION INTO THIS.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10122028May 24, 2005
ELECTRICAL SYSTEM
ETM PROBLEM WAS DIAGNOSED BY DEALER AFTER SURGING ENGINE AT IDLE AND THEN ENGINE FAILURE. WE PAID $850 TO REPLACE THIS AND NOW 13 MONTHS AND 13000 MILES LATER THE NEW PART HAS ALSO FAILED. THEY WILL NOT COVER THE PART BECAUSE IT HAS BEEN OVER 12 MONTHS SINCE REPAIR. I HAVE NO CONFIDENCE IN SPENDING ANOTHER (NOW $950) FOR ANOTHER ETM THAT IS DESTINED TO FAIL AGAIN RISKING ACCIDENT/DEATH FOR MY FAMILY DEPENDING ON WHEN "IT DECIDES" TO FAIL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121940May 23, 2005
VEHICLE SPEED CONTROL
I OWN A 2000 VOLVO S-80. THE ELECTRONIC THROTTLE MODULE FAILED SUDDENLY RESULTING IN THE INABILITY TO OPERATE THE VEHICLE AT NORMAL SPEED. THIS RESULTED IN IMMEDIATE UNCONTROLLED DECELERATION AND LIMITED VEHICLE CONTROL. THE VEHICLE WAS REPAIRED BY AN AUTHORIZED VOLVO DEALER. VOLVO IS AWARE OF THE PROBLEM WITH THIS PART (REFERENCE THE CENTER FOR AUTO SAFETY, SEE WWW.AUTOSAFETY.ORG/ARTICLE.PHP?SCID=119&DID817) AND IS INVOLVED IN A PENDING LAWSUIT IN CALIFORNIA, IN ADDITION TO STATE AND FEDERAL AGENCIES BEING INVOLVED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121070May 16, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT: THE CONSUMER STATES THAT SHE OWNS A 1999 VOLVO S80. SHE SAYS THAT SHE HAS HAD SEVERAL PROBLEMS WITH THIS VEHICLE. SHE TOOK THE VEHICLE TO HER VOLVO MANUFACTURER. VOLVO SAID THAT BECAUSE SHE BOUGHT IT USED FROM A INDEPENDENT DEALER AND OUT OF WARRANTY THAT THEY ARE NOT RESPONSIBLE FOR THE VEHICLE. SHE SAYS THAT HER ABS BRAKES KEEP FAILING AND NEEDED TO BE REPLACED. SOMETIMES THE BRAKES WORK AND SOMETIMES IT WOULD NOT. SHE ALSO SAID THAT SHE HAD TO REPLACE THE STEERING HOSE BECAUSE THE STEERING WOULD LOCK UP. THE PRIOR OWNER OF THE VEHICLE HAD TOLD THE INDEPENDENT DEALER THAT HE HAD SEVERAL PROBLEMS WITH THE VEHICLE WHILE HE OWNED IT. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121101May 16, 2005
FUEL SYSTEM, GASOLINE
1.MY WIFE HAS A 2001 VOLVO S80 T6. THE CAR JUST DIED ON HER AT 65 MPH ON A MAJOR FREEWAY. SHE WAS LUCKY TO GET IT ON THE SHOULDER AND WAS STRANDED. 2. THE FAILURE AS STATED BY VOLVO IS THE THROTTE MODULE. 3. DOING RESEARCH I HAVE FOUND THAT THIS IS MAJOR FAILURE ON VOLVO AND VOLVO CONTINUES TO DENY THE PROBLEM. THERE IS ALOTT OF SUPPORTING ARTICLES AND SEVERAL CLASS ACTION LAW SUITS IN THE WORKS. THE DEALER STATES IT WILL COST $907.00 TO FIX. STILL NOT FIXED!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10120896May 13, 2005
VEHICLE SPEED CONTROL
CONTINUOUS PROBLEM WITH SURGING ENGINE AT IDLE. WHEN STOPPED AT A TRAFFIC LIGHT OR COASTING TOWARDS ONE, THE ENGINE SURGES UNEVENLY INCEASING THE RISK OF AN ACCIDENT. I BELIEVE THE CAUSE IS A FAULTY ELECTRIC THROTTLE MODULE ETM. DEALER WILL ON;Y REPLACE A MAP SENSOR, BUT PROBLEM CONTINUES TO EXIST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10119530May 3, 2005
AIR BAGS
AIR BAG DEPLOYMENT CAUSED AN ACCIDENT. THERE WAS AN ACCIDENT TWO WEEK PRIOR TO DEPLOYMENT, NO AIR BAG DEPLOYED, AND NO MAJOR DAMAGE OCCURRED. THE FRONT AND DASH AIR BAGS DEPLOYED ON 4/29/05. NO IMPACT AT TIME OF DEPLOYMENT. DRIVER LOST CONTROL AND HIT ANOTHER VEHICLE. AIR BAG LIGHT CAME ON AS DRIVER WAS READING MESSAGE, AND AIR BAG DEPLOYED. SPEED WAS 20 MPH. THERE WILL BE INVOICES, POLICE REPORT.*AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S80