Volvo S80 Complaints

954 consumer complaints on file.

#11758318August 20, 2026
ELECTRICAL SYSTEM
The contact owns a 2008 Volvo S80. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that several unknown warning lights were illuminated. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed with a failed Central Electronic Module (CEM). The contact was informed that the CEM needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711155January 15, 2026
ENGINE
Car would not crank, got fuel system replaced. Week later after being parked, while driving car cut off on highway. Mechanic has vehicle and has determined the issue is Central Electronic Module. Car is 2010 Volvo S80 with active recall but vin number is not apart of recall while experiencing same problem that almost caused a major accident. Vin [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711169January 15, 2026
ELECTRICAL SYSTEM
On [XXX] I was driving from Opelika, AL to Birmingham, AL. About 20 miles from home while driving on [XXX] in the left lane, my car would not accelerate. I pushe9 it down to the floor and there was no gas, so I had to get over to the right lane while rolling to get out of danger of the traffic and large trucks. MY car has been towed three time in about 3 month in 2025. I had it towed from my work parking lot twice because it would not crank. We bought new batteries, changed out the key batteries and this last incident. We had just got the car out of the shop for a fuel pump & fuel pump control module. (see receipt). I learned there was a Safety Recall from the NHTSA. However, when I called only to learn that my car had not been recalled. Therefore, I am quite confused because the safety issue recall no 09V343000 for 2010,S80 appears to be having the same issue. the software within the Central Electronic module (CEM) is not sending the signal to the fuel pump that was just replaced to the electronic module (PEM). The missing signal to the PEM inhibits the start of the fuel pump. This was a very frightening experience having a car stop on the highway while in the fast lane. Now the fear of it happening again is quite frightening, that's why I confused as to the seriousness of this electrical system software issue is not being taken for granted on my vehicle. If it was a problem for some, why would it not be a problem for all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681205August 17, 2025
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
The headlight system malfunctioned. It is available for inspection upon request. The low beam failure error occurred, which led to an inspection of the headlight system. The wiring inside the headlight assembly failed. The insulation on bulb wires is crumbling everywhere and causing short circuits from exposed wire conductors. This causes a safety issue because the bulbs stop functioning, impairing visibility of the car, visibility of the road, and disabling motion intent lights like the turn signals. Bare wires touching can also lead to overheating and fires or failures of the headlight electrical system. Humidity may damage the exposed wires and cause bulb failure or wire overheating. The wiring harnesses may also overheat. The wire insulation problem was confirmed by an independent service center on multiple cars of this model.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671194July 3, 2025
FUEL/PROPULSION SYSTEM, AIR BAGS, SEAT BELTS
I bought this car from elderly people. After I bought it and drove, there's lots of thing not according to safety standard? I asked them (seller) but they don't have any answer, due to their age. So, since last Tuesday, I am driving as it is. Hardly I put 250 miles so far. There's belt sign, Air bag sign, and Low tire air sign. All signs are showing in my dashboard and stays as long as car is on. So, I am scared to death to drive this car, car itself in a mint condition and it's got only 131K miles. Still there's is more life left on this car. I am also senior citizen and retired person. So, I need help to get these fixed asap please.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665865June 9, 2025
STRUCTURE
The contact owns a 2010 Volvo S80. The contact stated that there was condensation inside the vehicle. Additionally, the contact's daughter informed the contact that there was mold on the front passenger's side seat belt. The contact stated that there was mold on the lower seal near the front passenger's side door jam. The vehicle was taken to the dealer, where it was inspected. The dealer informed the contact that the upper part of the windshield was detaching on the passenger's and driver's sides. The contact stated that after the dealer removed the carpet on the passenger's side, the contact noticed water inside the vehicle and the wiring was wet. The dealer determined that the windshield needed to be replaced. The dealer advised the contact to file an insurance claim for the windshield replacement and another claim for the water damages. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 89,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11641253February 7, 2025
UNKNOWN OR OTHER
Driving down [XXX] headed west to Charlottesville and debris flew off of another truck with a trailer attached . Came off the back of their truck and smashed into the top of my car into my sunroof glass. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635682January 13, 2025
FUEL/PROPULSION SYSTEM, SERVICE BRAKES, SUSPENSION
on Tuesday 11/19/2024 i went to my car and saw that a lot of fluid had leaked out of it. i went to start my car and when the car came on the gas tank was empty, but i had just filled the tank up the day before and parked it. on monday the 11/18/2024 i had put gas in the tank. so on tuesday when i had to go to the store i was pretty confused that the tank was low. this same thing had happened one time before but it never occurred that there was any kind of leak. but for an entire tank of gas to spill out is extremely concerning
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631489December 18, 2024
AIR BAGS, VEHICLE SPEED CONTROL, SEATS
See attached document for complaint.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11604071July 23, 2024
ENGINE
I have a 2016Volvo S80. this is my 7th Volvo I have owned. 4 Months ago my car stalled in the middle of ther road. I had no power with the gas petal. Truck behind me trird not to hit me and our sides touched scapping my car and passenger mirrow. The police offier did not charge either of us. I thought I had bad gas?? Took into my mechanic who only works on volvos he di 75,000 service work and changed the oil. I told him about what happened. Two weeks ago My car light came on no oil pressure stop immediately again was like several months ago i had no power with gas petal. I pulled over light went off. My mechanic was closed at that time so I went to Advance Auto. I have no measure stick for oil you have to go through the car system to check oil level. It stated not low however we put in a quart of Synethic oil and I dropped it off at my mechant. He called me the next day. He stated their was no oil in my car at all and their was no leak. Changed oil new filter another $150.00. He did some research on my car. My car is a year included in a class action lawsuit for faulty engine pistons problem. This lawsuit was settled out of court so no one knows for how much. So I am risking my life with a car that will require a new engine appox $8000.00. Volvo has never recalled these cars. I am afraid to drive it now!!!! A 7 time Volvo owner. You see all kinds of stupid recalls but when your engine stops in the middle of the road this is very dangerous. My mechanic states I need to take to a dealership for this problem. Called Volvo Midlothian VA they can not even look at my car till September. I Have called the other dealership in Richmond VA and they are doing some research and get back to me. If you google this their are 100,s of owners having the same problems that my car has and not one recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579271March 25, 2024
STEERING, UNKNOWN OR OTHER
A batch of metal used for the steering wheel trim prematurely wears down at the base of the steering wheel in 2 locations out of sight with normal use and becomes razor sharp. When turning the wheel, the spinning razor edge can cause the driver to lose control due to sudden pain due to slicing into the fingers. The metal slices into the skin drawing blood much like that of a papercut. I have experienced sudden cuts in turning on 2 separate occasions recently having to re-grab the steering wheel due to involuntary pain reflex release to prevent total loss of control and the problem has not been confirmed by the dealer. There is no prior warning when this issue suddenly occurs.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11571533February 12, 2024
LANE DEPARTURE: BLIND SPOT DETECTION, UNKNOWN OR OTHER, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Most concerning: Front driver door latch quit working while driving leaving door to swing open during traffic. This is a known issue that led to recalls of other Volvo models (2011 - 2017), but the S80 was excluded. It was a terrifying ordeal that has now happened twice (during freezing conditions here in Colorado). Less concerning to me but a problem: The blindspot monitoring system malfunctions and keeps on blinking even when there's nothing in the blindspot - which betrays the reason it exists.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570036February 5, 2024
AIR BAGS
See attached document for complaint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565928January 17, 2024
STRUCTURE:BODY
My drivers side door latch will no longer open from the inside or the outside. I have to climb across to the passenger side and go out the opposite door. I am reporting this because this vehicle is part of the volvo "P3" platform which includes the S60, and they had a huge recall to replace all the door latch mechanisms for this exact reason.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11550351October 17, 2023
VISIBILITY, STRUCTURE
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540556August 24, 2023
AIR BAGS, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
The air bag warning randomly popped up on my screen. They will not deploy if I get into a wreck. Non working air bag. I also have issues that come and go with the electrical component. Sometimes my door won't open, sometimes my seats won't move, and my license plate light is out due to something electrical. My gas tank spits gas back at me and makes weird noises sometimes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526567June 12, 2023
WHEELS
I was driving down the road at 60mph, and my car started to wobble a little bit. I pulled over to see if something was obviously wrong and I didn't notice anything. At this point I thought that maybe I needed a new rear shock, but when I got back on the road, the wobble was so bad that I couldn't drive 25mph. I drove about 20mph until I could get to a safe place to pull over which was only about a mile. I took the wheel off and this was the moment that I noticed the tire had swelled up to the point that it wouldn't stand upright. It just fell over. I bought the tire (Riken Raptor) brand new 11 months ago. There is still a lot of tread on the tire. I had the presence of mind to pull over as soon as I noticed something wasn't right. I fear that if I had been on an interstate highway going 70mph, then something really bad may have happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526377June 10, 2023
FUEL/PROPULSION SYSTEM
In Tank Fuel Pump, problem was leaking at top of pump @ the inlet at the outlet & return valve, crack in the plastic mold. Was giving off fumes, totally unhealthy and waitin for someone to light up a cigarette for a total car explosion and death for all occupants. I have replaced the pump myself. Local Dealer wanted 1100 plus to replace out of my budget This in my view it should have been done by recall, local Jim Volvo of Portland, Oregon said no, out of warranty period. I disagree, If unrepaired, I would have been risking me and my family or occupants in the vehicle at the time. There are still many of these cars and other models & years that I found my research on the web that has had this same problem. I have a 1998 Volvo s70 that appears to be developing the same issue. I had come to like my 2003 S80, it will be my last Volvo My cost so far About $150, and 1st pump I installed was defective, had to start over [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524216May 28, 2023
VISIBILITY/WIPER
These generation of Volvo p3 platform cars had a defective windshield seal that was not the best from the factory. Many cars of this generation (S60, S80, XC90, etc) have had the seals break, causing extreme water leakage as mine has had. And the possibility of the windshield falling out. Mine is bad enough that pushing it lightly from the inside to create a significant gap in the window and the frame of the A pillar. There are many forums and reports of this exact problem and Volvo has yet to voluntarily recall these cars. Many people have reported it to many dealers, but all say they cant replace them. This problem definitely puts the driver and other people in the cabin in danger. And no warning lights go off in relation to the problem. I appreciate your consideration.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524244May 28, 2023
VISIBILITY/WIPER
Leaking windshield. Notice Glass loose from top of windshield.Water leaking down into car on passenger and driver side. Floors soak and wet. Unable to drive in rain car smells due to wet floors. This windshield never was changed, it is the original. This is a Safety issue. This should be a recall. Made an appointment with Volvo dealership on 5/22/2023, they confirmed the windshield leak, water coming in from the top of the windshield. Advise to reseal or replace was told glass will continue to come loose if not taken care of. The windshield can cause an injury or accident if it comes a part while I'm driving. Many volvo's owners have this defective windshield. The leak is due to poor sealing during manufacturing of the vehicle's. This issue should be on the recall list and repairs done for free. All owners who had to pay for this repair should be reimbursed.The floor rugs should also be included in the recall, because it can cause health issue like mold, which is unhealthy. Safety for your customers should always come first.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S80