Saturn Ion Complaints

4,344 consumer complaints on file.

#10413561July 19, 2011
STEERING, STEERING:HYDRAULIC POWER ASSIST SYSTEM
2004 SATURN ION WITH 118K MILES. THE POWER STEERING WILL GO OUT AT LEAST A COUPLE OF TIMES A WEEK AT RANDOM TIMES. THIS BEGAN TO OCCUR WHEN THE VEHICLE HAD ABOUT 90K MILES BUT GM REFUSED TO REPAIR. WHEN IT ORIGINALLY HAPPEN IT WOULD OCCUR ABOUT ONCE A MONTH BUT NOW HAS PROGRESSED TO A CONSTANT OCCURRENCE. THE ON BOARD SCREEN NEXT TO GAUGES WILL SHOW "PWR STEER" AND BEEP LOUDLY. THIS MEANS THE POWER STEERING HAS GONE OUT. CAN OCCUR AT ANY SPEED OR ROAD TYPE. CAR WILL BECOME DIFFICULT TO MANEUVER. THE ONLY WAY TO GET THE POWER STEERING BACK IS TO RESTART THE CAR BY TURNING IT OFF AND BACK ON. IT IS UNSAFE TO DRIVE THE VEHICLE WITHOUT THE POWER STEERING. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413641July 19, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE IGNITION SWITCH WOULD NOT COMPLETELY TURN OFF, WHICH PREVENTED HIM FROM REMOVING THE KEY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE IGNITION CYLINDER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 43,000 AND THE CURRENT MILEAGE WAS 56,159.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413639July 19, 2011
STEERING, STEERING:ELECTRIC POWER ASSIST SYSTEM
ALERT SOUNDS ALONG WITH "PWR STR" MESSAGE. POWER STEERING FAILS. THIS OCCURRED DURING BOTH CITY AND INTERSTATE DRIVING. SEEMS MORE FREQUENT IN WARMER WEATHER. POWER STEERING RESETS AND WORKS FINE WHEN CAR IS SWITCHED OFF AND BACK ON AGAIN. MECHANIC CHECKED ON THE ISSUE AND FOUND THE MODULE THAT CONTROLS THE ELECTRIC STEERING SYSTEM TO BE FAULTY, REQUIRING REPLACEMENT OF STEERING COLUMN. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413263July 18, 2011
STEERING
TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE POWER STEERING FAILED. THE VEHICLE WAS SHUT OFF, AND UPON RESTART THE VEHICLE OPERATED AS NORMAL. THE FAILURE RECURRED APPROXIMATELY THREE TIMES ON THE DRIVE HOME. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,349. UPDATED 09/07/2011 *LN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10414293July 18, 2011
FUEL SYSTEM, GASOLINE
NOTICEABLE GAS SMELL AROUND THE AREA OF THE VEHICLE'S GAS TANK WHICH BECAME WORSE WHILE DRIVING. I BROUGHT MY CAR INTO A LOCAL SERVICE STATION TO HAVE IT LOOKED AT. EVENTUALLY, AFTER REMOVING THE FUEL TANK, THEY FOUND THE CAUSE OF THE LEAK TO BE A FAULTY FUEL PUMP MODULE. THIS IS A KNOWN PROBLEM WITH SATURN IONS AND THERE IS A RECALL IN EFFECT (09V419000), BUT IT ONLY APPLIES TO VEHICLES THAT ARE SOLD OR REGISTERED IN CERTAIN STATES. I FEEL LIMITING A RECALL TO A CERTAIN AREA IS WRONG. THIS IS A VERY SERIOUS PROBLEM THAT COULD HAVE RESULTED IN MY VEHICLE CATCHING FIRE. I BELIEVE THAT SATURN (GM) SHOULD TAKE RESPONSIBILITY FOR ANY VEHICLES THAT ARE AT RISK FOR THIS DEFECT AND SHOULD REIMBURSE THE OWNERS FOR ANY RELATED REPAIRS. THIS SHOULD NOT BE LIMITED TO CERTAIN STATES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413239July 17, 2011
ELECTRICAL SYSTEM
I HAVE HAD SAME PROBLEM WITH 2004 SATURN SINCE DAY WHEN I BOUGHT IT. TAKE TO DEALER AND THEY DON'T KNOW WHAT THE PROBLEM IS. BOUGHT NEW BATTERY CAUSE THAT IS WHAT A MECH SAID TO DO NEED LARGER SIZE. LAST MONTH EVERY TIME NEVER FAILED YOU GET IN VEHICLE TURN KEY ON . SOUNDS LIKE IT WANTS TO START, BUT NO YOU HAVE TO WAIT 10 MIN THEN TURN KEY AND IT STARTS. COLD OR WARM WEATHER DIDN'T SEEM TO MATTER. I WAS TOLD MAYBE STARTER! SO I TOOK IT TO A NEW MECHANIC THAT I HAD A DEALING WITH ON ANOTHER ISSUE DIFFERENT VEHICLE. HE DID TESTING AND REPLACED THE PASS LOCK KEY . SOMETHING TO DO WITH THE ALARMING SYSTEM. SO KNOCK ON WOOD.. THIS LAST WEEK STARTS EVERYTIME ITS WORKING. TOTAL COST FOR PART IS 250.00 PLUS YOU NEED TO HAVE NEW KEY MADE AND CODED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412818July 13, 2011
ELECTRONIC STABILITY CONTROL (ESC), UNKNOWN OR OTHER, ELECTRICAL SYSTEM
CONTINUAL COMPUTER/ELECTRICAL PROBLEMS BEGINNING - 1/12/10 + 1/14/10 + 12/29/10 + 6/21/11 + CURRENT PROBLEM 6/25/11 DEALERSHIP CHARGED $120 FOR DIAGNOSIS EACH INCIDENCE SINCE 12/19/10. CURRENT MILEAGE 22,170.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412200July 13, 2011
STEERING
POWER STEERING QUITS WORKING AT RANDOM TIMES, SOMETIMES WHEN MAKING TURNS AND IS DIFFICULT TO CONTROL, PARTICULARLY AT SPEEDS BELOW 30 MPH. I CONTACTED THE GM DEALER THAT REPRESENTS SATURN BUT WAS TOLD SINCE THE CAR HAS 115,014 MILES ON IT THE VEHICLE DID NOT QUALIFY FOR A FREE REPLACEMENT FROM GM. THIS IS A VERY UNSAFE CONDITION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10411984July 12, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE KEY WOULD NOT DISENGAGE FROM THE IGNITION. THE CONTACT HAD TO HAVE THE FUSE IN THE ENGINE DISCONNECTED IN ORDER FOR THE VEHICLE TO SHUT OFF. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10411833July 11, 2011
STEERING
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT POWER STEERING WOULD FAIL SPORADICALLY. THERE WAS AN UNUSUAL CHIME THAT SOUNDED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 78,864.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410886July 7, 2011
VISIBILITY
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THE WINDSHIELD WIPERS FRACTURED WHILE DRIVING 55 MPH IN HEAVY RAIN CONDITIONS. THE DEALER ADVISED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN ANY RELATED RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THAT THERE WAS A FAULTY PLASTIC WINDSHIELD WIPER HINGE. THE WINDSHIELD WIPER MOTOR WERE REPLACED. THE CURRENT MILEAGE WAS 59,000. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. THE VIN WAS UNAVAILABLE. RK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410890July 7, 2011
STEERING
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED WHILE DRIVING 30 MPH THE POWER STEERING LIGHT WOULD FLASH ON THE RADIO AND THE POWER STEERING SYSTEM WOULD ALSO MALFUNCTION. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE ENTIRE POWER STEERING SYSTEM NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE POWER STEERING SYSTEM REPLACED. THE CONTACT STATED WHEN THE POWER STEERING SYSTEM MALFUNCTIONED THE STEERING WHEEL BECAME DIFFICULT TO TURN AND COULD CAUSE A CRASH. THE FAILURE MILEAGE WAS 82,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10411076July 6, 2011
STEERING:HYDRAULIC POWER ASSIST SYSTEM
2006 SATURN ION. CONSUMER STATES POWER STEERING ISSUES *TGW THE CONSUMER STATED THE POWER STEERING LIGHT ILLUMINATED WHILE DRIVING. WHEN THE CONSUMER ATTEMPTED TO GET OFF THE HIGHWAY, SHE HAD A DIFFICULT TIME TURNING THE STEERING WHEEL. THE DEALER REPLACED THE POWER ASSIST STEERING MOTOR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410457July 5, 2011
STEERING
TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH THE VEHICLE SUDDENLY STALLED. SHE NOTICED THAT THE POWER STEERING WARNING ILLUMINATED AFTER THE FAILURE OCCURRED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE IT TO THE DEALER. THE DEALER ADVISED HER THAT THE POWER STEERING ASSIST SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILES WERE APPROXIMATELY 113,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410523July 5, 2011
STEERING
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING 30 MPH, THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED, THEN THE VEHICLE SUDDENLY STALLED. THE DEALER NOR MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410533July 5, 2011
EQUIPMENT, ELECTRICAL SYSTEM
I HAVE A 2004 SATURN ION. I BOUGHT IN THE WINTER OF 2007. IT IMMEDIATELY PRESENTED WITH THE PROBLEM OF NOT STARTING IN REALLY COLD WEATHER. I TOOK IT TO THE DEALERSHIP IT WAS BOUGHT FROM AND THEY TOLD ME THEY COULDN'T FIND A PROBLEM. I HAVE BEEN TOLD BY ANOTHER MECHANIC THAT HE COULDN'T FIND THE PROBLEM EITHER. I SOMETIMES HAVE TO WAIT UP TO 30 MINUTES FOR MY CAR TO START IN FREEZING COLD WEATHER. ABOUT 6 OR 8 MONTHS AGO THE KEY WOULDN'T TURN WHEN IT WAS INSERTED INTO THE IGNITION. I HAVE TO JIGGLE IT BACK AND FORTH, SOMETIMES THE KEY ALMOST COMING OUT TOTALLY BEFORE IT WILL TURN OVER. TODAY IT TOOK 15 MINUTES TO FINALLY GET IT UNLOCKED AND TURNED OVER TO START. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410563July 5, 2011
STEERING, STEERING:ELECTRIC POWER ASSIST SYSTEM
ELECTRONIC ASSIST POWER STEERING FAILS WITHOUT ANY WARNING. STEERING BECOMES VERY DIFFICULT IF NOT IMPOSSIBLE FOR SOME PEOPLE WHICH COULD LEAD TO LOSS OF CONTROL. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10411237July 5, 2011
STEERING
ELECTRIC STEERING WENT OUT IN THE MIDDLE OF A TURN AND I CAME VERY CLOSE TO GOING INTO A VERY STEEP DITCH AS THE STEERING WHEEL WAS SO HARD IN TURNING. THANK GOODNESS I WAS NOT HURT, IF ANYONE LESS STRONG THAN I WAS DRIVING THEY WOULD MOST CERTAINLY BE IN THE 8 FOOT STEEP DITCH...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410618July 5, 2011
STEERING, STEERING:ELECTRIC POWER ASSIST SYSTEM
THE ELECTRONIC POWER STEERING MOTOR INTERMITTENTLY FAILS ON MY 2007 SATURN ION. AFTER DOING MUCH RESEARCH THIS SEEMS TO BE HAPPENING TO QUITE A FEW PEOPLE, AND THERE IS NO RECALL ON IT. AN INCIDENT HAS NOT OCCURRED AT THIS TIME, BUT VERY LIKELY CAN IF MY POWER STEERING GOES WHILE MAKING A TIGHT TURN AT HIGH SPEEDS. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410325July 2, 2011
STEERING
WHILE NEGOTIATING A LEFT TURN THE POWER STEERING WENT OUT ALMOST CAUSING MY WIFE TO HIT THE ONCOMING CAR HEADON. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn Ion