RIVIAN R1S Complaints

160 consumer complaints on file.

#11648019March 13, 2025
EXTERIOR LIGHTING
Hazard light switch stopped functioning one day. It is completely unusable and is a safety issue. Rivian cannot provide an ETA to fix the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647002March 7, 2025
AIR BAGS
Front passenger airbag is inactive for long periods of time while a passenger is seated in the vehicle during operation. This is indicated by the message displaying the airbag as being off. This occurs regularly with an adult seated normally in the seat while traveling at highway speeds, for long periods of time. I reported this to Rivian and they said the car is functioning normally but it does not seem safe that the airbag is turned off with a passenger present in the vehicle during operation. I am listing the latest incident date here but this has been persistent since I purchased the car new in 2023.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646688March 6, 2025
SEATS
In the R1S, there is a crossmember for the 3rd row seating. On low VIN vehicles, there appears to be a trend, including mine personally, that have crossmember bolts that were mis-installed during assembly and have disconnected the threaded inserts from the body and remain unscrewed and loose. This is a primary mounting point used to secure the seating in the vehicle. The service center confirmed that this has occurred and a video was provided to Rivian when requesting repair. (This video is no longer accessible in the app) Rivian's stance is that contrary to online reports of similar issues on low VIN R1S vehicles and mine, this is caused by the end user. Given the number of occurrences, this appears to be a faulty installation issue from unskilled labor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645757March 1, 2025
STEERING
I am experiencing an ongoing and unresolved steering column defect in my 2023 Rivian R1S, which creates a serious safety risk while driving. Issue Details: The steering wheel drops unexpectedly when weight is applied, even lightly. This occurs both while the vehicle is stationary and while driving, including when hitting small bumps in the road. The issue compromises steering stability and could lead to a loss of vehicle control. Repair Attempts & Rivian’s Response: I have taken the vehicle to Rivian Service Centers four times for this issue. Rivian has replaced the steering column three times (May 2024, July 2024, January 2025), but the issue persists. Rivian has now claimed this is a "normal characteristic" of the vehicle, despite previously acknowledging it as a defect and attempting multiple fixes. I requested a written statement regarding their refusal to fix the issue further, but they have not responded. Safety Concern: My father currently drives the vehicle, and I am deeply concerned that the steering column could fail while he is driving, leading to an accident. The steering instability may cause loss of control, particularly at higher speeds or in emergency maneuvers. Rivian’s failure to fix this issue despite multiple repair attempts indicates a potential systemic defect that could affect other Rivian R1S vehicles. Requested Action: I am filing this complaint to document this safety hazard and request that the NHTSA investigate whether this defect affects other Rivian vehicles. Given that Rivian has failed to properly address this issue, I urge the NHTSA to take action to ensure driver safety, including a potential recall if necessary.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644682February 24, 2025
VEHICLE SPEED CONTROL, SUSPENSION, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
I own a R1S and the vehicle is less than 900miles old (21st day of ownership). When driving today on the highway at 75miles - the vehicle suddenly decelerated to 51 miles. I almost got rear ended by a truck and was very difficult to manoeuvre to safe place from the left lane to the right most lane. I parked in a safe spot and saw through several customer Complaint forums that we need to do a hard reset. But the messages were from customers that are 3 years old. I am surprised this still exists as a complaint. I almost died today
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644165February 21, 2025
ELECTRICAL SYSTEM, VISIBILITY/WIPER
Winter weather led to snow buildup on the headlamps which made them useless. Fortunately this was during the day so there was plenty of sunlight. If this was at night, I would not have had any visibility and would have needed to stop every few miles to clean the headlamps. My BMW uses washer fluid to clean my headlamps and the xenon's are hot enough to melt snow. Neither of these are in the Rivian
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642066February 11, 2025
VISIBILITY/WIPER
Backup camera inoperable when putting car into reverse. Requires a system reset. Daily issue. Issue started within one week of ownership. Service replaced ECU. Upon return of vehicle, issue repeated itself. Was told that inoperable backup camera is a convenience feature and not safety critical.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642032February 11, 2025
ENGINE
On November 16, 2024, while trying to use the vehicle's heating system, only cold air would come out of the vents and an error message, “thermal system fault” appeared on the screen. The service center instructed to not drive it and eventually picked it up via tow truck and made repairs. The vehicle was returned and hot air successfully comes out of the vents but it is often accompanied by extremely loud noises (like a jet engine) as well as some pulsating and odd noises. Also, periodically only cold air comes out of all vents (even though the screen shows heat) if the defog is selected with temperature and fan speed regulated. The safety and performance of the battery has been impacted by the faulty thermal management system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638491January 25, 2025
AIR BAGS, SEATS
the sensitivity of the airbag sensor on the passenger seat is not functioning properly in my opinion. there are times when there is a passenger present and seated, the car is showing that the passenger airbag is off. I took the car to Rivian service center. They indicated that they could not replicate the problem and that to make sure the passengers are over 110 lbs. They also noted that with future software update, they may make it better, which indicates to me that they know there is a problem. I know for a fact that my passengers have been over 110 lbs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635709January 13, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
On January 9, I was driving my new 2025 Rivian R1S (approx. 2,400 miles) when it suddenly displayed “Drive stalk not working.” The vehicle jolted, made a loud noise from the front axle, and then fully stopped in the middle of a busy road with the battery still at 55%. Once it stopped, I had no hazard lights or power steering, and the infotainment system locked up. After several attempts to reboot, the screen showed “Critical battery error” before shutting down completely. I was unable to move the vehicle or alert other drivers with flashing lights, creating a major safety hazard. It took about two hours for a tow truck to arrive. ## Component or System Failure: The vehicle’s propulsion system (drive controls) and electrical/hazard light systems appeared to fail simultaneously. The vehicle is currently at a service center for inspection and could be made available if needed. ## Safety Risk: Being stranded in the middle of the road without hazard lights or any way to move the car put myself and other drivers at serious risk. ## Reproduction/Confirmation: It has not been confirmed or reproduced yet by the service center. ## Inspection: The manufacturer’s service center is inspecting the vehicle. No other parties (police or insurance) have inspected it. ## Warning Lamps/Messages: There were no prior warnings. The “Drive stalk not working” error and subsequent “Critical battery error” appeared just moments before the vehicle stopped. I am reporting this because a sudden, total shutdown without hazard lights is a serious safety concern, especially on a busy road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635538January 12, 2025
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, STEERING
Driving my Rivian R1S on a road trip with family from Seattle, WA to Ketchum, ID (about 600miles.) Stopped to recharge outside of Boise, ID for about 20mins. Started driving again and in about 5 minutes the car started warning (visual message and audible alarm). The following events then occurred: -- The warning message stated something along the line of "Pull over immediately the car will shut down imminently." -- I was driving in traffic and was able to make it through an intersection and saw a gas station in the distance. -- The power steering and braking began to go unresponsive and the car began slowing down as I drove through the intersection. I tried to guide the car to the gas station. -- While pulling in to the gas station the car could barely be controlled. Once dropping below 5mph or so it immediately shut itself down. -- The inability to effectively control the vehicle was extremely unsafe. If the intersection I had to pass through had a red light the car would likely have shut itself down and stranded our family at a very busy intersection. -- The car began flashing a ton of different warning messages. "Suspension needs to be serviced", "Front trunk unable to close please service", "Battery system overheating" are a few as an example. -- After calling customer service I reset the vehicle (using prescribed sequence of button pushes.) The car then went dark and nothing worked from there out. -- Called a tow truck and found hotel for family. Rivian was towed to the Boise service center. -- Rivian service center has been unable to diagnose or recreate the issue to date - they have been in possession of the vehicle for 17 days and counting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634764January 8, 2025
SERVICE BRAKES
On our drive back from Yosemite, we began descending from Groveland, CA after leaving the Rivian charging station. Due to heavy rain, the car ahead of me was moving cautiously, limiting my speed to about 20 mph while maintaining a safe distance during the descent to Moccasin, CA. Thanks to the regenerative braking, I didn’t need to apply the brakes, as the car automatically slowed when I wasn’t pressing the throttle. However, my windows started to fog up, so I turned on the defoggers. Shortly after, I noticed the car’s door locks repeatedly unlocking and locking by themselves. As we neared the bottom of the descent, I began to smell something burning from the vents. This prompted me to step on the brake pedal for the first time, but it felt unusually stiff, with little travel. The car didn’t slow down, and the burning smell intensified. I pressed the brake pedal repeatedly, but it felt stuck, and the car did not decelerate. Eventually, I was able to roll to a stop. I pulled over to a side street where the issue persisted. I turned off the defogger and contacted Rivian via SOS. We were able to replicate the brake issue on the side street: as I maneuvered the car, the brake pedal sank on its own when the defogger was on. Once I turned it off, the pedal returned to normal. There were no warning lights or alerts from the car system. When I got out of the car, the burning smell was strong near the front wheels. It was clear that my family’s safety was at risk, including 3 young children. The car was towed to a service center, where it’s being inspected. Rivian hasn’t been able to reproduce the issue yet. I believe the regenerative brakes weren’t working properly, causing the car to rely on the regular brakes for the entire descent. This likely led to brake failure at the bottom, with the burning smell originating from overheated brakes. I also suspect that the overheating caused other electrical issues, which could explain why the door locks kept cycling on and off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632563December 26, 2024
POWER TRAIN
Unable to use the drive stalk to change gears. Reboot fixed it temporarily. Service center ended up replacing the Steering Column Control module.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632562December 26, 2024
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
On the way home from picking up the vehicle, the adaptive cruise control and the late keep assist functionality failed. The service center determined that one of the front radars needed to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632561December 26, 2024
UNKNOWN OR OTHER
When the Pet Comfort is used in sub freezing temperatures, the HVAC system does not respect the set temperature and the vehicle keeps heating the inside nonstop. On this particular incident, the Pet Comfort feature was set to 68º F however, I received an alert that the inside of the cabin was above 75º F.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632559December 26, 2024
UNKNOWN OR OTHER
The heat pump compressor had a loud noise for days, similar to a jet engine. On December 13, 2024, while the vehicle was being driven in freezing temperatures, the heat pump compressor made different noise that sounded that internal pieces were being broken. After that, the dashboard showed the following error "Thermal system fault detected. Service it if the problem persists". After this, there was no heat available for the cabin. Service center replaced the compressor under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630610December 13, 2024
POWER TRAIN
Front wheel hub bolts back out on their own. This is a huge safety problem and needs a public recall. It is a known problem. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628789December 4, 2024
STRUCTURE:BODY, SUSPENSION
Rivian has a 'kneel' option that uses the powered air suspension to lower the vehicle to make entry and exiting the vehicle easier for users. Yes, this can be turned off or on. When on, the function stops if a main door (driver/passenger) is open and left open the car will not continue to kneel for safety purposes. However, it does NOT stop if you are using the rear hatch to access anything. The car continues to kneel. I have hit my head multiple times on the rear hatch because I am behind the vehicle and assume a certain amount of head room and the car is still kneeling and I do not realize it and stand up like I was and hit my head. I have notified Rivian and asked for updates. I consider this a critical issue and has caused minor injury or confusion momentarily. I live on a busy street and the last thing I need is to hit my head and be knocked out. I have not heard anything from Rivian on my request and an update came out to 'fix' items but this was not included. I advised if it was not I would file an official complaint to make them take security and safety issues seriously.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626513November 20, 2024
AIR BAGS
The passenger seat airbag turns off when a passenger is sitting in the seat. I have taken the vehicle to the service center twice for this issue and they insist it is working as intended. This is a major safety issue for myself and children when we are sitting in the passenger seat. Please help in resolving this!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623847November 6, 2024
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
1> What component or system failed or malfunctioned, and is it available for inspection upon request? * The sensors don't detect the object sometimes. There were 2 incidents when the car sensors did not detect the object a> In my office parking lot the rear sensors did not detect the fire hydrant and did not make the beep noise resulting in a collision. b> I was driving in my neighborhood; I was blinded by the sun and couldn't see the road ahead. Again, the sensors did not detect the car in front i ended up in a collision. 2> How was your safety or the safety of others put at risk? * I had a collision with another car parked by the curbside. Luckily no one was in the other car but both cars had severe damages. I had bruises on my left-hand forearm. 3> Has the problem been reproduced or confirmed by a dealer or independent service center? * When the first incident happened, I was not able to provide Rivian accurate date and time of the incident and the gear guard did not record the collision although it was supposed to record. So I went back to my office parking lot and i reproduced the problem 1 time after trying several attempts and shared the video with Rivian. I have had too many email exchanges with Rivian to help address the issue but they did not help. 4> Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? * When i reported the first-time issue first time, Rivian inspected the sensors on May 29th 2024 and they said there was no problem with the sensors. But it failed to detect the car in my street and hence i had this collision. I could not see anything as i got blinded by the Sun in the evening. I have a recording from the car's gear guard. 5>Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? * There were no warnings or messages during the incident. However, When it detects it applies the brake. But not this time.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to RIVIAN R1S