Ram 3500 Complaints

2,367 consumer complaints on file.

#11444052December 16, 2021
SERVICE BRAKES
At 40000 miles my service brake light has come on. This a bad HCU and according to multiple site is on thousands of HD trucks Cost to repair is 1500 fo a safety piece of equipment I ha replace 400 in sensors already and now unless our a Ram dealer you cannot buy he piece to replace
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443762December 14, 2021
ELECTRICAL SYSTEM, ENGINE
The contact owns a 2019 Ram 3500. The contact stated while driving 65 MPH, the check engine warning light illuminated and the started to decelerate. The local dealer was contacted and made aware of the failure. The vehicle was not diagnosed or repaired. The contact took the vehicle to an independent mechanic and was informed that the battery needed to be replaced, the filter needed to be changed weekly, and an unknown sensor needed to be replaced. The vehicle was repaired but continued to experience the failure. The manufacturer had not been informed of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443717December 14, 2021
POWER TRAIN
My vehicle came with 4X4 gear box shift on the floor. I could not get it to move into neutral or 4 low gear. I hardly drove in so it was no big deal so one day I pulled up the boot around the shift and there was a screw blocking the forward movement. It was the same screw that mount the plastic around the shift, after removing it I was able to get all the gears. The danger in that screw could have put me at risk by locking me into a gear and only staying there. The only reason I discovered this was I changed out my vinyl for carpet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11441535November 23, 2021
ELECTRICAL SYSTEM
The 8.4 u Connect Radio is delaminating and randomly calling people and switch to things on the screen randomly it’s a safety issue because it’s a distraction for the driver and could cause other electrical damage I haven’t taken it to a dealer because I already know the answer it’s up to me to replace it until the company takes ownership of there problems
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440397November 14, 2021
FUEL/PROPULSION SYSTEM
As I was preparing to travel for the holidays comíng up, I was traveling to Texas to see family. I was driving around 65 mph when suddenly the truck started jerking and slowing down when the gas pedal would not give it power. The car behind slammed the brakes and in order to avoid hitting me had to went the the side of the highway. Before coming to a complete stop the truck a 2020 ram 3500 shut off and will not come off. The tow truck was able to scan the truck and the codes are for low fuel pressure and fuel pump. This was a very scary situation because I’m with all my family and not only did I put them in danger by this truck failing with out a notice of any kind but also put others like the vehicle behind in danger because the truck failed. I have look up and this seems to be a common issue with all the “new ram trucks” not sure why there is no recall yet. Hoping this gets looked at and something can be done for the safety of others
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11440305November 13, 2021
FUEL/PROPULSION SYSTEM
I was on my way home from the local RAM Dealer last night, where I wanted to sell my truck (after inspecting it, they offered me $82K for it), when, spontaneously, my truck started to smoke from under the hood and literally burst into flames! I had to pull over and jump out to avoid being burned alive! I am so traumatized. I'm attempting to tow what's left of this truck to the dealer this morning. I hope FCA will take responsibility for this!
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11439302November 4, 2021
WHEELS
The contact owns a 2019 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V398000 (Wheels) however, the part to do the recall repair was unavailable. The contact called the local dealer who confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438581October 28, 2021
TIRES, TIRES:TREAD/BELT
Tire is Nexen Roadian AT Pro LT235/80R17 Load Range E. Original Factory installed tires on 2019 Ram 3500 with dual rear wheels. Purchased the truck new in June 2020. All 6 tires on the truck are identical and had approximately 14,000 miles on them when the driver's side front tire failed. The tires were recently rotated approximately 3-4 weeks prior to failure. The tire that failed was previously located on the Passenger Side Front prior to rotation. I began noticing vibration in the steering wheel at speeds approximately 40-45 mph and higher. I monitored this vibration for a few days in various driving conditions in an attempt to diagnose the problem and noticed that the vibration increased with vehicle speed. Soon, the problem became worse and the entire vehicle began vibrating. The last day of the evaluation period I was towing a Tandem Axle 16ft open Car Trailer with an SUV loaded on the trailer at speeds as high as 75 mph on the interstate. The next day I took the truck to the local dealer who informed me that the steel belt had separated on the inside of the tire and would require replacement. After conducting research on tire separation, I discovered the serious safety concern where the tire could have blown out which would have surely caused a serious accident. I also discovered that this separation failure is very common with this same combination of Nexen Tires on Heavy Duty Ram Pickup Trucks. I had the spare tire mounted until an identical replacement tire was delivered to the dealer for install. I paid $282.42 out of pocket for the tire replacement and after arguing with the dealer, they filed a warranty claim with Nexen. Weeks later I was informed that they have offered to reimburse approximately $113, but to date I have not received any funds and I still have 6 Nexen of these Nexen tires on my truck plus the spare.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438429October 27, 2021
FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP:MOUNTING PLATE/FLANGE
The contact owns a 2020 Ram 3500. The contact stated while hauling his fifth-wheel travel trailer driving up a hill the vehicle lost all power. The contact stated he had to maneuver over several lanes of traffic to move off the road safely. The police department was contacted and had the vehicle towed. The tow truck driver had to unhitch the trailer from the contact's vehicle to tow the truck to a dealer. The vehicle was towed to the dealer and diagnosed with a fuel sensor failure. The fuel sensor was replaced. The vehicle failed to start and was diagnosed with a fuel injection pump failure which had imploded sending metal fragments throughout the whole fuel system and into the fuel tank. The entire fuel system including the fuel tank and all fuel parts needed to be replaced. The contact stated that the dealer informed him of a notice that was sent to the dealer by the manufacturer of a fuel pump failure. The contact stated that he researched the failure online and found NHTSA Action Number: PE21021 (Fuel System, Diesel). The manufacturer was made aware of the failure and a case was opened. The failure mileage was 25,700. Replacement parts are same defective CP 4 injector pump that already failed and now metal shavings are contaminating fuel system leading to another implosion and possible accident or death FCA has no fix available making truck unsafe to operate. STELLANTIS, FCA and STAR are well aware of this CP 4 safety issue in 2019 and 2020 trucks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438271October 26, 2021
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, ENGINE
Check engine light has gone on intermittently. Have had it checked with no reason for the code. No sign that it was the engine harness. Contacted dealership and they explained they couldn't look at it for 3 weeks. Brought it to another mechanic and replaced computer. a week later it damaged that computer. I called dealership and they again advised there wad no way to have it towed in for at least 3 weeks. Only 1 diesel mechanic present. Had diagnostics run again and was diagnosed as engine wiring harness. Engine wire harness has damaged 5 computers. While driving vehicle, it suddenly cuts off, with warning lights on, power steering will not work. There is no warning to this happening. It has happened several times on the road, but would restart while still rolling. Now, there are no replacement wiring harness available to purchase. This is only a 2007.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438282October 26, 2021
FUEL/PROPULSION SYSTEM
I was driving my truck towing a fifth wheel trailer weighing over 10,000 pounds on a rural state highway in Missouri with many hills, curves, and little to no shoulders. As I was traveling on a downhill slope at approximately 60mph my engine abruptly died with no warning, causing an immediate loss of power steering, power brakes, and engine brake. I began applying heavy pressure to the brakes slowing the vehicle and began looking for a side road to pull into. I came upon a driveway with an open gate into a field. With much manual force to the steering wheel and brakes I was able to guide the truck and trailer off of the highway into the field to a stop. I was fortunate to not have anyone stopping in front of me as I am certain I would not have been able to avoid a crash with the heavy load and no power. The vehicle was towed to a local Ram dealer and metal shavings were discovered in my fuel system. Repairs were made under warranty and after 6 weeks my truck was returned to me with a new fuel system including a new Cp4 fuel pump that had failed. This happened on 08/28/2020 and the truck had 8900 miles at the time. On 09/15/2021 I discovered metal shavings in my rear fuel filter while doing routine maintenance The truck was running appropriately with no codes or warning lights, it had 72000 miles at the time. I telephoned a local Ram dealer shop and was told it would have to be diagnosed at their shop. Unwilling to take the chance with another Cp4 pump failing I contacted a local diesel shop and was advised to replace the Cp4 with a Cp3 pump. I purchased a new Bosch Cp3 fuel pump specifically modified for replacement of Cp4 pumps in Ram trucks and paid the local shop myself to do the work. I still have my second Cp4 pump in my possession.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438238October 26, 2021
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS, TIRES:TEMPORARY/EMERGENCY SPARE TIRE, TIRES:TREAD/BELT
In August 2021, my truck started pulling to the right and bouncing. I took to dealership where got vehicle. On September 1,2021 they rotated front tires to rear outer spots. The truck stopped pulling but still bounced. A week later went to Dr. appointment and when got back the tire that was on right front and moved to right rear outer spot had a knot in side wall as well as wire sticking out. There was only 17,479 miles on the truck at the time of rotation. I had that tire taken off and spare put on. Truck still bounced like bad tire still on rear of it. Then on October 20,2021 the other tire that was moved from left front to left rear outer tire split in the tread and blowing out. I contacted the dealership about the issues with the tires but they said it's the customer's responsibility to file warranty claims. In trying to find a dealer of Nexem tires, which I've not been able to in this area, I found a lot of complaints on these tires. Now it's going to cost me almost 2000.00 dollars to replace all 7 tires.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438095October 25, 2021
TIRES:TREAD/BELT
The contact owns a 2018 Ram 3500 equipped with Nexen Tires, Tire Line: Roadian HTX, Tire Size: LT235/80/R17, DOT Number: 8EX6. The contact stated while driving 50 MPH, the contact noticed the vehicle was bouncing while driving. The contact was able to continue driving to work. After exiting the vehicle, the contact inspected the vehicle and noticed that a bubble had started to form on the front driver’s side tire. Additionally, the contact became aware of tread separation on the tire. The contact took the vehicle to a local dealer who inspected the vehicle and offered to replace the tires with new tires. The contact declined and informed the dealer that he would seek assistance from the tire manufacturer. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 27,362.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438121October 25, 2021
FUEL/PROPULSION SYSTEM
Fuel pump failed at 103,000 miles while driving down the highway. Truck started acting funny slight loss of power. Pulled over to the side of the highway and turned truck off. Went to restart and it wouldn't restart. Had to sit on the side of the highway 43 with no amenities within 50 miles waiting for help. Unable to get a towing company directly 911 was called and CHP had to arrange a tow truck for more than 100 miles from destination. Truck was taken to mechanic that confirmed fuel pump failure that in turn took out the entirety of the fuel system. Has been at the mechanics since June 24th waiting on parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11438155October 25, 2021
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Truck was with high pressure pump issues, spent $2600 in rental truck, $400 i. Towing truck and about one month with no truck, Chrysler still doesn't want to pay me back, this is my second truck with same issue, previous truck was a 2019 3500 ram having the same problem when truck was with only 4,000 miles on it. Now they repaired my truck but now i feel like my truck lose already torque, is using more diesel and more DEF.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437974October 24, 2021
TIRES, TIRES:TREAD/BELT, TIRES:SIDEWALL
NEXEN LT235/80R17 2019 Dodge Ram 3500 Dually We have read many horror stories about these stock tires from RAM. The RAM dually and other sites are full of photos and stories of the tires failing. These truck are used for towing large RV and other trailers so the risk due to failing tires is huge. We had hoped to get a few miles out of them before replacing them for peace of mind. Didn't happen though we had the front and inside dual on the passenger side fail at 14,866 miles. The front began to wobble and shake the front end of the truck. I noticed it on 10/12/2021 and on the 13th the truck was shaking so badly I drove the 15 or so miles to Discount tire at 30mph. Discount tire inspected the tire and immediately noticed the tire belts were separating and the tire was about to blow apart. They then found the inside passenger side dual was separating as well. We pulled and replaced all 6 tires. No way we could trust our safety to the RAM stock NEXEN tires. Please look into this further. The number of reports does not reflect the numbers of failures on the road. Many of the truck buyers just immediately replace the NEXEN tires on delivery of their RAM trucks! $200 for a new front end alignment and $1,600 for tires on a new truck but we are safe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437993October 24, 2021
FUEL/PROPULSION SYSTEM, POWER TRAIN, ENGINE
Truck lost throttle response at about 50mph. Coasted to a stop on the side of the road and as soon as it stopped the truck shut down and wouldn’t restart. Check engine light came on and warning message read something along the lines of “exhaust system service required see dealer” After researching these symptoms and warning message, I believe this to be a fuel pump failure. I was able to safely get my truck off the road, but I can easily see how this could be a safety concern depending on traffic. Truck will go to the dealership tomorrow.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437862October 23, 2021
ELECTRICAL SYSTEM
The uconnect 8.4 navigation screen is delaminating. This could become a safety issue if the screen continues to melt and drip glue on the traction control, trailer brake control, parking sensors, as well as can be distracting to the driver if the screen changes on its own. It can also cause the rear view camera to turn on and cause a motion picture to be displaying while the vehicle is in constant motion. The screen has been inspected by a third party and is in need of replacement which costs over $1000. The cause is a faulty part that is not made properly and causes it to prematurely separate from the lcd screen.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437744October 22, 2021
ENGINE
Complete engine stall while driving at highway speeds while towing a trailer. I was able to get to the shoulder before losing all forward momentum. There were no errors or warnings before stall. Truck would not crank after stopping and was towed to the dealership. Dealership blamed the issue on an aftermarket fuel tank, but repaired fuel pump under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437781October 22, 2021
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Ram 3500. The contact stated while driving approximately 40 MPH, the vehicle lost motive power. The contact stated that the check engine and service exhaust system warning lights were illuminated. The vehicle was towed to a local dealer and was diagnosed with needing the entire fuel system replaced. The manufacturer was not informed of the failure. The failure mileage was 35,582.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500