Ram 3500 Complaints

2,367 consumer complaints on file.

#10850658March 20, 2016
UNKNOWN OR OTHER
THE VEHICLE HAS A DRIVER INFORMATION DISPLAY (DID). THERE IS A 7 PIN CONNECTOR FOR A 5TH WHEEL TRAILER. WHILE UNDER TOW, AND USING THE BRAKES IN THE TOW VEHICLE, THE DID RANDOMLY DISPLAYS "CHECK TRAILER BRAKES/TRAILER BRAKES DISCONNECTED" THEN AT SOME POINT IN TIME LATER (SECONDS OR MINUTES) THE MESSAGE DISAPPEARS AND THE TRAILER BRAKES RETURN TO A FUNCTIONING CONDITION. RAM AND RV TRAILER TECHNICIANS HAVE TRIED TO TROUBLESHOOT THE PROBLEM UNSUCCESSFULLY. THE RAM DEALERSHIP SAID THEY RETRIEVED AN ERROR CODE AND REPLACED THE BRAKE MODULE. THE PROBLEM STILL PERSISTS. HAVE YOU RECEIVED ANY OTHER SIMILAR REPORTS?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10850553March 19, 2016
STEERING
R46 FRONT SUSPENSION TRACK BAR FRAME THAT WAS IMPROPERLY WELDED DURING THE MANUFACTURING PROCESS - WE ARE BEING TOLD BY THE DEALERSHIPS THAT NO PARTS ARE AVAILABLE TO FIX THIS AT THIS TIME. THE ISSUE WITH THIS IS THAT WE PULL A LARGE HORSE TRAILER WITH THIS TRUCK AND ARE PUTTING OUR LIVES AND THE LIVES OF OUR HORSES IN JEOPARDY EVERY DAY WE DRIVE THIS TRUCK. WE DID NOT SPEND $70,000 ON THIS VEHICLE TO HAVE IT BE A DEATH TRAP WHILE WE WAIT ON PARTS. WE HAD A 2008 THAT THE TIE ROD BROKE JUST AS I PULLED INTO THE PARKING LOT AT WORK. I WAS TOLD I WAS LUCKY THAT I WASN'T SERIOUS INJURED OR KILLED COMING DOWN THE HIGHWAY. WE WERE TOLD AT THE TIME THERE WAS NO RECALL, GUESS WHAT, THE NEXT WEEK THE RECALL CAME OUT. SO HERE WE ARE IN THE SAME ISSUE AGAIN, DIFFERENT PART, WITH NO HELP COMING FROM THE DEALERSHIPS, MOPAR ETC.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10850125March 16, 2016
SERVICE BRAKES, ELECTRICAL SYSTEM
THE FACTORY INTEGRATED TRAILER BRAKE MODULE (ITBM) ON MY 2014 RAM 3500 MEGACAB 4X4 CUMMINS DIESEL TRUCK DOES NOT SUPPLY PROPER VOLTAGE TO ACTIVATE THE ELECTRIC BRAKES ON A TOWED TRAILER. THE VOLTAGE SUPPLIED TO THE TRAILER BRAKES IS 7 VOLTS DC WITH THE GAIN SET AT MAX, CHECKED BY A TRAILER DEALER THAT DOES PA STATE INSPECTIONS, WHERE A TRAILER REQUIRES OVER 10 VOLTS DC TO PROPERLY ACTIVATE THE BRAKING SYSTEM ON THE TRAILER BEING TOWED TO SAFELY AID IN STOPPING BOTH THE TRAILER AND TOW VEHICLE. I RECENTLY HAD A NOTICE APPEAR IN THE ELECTRONIC DASH (EVIC) THAT THERE WAS A TRAILER BRAKE PROBLEM AND A NOTIFICATION THAT THE TRAILER WAS NOT CONNECTED WHEN IT WAS STILL CONNECTED TO THE TRUCK. THIS PROMPTED THE FIRST VISIT TO THE DEALER WHERE I WAS TOLD THERE WAS A PROBLEM WITH THE TRAILER. I HAVE HAD MY TRUCK TO THE DEALER TWO TIMES FOR THIS PROBLEM AND THE SECOND TIME THEY CHECKED THE VOLTAGE OF ANOTHER TRUCK THAT WAS 7 VOLTS DC AND SAID IT WAS OK. I HAVE A 35 FOOT 5TH WHEEL RV TRAILER AND A 18FT FLAT TRAILER THAT DO NOT BRAKE PROPERLY WHEN ATTACHED TO THIS TRUCK. THE 18 FT TRAILER BRAKES WORK PROPERLY WHEN ATTACHED TO A DIFFERENT TRUCK. I HAVE BEEN RESEARCHING THIS PROBLEM ON THE INTERNET AND HAVE FOUND THAT ON MANY OF THE FORUMS DEALING WITH CUMMINS DIESEL AND RAM TRUCKS THAT THIS PROBLEM IS WIDE SPREAD OVER MANY MODEL YEARS. ON THE DODGE RAM FORUM (WWW.RAMFORUM.COM - SEARCH BRAKE CONTROLLER) AN AUTOMOTIVE ENGINEER EVEN DOCUMENTED THE LACK OF OUTPUT OF HIS 2015 RAM 3500 TRUCK. AT 100% INPUT THERE WAS ONLY 66% OUTPUT TO THE TRAILER BRAKING SYSTEM. I HAVE HAD 6 SAFETY RECALLS FOR THIS TRUCK SO FAR. THIS PROBLEM MAY NOT RECEIVE AS MUCH ATTENTION AS OTHER PROBLEMS DUE TO THE FACT THAT THERE IS A MUCH SMALLER NUMBER OF VEHICLES USED FOR TOWING. PLEASE DO NOT WAIT UNTIL SOMEONE IS KILLED BEFORE INVESTIGATING THIS PROBLEM. THANK YOU FOR REVIEWING MY SUBMISSION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10846443March 14, 2016
AIR BAGS, SEAT BELTS, STEERING
TL* THE CONTACT OWNS A 2014 DODGE RAM 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V460000 (AIR BAGS, SEAT BELTS), 15V459000 (AIR BAGS) AND 15V541000 (STEERING) HOWEVER, THE DEALER INFORMED THAT THE RECALL REMEDY HAD ALREADY BEEN PERFORMED ON THE VEHICLE. THE CONTACT STATED THE VEHICLE WAS NOT TAKEN TO THE DEALER PREVIOUSLY TO BE SERVICED UNDER ANY RECALLS. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10845959March 10, 2016
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2014 RAM 3500. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STOPPED AT A STOP LIGHT OR A STOP SIGN, THE INSIDE OF THE VEHICLE WAS FILLED WITH FUEL FUMES. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10845567March 8, 2016
TIRES:SIDEWALL
TL* THE CONTACT OWNS A 2016 RAM 3500 EQUIPPED WITH NEXEN TIRES, SIZE: LT23580R17E (NA) THE CONTACT STATED THAT THE OUTSIDE EDGE OF THE FRONT PASSENGER SIDE TIRE WAS ROTTEN AND RUBBER WAS CHIPPING OFF. THE CONTACT REMOVED AND REPLACED THE TIRE WITH THE SPARE. THE CONTACT WAS UNABLE TO LOCATE A DEALER TO REPLACE THE TIRE. THE TIRE WAS ORIGINAL EQUIPMENT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE TIRE LINE WAS UNAVAILABLE. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 1,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10840189March 7, 2016
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2016 DODGE RAM 3500. WHILE DRIVING AT AN UNKNOWN SPEED, THE SPEEDOMETER FAILED TO DISPLAY THE PROPER MILEAGE WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,060.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10839840March 4, 2016
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL* THE CONTACT OWNS A 2016 RAM 3500. THE CONTACT SMELLED AN ABNORMAL EXHAUST ODOR IN THE VEHICLE WHEN THE HEATER WAS RUNNING. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 4,128. UPDATED 05/03/16*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10839964March 4, 2016
STEERING
TL* THE CONTACT OWNS A 2013 RAM 3500. WHILE DRIVING APPROXIMATELY 75 MPH, THE FRONT END OF THE VEHICLE BEGAN TO VIBRATE VIOLENTLY AND THE CONTACT LOST STEERING CONTROL. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE AND MANEUVERED TO SIDE OF THE ROAD FOR A FEW MOMENTS. THE ENGINE WAS NOT TURNED OFF AND THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,500. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10839156March 1, 2016
STEERING
TL* THE CONTACT OWNS A 2014 RAM 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V541000 (STEERING); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10838049February 24, 2016
SEATS
TL* THE CONTACT OWNS A 2014 RAM 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V533000 (SEATS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10837095February 19, 2016
STEERING
THE DRAG LINK ADJUSTER FOR THE STEERING WHEEL WAS NOT TIGHTENED TO SPEC. THIS CAN RESULT IN LOSING STEERING CONTROL WHILE DRIVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10837119February 19, 2016
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2013 RAM 3500. THE CONTACT STATED THAT THE FRAME HAD A SPRING MOUNT THAT WAS NOT WELDED PROPERLY AND CAUSED THE SPRING MOUNT TO BECOME LOOSE AND SEPARATE FROM THE FRAME. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V541000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10836622February 17, 2016
SERVICE BRAKES, VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2014 RAM 3500. IN APRIL OF 2015, WHILE THE VEHICLE WAS IN REVERSE, THE BRAKES MALFUNCTIONED. THE CONTACT'S VEHICLE FAILED TO STOP AND BUMPED INTO A SECOND VEHICLE. THERE WERE NO INJURIES. WHILE DRIVING APPROXIMATELY 60 MPH, THE BRAKES SUDDENLY ACTIVATED WITHOUT THE BRAKE PEDAL BEING APPLIED. DURING THE INCIDENT, THE BRAKE SENSOR, ABS SENSOR AND THROTTLE SENSOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE BRAKE MODULE SENSOR AND TRANSMISSION SENSOR, BUT THE FAILURE RECURRED WHILE BEING TEST DRIVEN. IN NOVEMBER OF 2015, THE VEHICLE EXPERIENCED THE FAILURE AGAIN. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE STAR CONNECTOR. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 7,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10825061February 9, 2016
UNKNOWN OR OTHER
FAILURE OF FRONT HUB ASSEMBLY(BEARINGS) DUE TO EXCCESSIVE WEIGHT OF ENGINE ON UNDER RATED BEARING ASSEMBLY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10824932February 8, 2016
STEERING
TL* THE CONTACT OWNS A 2013 RAM 3500. WHILE DRIVING APPROXIMATELY 16 MPH, THE STEERING WHEEL LOCKED TEMPORARILY. THE DEALER DIAGNOSED THAT THE STEERING COLUMN BOX WAS FRACTURED AND THE TOWER SHOCK ASSEMBLY FRACTURED AND DAMAGED THE STEERING BOX. THE DEALER REPAIRED THE BOX, BUT NOT THE TOWER BRACKET. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10824933February 8, 2016
UNKNOWN OR OTHER
THERE IS AN EXTREME DELAY WHEN PRESSING THE ACCELERATOR AND ACTUAL ACCELERATION OF THE VEHICLE. THERE SEEMS TO BE NO CORRELATION BETWEEN HOW FAR THE ACCELERATOR IS PRESSED AND VEHICLE ACCELERATION. WHEN MERGING INTO TRAFFIC AND ESPECIALLY WHEN PULLING OUT INTO TRAFFIC, THIS DELAY IS A SEVERE SAFETY PROBLEM. THERE ARE TIMES THAT A 2-3 SECOND DELAY IS EXPERIENCED BETWEEN PRESSING THE ACCELERATOR AND THE VEHICLE ACTUALLY MOVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10824706February 7, 2016
SERVICE BRAKES
OEM TRAILER BRAKE CONTROLLER BARELY WORKS. TRIED WITH ALL 4 SETTINGS (TRAILER TOWING SHOULD HAVE NEEDED "ELECTRIC HEAVY" SETTING) HAD TO TURN THE GAIN ALL THE WAY UP TO GET THE BRAKES TO ENGAGE, PULLING AN EMPTY TRAILER. SHOULD BE ABLE TO COMPLETELY LOCK THE TRAILER BRAKES ON SETTING 10 FOR GAIN. TRAILER BRAKES ARE ADJUSTED CORRECTLY AND AFTERMARKET BRAKE CONTROLLER WORKS FINE WITH THAT TRAILER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10823640February 1, 2016
SERVICE BRAKES, UNKNOWN OR OTHER
INTEGRATED TRAILER BRAKE CONTROLLER FAILS TO PROVIDE SUFFICIENT BRAKING POWER TO TRAILER. ON SEVERAL OCCASIONS, TRUCK AND TRAILER WERE IN NEAR-MISS POTENTIAL ACCIDENTS DUE TO INSUFFICIENT TRAILER BRAKING. CONTROLLER WILL NOT HOLD TRAILER STILL WHILE THE TRUCK IS AT REST. REGARDLESS OF SETTINGS, INCLUDING MAX POWER SETTINGS AND USING THE MANUAL SLIDER FULLY ENGAGED, THE CONTROLLER WOULD NOT ACTIVATE THE TRAILER BRAKES SUFFICIENTLY TO SAFELY SLOW THE TRAILER IN ANY SITUATION. TRAILER IN QUESTION IS APPROXIMATELY 13,000#, DUAL AXLE WITH BRAKES ON BOTH AXLES. SECOND TRAILER WAS USED FOR TESTING WITH SIMILAR RESULTS, INCLUDING THE INABILITY TO CAUSE BRAKE LOCKUP OF AN EMPTY FLATBED TRAILER. DEALER REPLACED ITBM COMPONENT(S), WITH NO CHANGE. EXCUSED AS WORKING PROPERLY, EVEN WITH OBVIOUSLY INSUFFICIENT BRAKING ABILITY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10823078January 29, 2016
STEERING
TL* THE CONTACT OWNS A 2014 RAM 3500. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V541000 (STEERING); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE PARTS WOULD NOT BE AVAILABLE UNTIL MARCH OF 2016. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500