Mercury Mountaineer Complaints

1,992 consumer complaints on file.

#10144442December 5, 2005
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
I HAD A SPARK PLUG BLOW OUT OF MY 2002 MERCURY MOUNTAINEER 4.6L ENGINE. THE CAR HAS 86,000 MILES ON IT BUT THIS IS THE SECOND ENGINE. THE ORIGINAL ENGINE WAS REPLACED IN DEC 2003 WHEN IT HAD 49,000 MILES ON IT. THE ORIGINAL ENGINE SEIZED UP AFTER AN OIL PUMP FAILURE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143997November 30, 2005
AIR BAGS:FRONTAL
DT: THE CONTACT'S VEHICLE WAS INVOLVED IN A HEAD ON COLLISION WITH A TREE WHILE DRIVING AT 45 MPH. UPON IMPACT, THE FRONT AIR BAGS DID NOT DEPLOY. THERE WAS ONE INJURY REPORTED. THE INSURANCE COMPANY WAS NOTIFIED AND A REPORT WAS TAKEN. THE MANUFACTURER WAS CONTACTED. THEY REQUESTED THAT THE VEHICLE BE DELIVERED TO THEM FOR ANALYSIS. THE INSURANCE COMPANY HAD ALREADY TAKEN THE VEHICLE. A POLICE REPORT WAS TAKEN. *AK UPDATED 12/19/05. *JB
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10143056November 17, 2005
VEHICLE SPEED CONTROL, EQUIPMENT
PUT CAR IN REVERSE, HAD VERY FAST SUDDEN HIGH ACCELERATION WITHOUT TOUCHING THE THROTTLE. HELD BRAKES WITH BOTH FEET UNTI I COULD TURN IGNITION OFF. AFTER LOOKING FOR OBVIOUS SIGN OF PROBLEM (FOUND NONE), TURNED CAR BACK ON AND IT ACTED NORMAL. ALMOST RAN OVER MY SON. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143069November 17, 2005
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SPARK PLUG BLEW OUT OF CYLINDER HEAD AND STRIPPED THREADS. MERCURY MOUNTAINEER 2002. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10142306November 9, 2005
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
MY CHECK ENGINE LIGHT HAS BEEN COMING ON. I HAVE HAD VARIOUS SHOPS USE THEIR COMPUTER TO FIND OUT WHY THE LIGHT WAS ON AND HAVE PAID FOR CLEANING VALVES, SENSORS, AND HOSES AS WELL AS HAVING NEW SENSORS INSTALLED. THE FIRST INSTANCE OCCURRED AT 65, 475 MILEAGE ON MY VEHICLE. TODAY, THE SHOP WHERE I NOW TAKE MY VEHICLE FOR SERVICING USED THEIR COMPUTER TO SEE WHY THE CHECK ENGINE LIGHT WAS ON YET AGAIN AND IT GENERATED A TSB FROM FORD, ARTICLE 04-7-5 WHICH SUPERSEDES ARTICLE TSB 03-25-1. THIS ARTICLE STATES THE ISSUE AS "SOME 1998 EXPLORER/MOUNTAINEER VEHICLES EQUIPPED WITH THE 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE(S) P0420 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD-BANK 1) AND/OR P0430 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOL - BANK 2). THE ACTION LISTED FOR CORRECTION OF THIS PROBLEM IS STATED AS "TO SERVICE, REPROGRAM THE POWERTRAIN CONTROL MODULE (PCM) TO THE LATEST CALIBRATION USING WDS RELEASE B28.3 OR HIGHER. REPLACEMENT OF CATALYSTST IS NO LONGER NECESSARY TO ADDRESS THE MOST COMMON CAUSES OF THIS CONDITION." THIS SOUNDS LIKE A PROBLEM FORD INSTALLED ON THESE 1998 MOUNTAINEERS AND I BELIEVE FORD SHOULD BEAR THE COST OF REPROGRAMMING THE COMPUTER IN THE VEHICLE FOR THE VEHICLE TO FUNCTION PROPERLY AND SAFELY. THE WORKER AT THE SHOP TOOK THE TIME TO EXPLAIN TO ME WHAT THIS ARTICLE MEANT AND THE POSSIBLE RAMIFICATIONS TO THE FUNCTIONING OF MY VEHICLE BECAUSE OF THE PROBLEM CAUSED BY FORD NOT HAVING THE CORRECT COMPUTER PROGRAM RUNNING IN THE VEHICLE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141999November 7, 2005
ENGINE AND ENGINE COOLING:ENGINE
FORD MOTOR COMPANY MR. MIKE MCMULLIN DISTRICT MANAGER AUGUST 29,2005 DEAR SIR, I PURCHASED A 1998 MERCURY 5.0L MOUNTAINEER IN JULY 1999 AND IT CURRENTLY HAS SOME 85,000 MILES ON IT. LONG BEFORE THE 36-MONTH/36K MILES WARRANTY RAN OUT, I COMPLAINED TO MY FORD DEALER THAT I HEARD AN ENGINE NOISE THAT SOUNDS SOMETHING LIKE A HYDRAULIC VALVE LIFTER STICKING. IN TAKING MY CAR INTO AN INDEPENDENT SERVICE CENTER LATELY FOR SOME NON-WARRANTY MINOR SERVICE WORK, THE MECHANIC THERE ASKED ME HOW LONG I HAD BEEN EXPERIENCING THE ENGINE NOISE THAT HIS TRAINED EAR WAS HEARING. I INFORMED HIM THAT IT HAD BEEN CLICKING LIKE THAT FOR A GOOD LONG TIME. JUST FOR CURIOSITY HE CHECKED THE NHTSA WEB SITE FOR TECHNICAL SERVICE BULLETINS (TSBS). HE FOUND TO MY AMAZEMENT AND DISGUST THAT THE NHTSA SHOWED TSB #14489, ISSUED NOVEMBER 01,2000, CONTAINED THE FOLLOWING: ??SOME 1998-1999 EXPLORER/MOUNTAINEER VEHICLES BUILT THROUGH 01/1999 AND EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION NOISE COMING FROM THE #5 CYLINDER. ONE POSSIBLE CAUSE HAS BEEN IDENTIFIED AS THE LEFT A/C COMPRESSOR BRACKET COMING IN CONTACT WITH THE ENGINE BLOCK. THE BRACKET CAN APPLY PRESSURE ONTO THE CYLINDER WALL AND OVERTIME CAUSE THE CYLINDER WALL TO DISTORT RESULTING A NOISE DESCRIBED AS PISTON OR LIFTER NOISE. THE NOISE WILL BE WORSE ON COLD STARTS AND HOT DECELERATION, BUT WILL BE LESS SEVERE AT OPERATING TEMPERATURES. IF THE VEHICLE HAS OVER 12,000 MILES PLEASE REPLACE THE BRACKET WITH F87Z-3C511-CA AND INSTALL A FAR ENGINE REPLACEMENT (F77Z-6006??ARM FOR 1998 M/Y VEHICLES, XL2Z-6006-AARM FOR 1999 M/Y VEHICLES) FROM YOUR LOCAL SUPPLIER. THE BRACKET AND THE ENGINE MUST BE INSTALLED AT THE SAME TIME.?? I CONCLUDE THAT THE REPAIRS FOR THIS PROBLEM WHICH HAS BEEN ESTIMATED AT $4,828, SHOULD NOT BE BORN BY ME. I FEEL THAT EQUAL COST SHARING IN THIS MATTER WOULD BE A FAIR AND EQUITABLE TREATMENT. SINCERELY, PAUL G. BARBOZA. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141389November 1, 2005
ELECTRICAL SYSTEM:WIRING
LCD DISPLAY ON STEREO/CLOCK ONLY WORKS OCCASIONALLY MOST OF THE TIME THERE IS NOT A TIME DISPLAY AVAILABLE. AND WE HAVE VARIOUS GAUGES THAT WILL NOT WORK AND THEN WILL WORK FOR A BRIEF TIME AND THEN AGAIN STOP WORKING. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141198October 29, 2005
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
2002 MERCURY MOUNTAINEER STALLED OUT ON THE HIGHWAY AND HAD TO BE TOWED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140481October 21, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION
VEHICLE JERKS INTO REVERSE. VEHICLE WAS PLACED IN SHOP TO HAVE ADDITIVE PLACED IN TRANSMISSION FLUID TO CORRECT THE PROBLEM. THE PROBLEM HAS NOT ABATED. THE TRANSMISSION IS ALSO VERY LOOSE. AFTER BEING PLACED IN PARK IT LUNGES 3 TO 4 INCHES IN THE DIRECTION OF THE SLOPE IT IS PARKED ON. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140188October 19, 2005
VEHICLE SPEED CONTROL
PURCHASED A NEW 2005 MERCURY MOUNTAINEER IN 7/31/2005 THE FIRST TIME THE CAR ACCELERATED WHEN THE BRAKES WERE APPLIED AND THE CAR HAD TO BE PUT IN NEUTRAL TO STOP. THE DEALER REPORTED THAT THERE WERE NO KNOWN FIXES FOR THIS PROBLEM AT THIS TIME. THE SECOND TIME WHILE PULLING INTO MY DRIVEWAY WHEN THE BRAKES WERE APPLIED THE CAR ACCELERATED AND CRASH INTO MY GARAGE DOOR. THIS TIME THE DEALER BLAMED MY WIFE AND SAID SHE MUST HAVE PRESSED THE GAS AND BRAKE PEDDLES AT THE SAME TIME. THE CAR SUSTAINED FRONT END BODY DAMAGE AND MY GARAGE DOOR NEEDS TO BE REPLACED. THE CAR HAS BEEN AT THE DEALER SINCE THE ACCIDENT HAPPENED AND WE ARE STILL WAITING TO FIND OUT WHAT IS FORD'S DETERMINATION OF THIS ISSUE AND WHAT THEY WILL DO TO GET US OUT OF THIS CAR AND INTO SOMETHING ELSE. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10140159October 18, 2005
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH, AIR BAGS
OCTOBER 18, 2005 U. S. DEPARTMENT OF TRANSPORTATION NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION OFFICE OF DEFECTS INVESTIGATION NVS-210, 400 7TH STREET SW WASHINGTON, DC 20590 DEAR DEPARTMENT OF TRANSPORTATION: I AM WRITING BECAUSE OF A SAFETY CONCERN WITH MERCURY 2000 MOUNTAINEER. MY MOUNTAINEER, VIN #[XXX], HAS A PROBLEM WITH THE AIRBAG SAFETY SYSTEM. I BELIEVE THIS PROBLEM IS CAUSED BY A DESIGN DEFICIENCY. THE AIRBAG WARNING LIGHT ON MY INSTRUMENT PANEL FLASHES SEVERAL TIMES AND THEN COMES ON STEADY. I TOOK IT IN FOR REPAIR AND THE SERVICE REPRESENTATIVE AT THE FORD DEALER TOLD ME THE WIRING HARNESS WAS BAD. THEY SAID THAT TESTS SHOWED THAT THE HARNESS WAS CORRODED. SINCE THE HARNESS RUNS UNDER THE CARPET ON THE FLOOR, WATER AND SALT HAD PROBABLY ENTERED THE HARNESS AND CORRODED IT. THEY SAID THAT MY AIRBAG SYSTEM WAS UNRELIABLE. I BELIEVE IT IS UNREASONABLE AND DANGEROUS TO INSTALL A CRITICAL SAFETY SYSTEM COMPONENT IN A KNOWN LOCATION OF CORROSIVES AND MOISTURE, UNLESS THAT COMPONENT IS DESIGNED TO PROTECT AGAINST THOSE HAZARDS. IT APPEARS THAT THE AIRBAG WIRING HARNESS IS NOT SO DESIGNED. AS THESE VEHICLES AGE, THIS COULD BECOME MORE AND MORE OF A PROBLEM. THE REPAIR IS EXPENSIVE, I WAS QUOTED $970. THE TRADE IN VALUE OF MY VEHICLE IS ABOUT $8600. AS THESE VEHICLES AGE THEY WILL HAVE LESS AND LESS VALUE AND THE COST OF REPAIR WILL BECOME A LARGER AND LARGER PERCENTAGE OF VEHICLE VALUE. I BELIEVE YOU SHOULD QUERY FORD MOTOR COMPANY AND FIND OUT HOW PREVALENT THIS PROBLEM IS AND SEE IF THE FREQUENCY OF THE PROBLEM IS INCREASING. IT SHOULD CONTINUE TO BE MONITORED AS THESE VEHICLES AGE. PERHAPS MERCURY SHOULD ACT TO REPLACE THESE HARNESSES BEFORE THEY BECOME INOPERATIVE. [XXX] *NM UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136572October 18, 2005
ELECTRICAL SYSTEM:IGNITION:SWITCH, STRUCTURE, EQUIPMENT, POWER TRAIN:AUTOMATIC TRANSMISSION
DT: THE CALLER SAID VEHICLE STALLED WITHOUT WARNING SEVERAL TIMES. SHE STATED THAT IT DID START BACK UP. SHE TOOK THE VEHICLE TO THE DEALER THREE TIMES. DEALER SAID THEY FIXED IT EACH TIME. SHE SENT MANUFACTURER A LETTER ON THE PROBLEM AND OTHER PROBLEMS. ALSO, THE CALLER STATED THAT SHE HAD THE IGNITION SWITCH REPLACED, AND NOW WHEN SHE TAKES IT OUT OF PARK SOMETHING POPS. DEALER WILL NOT DO ANYTHING ELSE TO HELP HER WITH THE IGNITION SWITCH. *AK THE DAY TIME RUNNING LIGHTS DID NOT STAY ON, THE CONSUMER HEARD WIND NOISE COMING FROM THE VEHICLE, THE CIGARETTE LIGHTER DID NOT WORK, THERE WAS A POPPING NOISE WHEN THE CONSUMER PLACED THE VEHICLE INTO GEAR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10139426October 12, 2005
VEHICLE SPEED CONTROL, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
MY WIFE WAS PULLING INTO A PARKING SPACE WHEN THE VEHICLE SURGED FORWARD RESULTING IN A CRASH WITH A METAL HAND RAIL AND TWO AIR CONDITIONING UNITS. NO DEFINITIVE CAUSE HAS BEEN ESTABLISHED EXCEPT. A WITNESS SAYS SHE HEARD AN ENGINE REV UP JUST PRIOR TO THE CRASH. *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10139892October 6, 2005
VISIBILITY:WINDSHIELD
THERE WAS A RECALL ON REAR WINDSHIELD GLASS ON CERTAIN FORD MOTOR COMPANY VEHICLES. THE INSURANCE COMPANIES INVESTIGATION DETERMINED THAT THE DAMAGE SUSTAINED BY THE CONSUMER'S VEHICLE WAS FROM A FLAW IN THE REAR WINDSHIELD GLASS. THE INSURANCE COMPANY REQUEST REIMBURSEMENT FROM FORD. *TS *NM ***TRANSFER TO OCC***
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10099706October 3, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
WHEN BRAKING BRAKES FAILED, CAUSING THE VEHICLE TO GO INTO AN EMBANKMENT. VEHICLE WAS TOWED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK *NM
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10138822September 29, 2005
ELECTRICAL SYSTEM
CONSUMER LOST USE OF ALL ACCESSORIES IE. LIGHTS, MIRRORS, POWER DOOR LOCKS, WIPERS POWER WINDOWS ETC. THE CONSUMER HAD GEM MODULE AND WIPER MOTOR REPLACED. *TS *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10129122September 29, 2005
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR, TIRES
1999 MERCURY MOUNTAINEER TIRE BLOW OUT OCCURRED WHILE DRIVING AT 70 MPH.***NO ANSWER REQUIRED***. *MR *JB THE CONSUMER WAS TOLD THE ROTORS WERE OUT OF ROUND.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137684September 26, 2005
AIR BAGS, FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
INTERMITTENT AIRBAG LIGHT WOULD COME ON. WHEN I TOOK TO DEALERSHIP, IT WAS ALWAYS OUT, AND INSTEAD OF PAYING EXTRAVAGANT DIAGNOSTIC FEES THEY SAID MAY NOT SHOW PROBLEM, I DID NOT GET IT LOOKED AT. IT WAS REPAIRED TODAY....A HARNESS ELECTRICAL SHORTAGE WHICH I FEEL SHOULD NOT BE CHARGED TO THE CUSTOMER. THE SHORT IS FOR SOMETHING THAT ONLY A CERTIFIED TECH REPAIRS. AIRBAGS HARNESSES ON THIS VEHICLE PER THE REPAIR TECH GO OUT REGULARLY, WHICH SOUNDS LIKE A DEFECT TO ME. THE REPAIR PASSED ON TO ME WAS MORE THAN $300! ALSO, IAC ATTACHED WITH TOO LITTLE SILICONE, WHICH CAUSES THE IAC TO BURN AND MALFUNCTION. IT WAS ALSO REPAIRED. I DO NOT HAVE PARTS.....DEALERSHIP KEPT THEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136995September 19, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAD NO WARNING THAT THE AUTOMATIC TRANSMISSION IN MY 2002 MERCURY MOUNTAINEER AT 55,000 MILES WAS GOING OUT. THE O/D LIGHT CAME ON FLASHING AND THE CHECK TRANSMISSION LIGHT CAME ON FLASHING. THE SPEED OF THE VEHICLE WOULD NOT ACCELERATE PAST 20 MPH. I IMMEDIATELY TOOK IT TO THE MERCURY DEALERSHIP AND THEY REPAIRED THE LEAKING DIFFERENTIAL SEALS IN THE REAR OF THE VEHICLE AND THE PINION SEALS IN THE FRONT OF THE VEHICLE. THEY CHECKED THE TRANSMISSION FLUID AND IT WAS FULL. AFTER 424.00 THE PROBLEM WAS STILL THERE. TOOK VEHICLE TO TRANSMISSION SPECIALTY SHOP AND THE VEHICLE IS IN THE SHOP AT THIS HOUR HAVING THE TRANSMISSION YANKED OUT AND REPAIRED. THIS IS MY FIRST FORD VEHICLE AND MY LAST. THERE SEEMS TO BE A TRANSMISSION ISSUE REGARDING FORD/MERCURY VEHICLES AND THERE SHOULD HAVE BEEN SOMETHING DONE ABOUT THIS LONG BEFORE NOW.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136141September 11, 2005
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS, SEAT BELTS:FRONT, VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
BACK LIFT SHATTERED WHEN CLOSING, RESULTING IN SHATTERED GLASS EVERYWHERE AND BRACKETS HANGING (IT WAS RAINING OUTSIDE!). I DROVE CAR TO DEALER WHO PROVIDED A REPLACEMENT CAR DURING REPAIRS BUT IT TOOK 6 WEEKS TO REPAIR. THEN WHEN I WAS CALLED TO PICK UP THE CAR I WAS TOLD THE "CHECK ENGINE SOON LIGHT" IS COMING ON! WHEN I PICKED IT UP, I NOT ONLY SEE THE LIGHT IS INTERMITTENT COMING ON, BUT MY ELECTRIC WINDOW SWITCHES ARE NOT WORKING TO PUT THE WINDOWS UP AND DOWN (EXCEPT THE FRONT PASSENGER WORKS FINE) AND THE DRIVER SEAT BELT IS NOT RETRACTING CORRECTLY! THIS CAR IS ONLY 3 YEARS OLD!! *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercury Mountaineer