Jeep · Model Report
Showing safety data for the 1999 model year only.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE LEFT SIDE AND RIGHT SIDE INSTRUMENT PANEL WIRING GROUND ATTACHMENT SCREWS COULD LOOSEN OVER TIME.
The contact owns a 1999 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the rear subframe fractured near the axle. The vehicle was taken to an independent mechanic who diagnosed that the subframe was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
No injuries · No fire · No crash
I STARTED HEARING A BANGING/CLANGING NOISE UNDER THE REAR OF THIS VEHICLE UPON STARTING/STOPPING OR REVERSING. THE NOISE IS BEST DESCRIBED AS A SHARP METALLIC CLANG. UNDERCAR INSPECTION REVEALED THE FRAME HAS CORRODED TO THE POINT THE UPPER CONTROL ARM MOUNTS HAVE PULLED AWAY FROM THE FRAME AND THE TRACK BAR THAT LOCATES THE AXLE SIDE-TO-SIDE HAS SEPARATED FROM THE REAR AXLE HOUSING ALONG WITH THE UPPER CONTROL ARM MOUNT SEPARATING FROM THE AXLE HOUSING. REPAIR OF THIS VEHICLE REQUIRES REPLACEMENT OF THE FRAME ALONG WITH REPLACEMENT OF THE COMPLETE REAR SUSPENSION AND AXLE HOUSING. THIS SAME VEHICLE WAS REPORTED TO YOU 03 NOVEMBER 2016 FOR THE SAME ISSUE INVOLVING THE CENTER SECTION OF THE FRAME RUSTING THROUGH CAUSING THE TRANSFER CASE MOUNT/SKID PLATE TO DROP. SAFETY CAPS WERE INSTALLED ON THE FRAME AT THIS TIME AND THE VEHICLE WAS PLACED BACK INTO SERVICE.
No injuries · No fire · No crash
FRAME ROTTED FROM RUST WHERE THE REAR SUSPENSION ATTACHES TO THE FRAME. TOO MUCH RUST TO REPAIR. REMAINING VEHICLE IS IN GOOD SHAPE CONSIDERING ONLY 107K MILES. SUSPENSION BROKE FREE FROM THE FRAME DURING NORMAL ROAD OPERATION. I AM TOLD THAT THE PROBLEM IS EPIDEMIC WITH JEEP TJ FRAMES. APPARENTLY SO BECAUSE THERE IS NOTING AVAILABLE ON THE USED PARTS MARKET. LOTS OF TJ BODIES AND PARTS AVAILABLE BUT NO FRAMES TO GO ALONG WITH THEM.
No injuries · No fire · No crash
JEEP IS A 5 SPEED TRANSMISSION. COULDN'T SHIFT CORRECTLY, HEARD A RATTLE. ENGINE HAD FALLEN DUE TO RUSTING FRAME. FRAME SO RUSTED, ENGINE FELL. ONLY 90,000 MILES ON VEHICLE. NOT DRIVEN DAILY. WAS IN MOTION.
No injuries · No fire · No crash
JEEP FRAME ROTTED ABOVE REAR AXLE
No injuries · No fire · No crash