Hyundai Ioniq 5 Complaints (2025)

290 consumer complaints on file.

#11758690August 22, 2026
ELECTRICAL SYSTEM
My car starting throwing a “check electric vehicle system” warning intermittently beginning on July 7, 2026 which went away when I restarted the car. This happened again on July 27, 2026 three to four times while I was driving. The car did not lose power. As I was going to dealer the warning cleared and no code showed up in my diagnostic history. On August 12, 2026, the car once again showed "check electric vehicle system” and would initially clear when I restarted the car. I then began having intermittent power. Floored, the car would only go 27 mph. Then it would speed up again, then slow again. I was not in “turtle mode.” Luckily, I was able to safely get the car to the dealership without having an accident. DTC P1A8D13 did show in my diagnostics. The technician found that the 12v battery input had melted at the ICCU. This is very dangerous and could have led to a vehicle fire. My 2025 is on its 2nd ICCU (now 3rd) and has not had any recalls, so this is very troubling.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757520August 17, 2026
ELECTRICAL SYSTEM
ICCU failure. Failure happened while merging onto the road from driveway. Upon failure, 12 V battery was drained and car was immobilized. Prior to car mobilization dash read “Check electrical vehicle system” then many different failures appeared on the dash, then the car shut down. This event left us stranded on the road, unable to move to a safer location. Issue was confirmed with dealer and part had to be replaced. Part was original to the car and issue is known by the manufacturer but not being dealt with publicly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757439August 17, 2026
WHEELS
While driving on normal paved roads, a small vibration was heard from the rear of the vehicle. A person near the car when leaving the origin that morning heard a minor clicking sound at low speed from the rear of the vehicle. The vibration at that point seemed to be related to the rural mountain road that had some rutting. Continuing to drive, but onto better roads, the vibration became louder and louder, and appeared related to speed. Nothing appeared loose when stopping to charge. Vibration became loud (above conversation), stopped to inspect. Removed aerodynamic cover from lug nuts on right rear, and found two lugnuts completely sheared off (fell out when cover removed), with a third hanging on at less-than-finger tight. Vehicle driven slowly to safe location where it was towed to dealer. Dealer reported that the rim was bent in addition to sheared lug nuts as well as a damaged wheel bearing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757298August 16, 2026
ELECTRICAL SYSTEM
In June 2025, I started a lease on a new Hyundai Ioniq 5 SEL. On August 16, 2026, I attempted to start the car, but it immediately beeped and flashed a warning about the 12V battery (I didn't manage to take a picture). It then showed signs of an electrical issue, like flickering interior and exterior lights. It was undrivable. A short time later, there was no power at all. I took out the old 12V battery and measured the voltage with a multimeter, and observed 3.7V. After putting in a new battery, the car operated normally.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757147August 15, 2026
TIRES
Two tires failed dramatically, (on two separate days, but separated by only 121 miles of driving), causing extensive damage the first time and causing a total loss the second time. The first tire has been disposed of, but the second is available still. Each was on the highway and luckily there was not much traffic so I was able to pull safely onto the shoulder each time. However, if I had not been able to get over, our safety and that of others was at risk if we had been involved in a collision. My safety and my that of my elderly, handicapped brother was at risk the first time especially, because this is an EV and at one point on July 4, 100 degree temperatures in the early afternoon in South Carolina, the electrical system had been damaged and we could not, for a few minutes, get doors or windows open. The components (tires) have only been inspected by repair shops. There was no warning either time. The tires are 235/55 R 19.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756602August 12, 2026
ELECTRICAL SYSTEM, POWER TRAIN
I started the car and got the warning "check electric vehicle system." The car then lost power. It would only go 27mph with the accelerator pedal pushed all the way to the floor. My safety was at risk because my car was not responding appropriately to driver input. The car is at the dealership as it is undriveable in this condition. This is the second incident with this vehicle within 6 months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756527August 12, 2026
LANE DEPARTURE: ASSIST, LANE DEPARTURE: WARNING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
When I use the adaptive cruise control and use the lane keeping assistance the system keeps giving me an error message that I'm not looking at the road. I believe this is a known problem and Hyundai pushed an software fix TSB 25-G1-16H in November 2025. My car appears to have the update but still repeatedly gives me the same error message. It's very distracting and since the error message flashes on dash where you usually see the camera monitoring right side of car that feature is impaired. I have had at dealership twice and while the technician knows its an issue there's nothing they can do without Hyundai's decision to correctly fix with software update. I am over 6' tall and where glasses, two things I can't change.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756375August 11, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
My 2025 Hyundai Ioniq 5 experienced a complete and sudden loss of drive power at high speed, generating open fault code DTC P1A9096 (Internal ICCU Failure) [24V-204]. This failure completely matches the component and safety hazard profile under active Federal Safety Recalls 24V-204 and 24V-868 [24V-204].The vehicle was repaired at an authorized retail facility, Hyundai of El Cajon. The facility's un-finalized pre-invoice explicitly verified the ICCU failure code but deliberately omitted the federal safety recall context, routing the mechanical intervention under an internal manufacturer 'TSB 24-EV-004H' to hide the defect from consumer safety databases [24V-204].This represents a deceptive administrative effort to under-report active federal safety recall failures on newer model inventories across the E-GMP platform architecture [24V-204]. I am requesting a formal safety defect enforcement review into the manufacturer's regional reporting data.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754835August 4, 2026
ELECTRICAL SYSTEM
The vehicle was released to me as repaired by an authorized Hyundai dealer earlier the same day. While driving home, the vehicle entered reduced-power/turtle mode and lost propulsion capability. This is the third failure of the electrical/propulsion system in under three months on a vehicle less than one year old, and it occurred within hours of a warranty repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754834August 4, 2026
ELECTRICAL SYSTEM
While driving at 65–70 mph in rain, the vehicle emitted a repeated audible alarm from beneath the rear seat, then suffered a complete loss of motive power at highway speed. No warning light, message, or indicator appeared on the instrument cluster at any point. The vehicle was taken to an authorized Hyundai dealer the following day.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754831August 4, 2026
ELECTRICAL SYSTEM
While operating the vehicle, the instrument cluster displayed a “Check electric vehicle system” warning with a red vehicle-with-exclamation icon. The vehicle failed to charge when plugged in; state of charge was 90%. The vehicle was towed via Bluelink to an authorized Hyundai dealer. No prior issues and no damage history.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754271August 2, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Check electric system popped up. DTC: P1AD300 Critical hybrid/ev battery system fault involving abnormal cell voltage deviation 9,902 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754142August 1, 2026
FUEL/PROPULSION SYSTEM
SAFETY DEFECT REPORT: 2025 HYUNDAI IONIQ 5 HIGH-VOLTAGE BATTERY FAILURE On Sunday, July 5, 2026, at approximately 24,000 miles, the vehicle suddenly displayed a critical dashboard safety alert notifying me of an electrical propulsion failure and explicitly instructing me not to drive the vehicle. The sudden failure entirely disabled the vehicle's driving power and compromised its operational safety. The vehicle was removed from my possession via a flatbed tow on Wednesday, July 8, 2026, and delivered to Southern States Hyundai. On July 11, 2026, the dealership service technicians diagnosed a total high-voltage traction battery pack failure. The dealer opened Repair Order 9651579, and Hyundai Corporate approved a full warranty replacement of the $28,000 battery system. The vehicle remained out of service due to this safety defect for 21 cumulative days until the component replacement was completed on July 29, 2026.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752923July 26, 2026
TIRES
I need to report a serious vehicle safety concern involving a catastrophic front-right tire failure at highway speed. I am requesting a Hyundai case number and preservation of all physical evidence. Please preserve the failed tire, detached tread assembly, bead remnants, wheel, TPMS components and all service records. These items constitute material evidence necessary to determine whether the initiating cause was underinflation, rapid pressure loss, mounting damage, belt separation, bead failure or a manufacturing defect. The vehicle had been returned after approximately one month at a repair facility. After the incident, the three remaining tires measured 41, 35 and 35 psi, while the vehicle placard specifies 38 psi. The pre-failure pressure of the destroyed tire is unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751511July 20, 2026
ELECTRICAL SYSTEM
EV system not working on car with 8k miles on it. Dealer backed up and cannot offer rental car. This is a safety issue for me . This is a KNOWN issue for Hyundai and they are not recalling and their dealers are not equipped to resolve quickly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751250July 18, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Systemic failure of the electrical architecture and Integrated Charging Control Unit (ICCU) resulting in a sudden, catastrophic loss of motive power. Over 14 months of ownership, this vehicle has suffered four distinct, electrical and charging failures. On June 6, 2026, the vehicle experienced a total ICCU failure. All lights in the car went dark and lost all power without warning, creating an immediate and life-threatening hazard to myself . The vehicle had to be towed. Three prior repair attempts for charging and 12V battery failures were made by the dealer/. They replaced the ICCU, the car currently runs.. The replaced ICCU has not been redesigned and as a result the car is unsafe to take out on the highway or on a long drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750561July 15, 2026
FUEL/PROPULSION SYSTEM, ENGINE
The car entered a failed ICCU state (not confirmed until the car was looked at by Hyundai at the dealership) while I was driving down to Ano Nuevo regional park. Received a warning on the dash that said that electrical system has failed and to pull over. It restricted me from going over 10 mph on Highway 1 and I eventually pulled over the side of the road and got towed to the dealership. The car is home with me now but I do not feel safe driving this vehicle after all of the reports of ICCU failures. I am very concerned this will happen again and in a more dangerous situation. I was also stranded by this car in March 2026 with a dead battery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749766July 11, 2026
POWER TRAIN, UNKNOWN OR OTHER
I was slowing down, actively pressing the brake pedal to bring the vehicle to a full stop. As the car decelerated to what my senses and perception registered as a full stop, I pressed the “P” (Park) button while keeping my foot on the brake pedal. I felt the physical click of the “P” button under my thumb while still holding the brake, and my mind registered that the vehicle had successfully transitioned into Park. Before turning around, I visually confirmed that the vehicle had come to a complete stop. Believing it was fully secured in Park, I turned my head to check on my child in the back seat and naturally released the brake pedal completely. However, the system had actually rejected my command. I assume that the vehicle likely still had a small amount of speed at the exact millisecond I pressed the button, and the computer automatically blocked the “Park” command and kept the car in gear. Because an electric vehicle operates in almost complete silence, with no engine noise or vibration to indicate that it is still in gear, there was no auditory or physical cue to alert me that the car was moving when I released the brake. While my attention was turned toward the back seat for a few seconds, the car quietly began to creep forward, leading directly to the collision with the car in front of me. Following the accident, I found that the vehicle produces slightly different sounds when Park is rejected and when it is successfully engaged. However, the owner’s manual describes only the dashboard message and does not describe these sounds or explain how to distinguish them, so their meanings may be learned only through the failure. At the time of the incident, I was not familiar with the distinction between these two sounds. Because my brain processed the physical press of the button as a successful action, and I had visually confirmed that we were not moving, my focus immediately shifted to my child. I was entirely misled by the digital interface.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11749630July 10, 2026
ELECTRICAL SYSTEM
Failure of ICCU and high voltage fuse. Known issue in this vehicle. 2022-24 have been recalled. 2025 needs to be recalled. Warning on dash when it occurred, then 12V battery died. Undrivable. Towed in and repaired under warranty by dealer. But apparently it can happen again because Hyundai doesn’t know how to permanently address the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749425July 9, 2026
ELECTRICAL SYSTEM, POWER TRAIN
During a family road trip, my 2025 Hyundai Ioniq 5 (~9,000 miles, less than one year old) suddenly showed red "Check Electric Vehicle System" and 12V battery warning lights and then completely lost power. The 12V system failed entirely - the vehicle could not be driven or shifted, and the doors and the rear hatch could not be locked or unlocked. It had to be flat-bedded to a Hyundai dealer because it was completely inoperable. The dealer diagnosed a failed ICCU (Integrated Charging Control Unit) and a blown ICCU safety fuse (fault code P1A9096) and is replacing both under warranty; the component is available for inspection. The ICCU converts high-voltage battery power to charge the 12V system; when it fails, the vehicle loses all electrical power and drive capability. The warning lamps appeared immediately before total power loss, with no prior symptoms at the last scheduled service. This is a known, safety-critical failure on this platform: a sudden, complete loss of power can strand occupants and, if it occurs while driving, cause loss of motive power - a serious crash risk. My vehicle was stationary when it failed, but the same failure at speed would be extremely dangerous. I have video evidence of the car completely bricked out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Ioniq 5