Ford Five Hundred Complaints

1,073 consumer complaints on file.

#11365647October 21, 2020
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
BATTERY JUST GOES DEAD OVER NIGHT. SIGNAL LIGHTS MELTED AND QUIT WORKING. CLUSTER PANEL JUST SHUTS OFF WHILE RUNNING AND CAN'T USE AIR, RADIO, WINDOWS, LOCKS, SEATS, ETC. CAR SHUTS OFF WHILE DRIVING DOWN THE ROAD. HAVE REPLACED ALL PARTS SUGGESTED BY CODES. STILL NO FIX. WONT SHIFT FROM FIRST GEAR AFTER CLUSTER PANEL SHUTS OFF. THERE ARE HUNDREDS OTHER COMPLAINTS. THIS IS DANGEROUS AND SHOULD BE AN ELECTRICAL RECALL. HAPPENS RUNNING DRIVING AND SITTING STILL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11360327September 21, 2020
FUEL/PROPULSION SYSTEM, POWER TRAIN
THE INTAKE MANIFOLD IS MELTING ON THE INSIDE CAUSING MELTING PLASTIC TO DRIP INTO THE THROTTLE BODY,CAUSING THE CAR TO RUN VERY POORLY ARE NOT AT ALL!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354790September 13, 2020
STRUCTURE:BODY, ENGINE, STEERING
GOT INTO AN ACCIDENT AND RIGHT MIRROR WAS FULLY BROKEN. RIGHT SIDE OF THE BODY WAS ALSO SMASHED IN. LEFT BRAKE LIGHTS STOPPED WORKING AND ENGINE MAKES WEIRD SOUNDS.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11352005August 29, 2020
ELECTRONIC STABILITY CONTROL (ESC), ENGINE
THE CAR IS SURGING AND FEELS LIKE IT IS ABOUT TO FALL APART THE CAR HAS LOW MILES AND THE ENGINE FEELS LIKE THE TRANSMISSION IS SLIPPING BUT WAS TOLD THAT THIS IS A COMMON PROBLEM WITH THE FORD 500 I SEE THERE IS A EXTENDED WARRANTY BUT I JUST RECENTLY PURCHASED THIS CAR AND SEEMS LIKE THE WARRANTY EXPIRED AND I SEE FORD IS AWARE OF THIS AND REFUSES TO FIX THIS ISSUE WHICH IS A HAZARDOUS CONDITION AND I FEEL LIKE THAT IM GOING TO HAVE TO GET A LAWYER TO GET ANYTHING DONE BECAUSE FORD IS REFUSING TO FIX THIS ISSUE WITH THESE CARS AND ITS VERY DANGEROUS DRIVING THE CAR MAKES A LOUD KNOCK AND THE ENGINE DROPS BACK IN AND ITS BREAKING THE MOTOR MOUNTS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11348696August 11, 2020
POWER TRAIN
RECEIVED A CODE STATING THAT I HAVE A FAULTY PCM. WHEN I DRIVE ALL THE LIGHTS COME ON AND THE SPEED GAUGE SHUTS DOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11338439July 9, 2020
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
I HAD THIS CAR REPAIRED TWICE AT A PROFESSIONAL MECHANIC SHOP THAT COST ME THOUSANDS OF DOLLARS. EVERY TIME, THE CAR COMES TO STOP OR DIES ON ME. I REPLACED THE FUEL FILTER ONE TIME THAT IS UNDERNEATH THE CAR. NOW THE CAR IS SITTING IN MY GARAGE BECAUSE OF THE FUEL PUMP NOT FUNCTIONING AND DOES NOT MAKE THAT SOUND ANYMORE WHEN YOU TURN THE KEY ON.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11322586April 28, 2020
FUEL/PROPULSION SYSTEM
WHEN I BOUGHT THE CAR HAD ENGINE LIGHT ON SO REPLACE THE SPARK PLUGS AND PUT NEW BATTERY PROBLEM STILL THERE. HAD A MECHANIC CHECK OUT AND HE SAID CODES READING FUEL PROBLEM SO CHANGE OUT THE FUEL PUMP AND PUT INJECTOR CLEANER. PROBLEM STILL THERE HE SAID MAYBE THE COMPUTER SO NOW I DON'T KNOW WHAT TO DO. THE PROBLEM IS CHECK ENGINE LIGHT ON AND WHEN YOU STEP ON THE THROTTLE DOES NOT GO PASS 3000 RPM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11322158April 24, 2020
FUEL/PROPULSION SYSTEM
THE FUEL SYSTEM IS MALFUNCTIONING. THE FUEL TANK HAS A CRACK CAUSED BY A WELDING POINT ON THE FUEL TANK WAS BROKEN LOOSE. OVER TIME I SAW MY FUEL GAUGE DROP DRAMATICALLY. THIS CAUSES ME TO GET GAS MORE OFTEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11310704February 22, 2020
ELECTRICAL SYSTEM
IT BEGAN WITH THE 12 VOLT NOT WORKING. PUT IN NEW FUSE IT BLEW. THEN INSTRUMENT PANEL SPEEDOMETER GOES BLACK, IF YOU GOT THE DASH IT COMES BACK ON THE BATTERY GOT COMPLETELY DRAINED BOUGHT A NEW ONE. STILL HAVE A SHORT SOMEWHERE . NOTICED A MILLION OTHER COMPLAINTS THE SAME SHOULD THIS NOT BE INVESTIGATED? A SODERING DEFECT OR ELECTRICAL SHORT DRAINING BATTERY, IT'S OBVIOUSLY A VEHICLE DEFECT. ISN'T FORD A BIG ENOUGH COMPANY TO TAKE CARE OF THIS INSTEAD OF IGNORING IT? THIS IS ON A 2007 FORD 500, LOW MILES. THIS HAPPENS SITTING STILL OR DRIVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11309959February 18, 2020
ELECTRICAL SYSTEM, SUSPENSION, UNKNOWN OR OTHER
I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT VEFORE ALL OF THIS I KEPT GOING THROUGH FUEL RELAY ISSUES AND EVENTUALLY STARTED LOSING MY INSTRUMENT CLUSTER SO NOW I'M FIGHTING WITH THEM TO DO THE REPAIRS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11308904February 13, 2020
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
CAR IS LEAKING FUEL FROM THE GAS TANK AREA, LOOKS LIKE ITS LEAKING FROM THE FILLER NECK. AT TIMES IT LEAKS A CONSIDERABLE AMOUNT. I'M ALSO HAVING SURGING ISSUES. MAINLY AT LOW SPEEDS. THE VEHICLE HAS ALSO SHUT DOWN IN THE MIDDLE OF TRAFFIC. THESE PROBLEMS TRULY CONCERN ME AND I QUESTION THE SAFETY OF THE VEHICLE AND MY CHILDREN AND MYSELF WHILE IN THIS VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11307809February 7, 2020
SERVICE BRAKES
THE BRAKES ARE SPONGY. VERY SELDOM THEY WILL BE NORMAL. MOST OF THE TIME THEY WILL BE SOFT AND HAVE TO BE PUMPED. SOMETIMES THE BRAKES WILL BE FIRM FOR A COUPLE OF SECONDS AND THEN THE PEDAL WILL SINK TO THE FLOORBOARDS. THIS OCCURS DURING DURING NORMAL DRIVING AND STOPPING AND ALSO OCCURS WHEN VEHICLE IS IN PARKED. BRAKES HAVE BEEN PROFESSIONALLY SERVICED INCLUDING HOOKED TO A COMPUTER FOR PROPER BLEEDING. PROBLEM HAS NOT BEEN RESOLVED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11306524February 2, 2020
FUEL/PROPULSION SYSTEM
THE CAR JERKS WHEN ACCELERATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11300540January 20, 2020
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
I DON'T KNOW IF THIS BELONGS IN ENGINE OR FUEL/PROPULSION SYSTEM. THERE WAS NO MENTION OF 'GAS PEDDLE' IN EITHER. THE DATE OF 07/17/2013 IS APPROXIMATE. IT MAY HAVE BEEN BETWEEN 2013 - 2015. I AM NOT SURE OF THE EXACT DATES. IT WAS WHEN I WAS GOING TO A PAIN SPECIALIST IN BUFFALO AFTER MY REAR-END ACCIDENT IN MY PREVIOUS CAR IN JULY 2012. LOCATION - I-190 & NY-198 BUFFALO, NY 14207 42.930405, -78.899552 MERGE RAMP FROM THE NY-198 TO THE I-190 NORTH. 2007 FORD FIVE HUNDRED THE PROBLEM: THE GAS PEDDLE STUCK WHEN I HAD TO DO A FAST ACCELERATION / I FLOORED IT. I HAD TO PUT THE CAR IN NEUTRAL AND PRESS THE GAS PEDDLE A COUPLE TIMES TO GET IT UNSTUCK. I HAD IT IN TO THE FORD DEALER WHERE I BOUGHT IT AND THEY FIXED OR CLEANED SOMETHING. THE FORD DEALER SAID THAT IT WOULD COST ABOUT $400.00 TO REPLACE THE COMPONENT IF THIS DIDN'T WORK. IT HAPPENED AGAIN WHEN I DID ANOTHER FAST ACCELERATION. I WAS ABLE AGAIN TO GET IT UNSTUCK. I HAVE NOT HAD THE OCCASION TO DO A FAST ACCELERATION SINCE. I DON'T RUN IT FAST IF I CAN HELP IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11297823January 7, 2020
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
CAUSE UNKNOWN- BATTERY LIGHT IS COMING ON MORE WHILE VEHICLE IS RUNNING IN ALL MODES, LOCAL AUTO STORE DETERMINED IT IS AN ELECTRICAL PROBLEM. THEY TESTED THE BATTERY, ALTERNATOR & STARTER. ALSO NOTICED THAT THERE IS A MUSTY SMELL & MANY ( IF NOT ALL) OF MY METAL PARTS ARE RUSTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11289904December 18, 2019
ELECTRICAL SYSTEM
THIS IS A LONG ON GOING PROBLEM WITH THE ELECTRICAL PROBLEM THAT HAS BEEN GOING ON NOW FOR FIVE MONTHS. STARTED OUT HAVING THE BATTERY CLUSTER LIGHT ON & CHECK CHARGING SYSTEM. FOUND CHARGING A LITTLE LOW, HAD NEW ALTERNATOR INSTALLED. THEN WITH A WEEK, BATTERY, ENGINE LIGHT & AIRBAG LIGHT CLUSTER ARE ON, THEN THE FUN BEGAN, THEN ALL THE INSTRUMENT CLUSTER GOES OFF AND YOU HAVE NO TURN SIGNALS, NO FANS, NO RADIO, NO ELECTRIC WINDOWS, NO DOOR LOCKS AND NO BREAK LIGHTS, (BUT BREAK LIGHTS DO COME ON WHEN YOU APPLY BREAKS AND THE BACK-UP LIGHTS COME ON. THE SYSTEM CAN COME AND GO ON AND OFF WHILE MOVING AND SETTING STILL. HAVE HAD SYSTEM CHECKED AND CODED, THEY CAN NOT FIND A PROBLEM EXCEPT THAT IT IS A ELECTRIC PROBLEM, HAD ALL WIRING CHECKED, CLEANED. NO,FRAYED WIRE FOUNF AND NO DEFECTIVE COUPLING. AGAIN I GET IT A WIRE THAT IS GROUNDING AND CAUSING PROBLEM. ALL THE FUSES ARE OK AND KNOW HAVE BLOWN. THE ONLY THING I KNOW IS THIS PROBLEM WAS REPORTED TO FORD BACK IN 2006 OR 2007 AND THEY HAVE NOT PUT OUT ANY RECALL ON IT AND THERE DEALERS KNOW NOTHING ABOUT WHAT TO DO BUT THEY WILL TRY AND FIND IT AT WHERE HOURLY RATE AND IT COULD BE A HOUR OR SEVERAL HOURS TO FIND PROBLEM. AS I'VE SAID THIS IS ON GOING IT CLEAR UP AND LAST FOR A WEEK UP TO SIX WEEKS AT A TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11282739November 27, 2019
ELECTRICAL SYSTEM
THE ANTI THEFT IS ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270325October 22, 2019
ELECTRICAL SYSTEM
INSTRUMENT CLUSTER FLASHES THEN GOES BLACK WHILE DRIVING. INTERIOR EXTERIOR AND GAUGE LIGHTS GO BRIGHT AND DIM AND GO OUT ALTOGETHER WHILE DRIVING. CAR DIES WHILE MOVING. BATTERIES ONLY LAST 1 YEAR FROM BEING DRAINED. NO ALTERNATOR ISSUE PER 3 DIFFERENT MECHANICS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269306October 18, 2019
POWER TRAIN
I OWN A 06 FORD FIVEHUNDRED AND AT ONLY 100,000 MILES I BEGAN EXPERIENCING REALLY HARD DOWNSHIFTING AND SOMETIMES COMPLETE SLIP FROM GEAR SLAMMING BACK INTO GEAR AFTER ROLLING FREELY FOR A WHILE HAPPENS WHEN CAR REACHES NORMAL RUNNING TEMP WAS TOLD WHOLE TRANSMISSION NEEDS TO BE REPLACED SEEMS LIKE ALMOST EVERYONE WITH THIS VEHICLE REGARDLESS OF THE YEAR HAS THIS SAME PROBLEM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268024October 11, 2019
EXTERIOR LIGHTING
DRIVER SIDE HEADLIGHT SOCKET BURNS OUT THE BULB. THE BULB HAS BEEN REPLACED THREE TIMES IN THE PAST THREE MONTHS. THE ENTIRE LIGHT SOCKET UNIT NEEDS TO BE REPLACED. THE SERVICE TECH INFORMED ME THAT WAS A PROBLEM WITH THIS MODEL VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Five Hundred