Ford Five Hundred Complaints

1,073 consumer complaints on file.

#11681667August 19, 2025
POWER TRAIN
The contact owns a 2005 Ford Five Hundred. The contact stated that while driving at various speeds, the vehicle made an abnormal knocking sound. The vehicle was taken to two independent mechanics, where the flywheel was replaced twice with used parts because the part had been discontinued. The contact stated that while her son was driving approximately 20 MPH, the vehicle stalled. The check transmission warning light, the check engine warning light, and other unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was able to restart but was undrivable. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576414March 9, 2024
ENGINE, ELECTRICAL SYSTEM
I am having problem with the reset button in my 2005 five hundred ford, the oil light stays on after oil changes, no one does not know how to reset, the reset button does not work, several mechanic told me not to worry about it , but the car can't pass the smog, it reads not ready, they told my to take a ride for about 50 miles and drive up to sixty miles per hour. . On going problem and I am running out of money, can you help, please
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11554575November 10, 2023
POWER TRAIN
It's starting not going into highway gears (5&6) just revs real high and when it does finally, it kicks really hard. Sounds and feels like it's going to drop out from under the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540215August 22, 2023
ENGINE, SUSPENSION
I have 2 very serious and dangerous issues. The 1st issue, the car will shut off while driving and without warning. I'll be cruzing down the highway and out of no where it shuts off. I then do not have breaks or power stearing. This last Winter my daughter was driving it and it shut off while she was on black ice. The car flew into the ditch and the snow was so deep it was compacted in the entire engine so it was impossible to restart the car. It was akso -37 below temperature. It took me almost a half hour to get to her and she almost froze to death. She sustained frost bite on her hands, toes, ears, and cheeks. She almost died. Issue 2, my daughter was driving and all of the sudden a loud noise and she couldn't steer. The rear control arm bracket that is part of the subframe busted causing the control arm to no longer be attached to the frame. She almost flipped the car when that happened. I looked into it and many cars this year make and model had the exact same thing happen in the exact same spot. So that tells me that it is a manufacturer defect. I had this looked at and inspected by Trusted Tires & Auto. Neither of these issues had any warning at all. So now the car sits unable to be driven. Even if it was fixed I won't drive it or let my daughter drive it and I can't sell it because I don't want anyone else to drive it period. It is a death trap literally and puts everyone's life in dangernear that come near the car. It needs to be recalled immediately. This is absolutely unacceptable and Ford needs to stand behind their product. If this car continues to stay on the roads Many people will die because of all the defects on the car.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11531091July 8, 2023
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
The engine keep going into limp mode. The car stalls out while at lights an stop signs, power steering goes out on highway an other roads making it impossible to steer or steer out of others ways, limp mode causes car to not be able to keep up with traffic on highway and other roads. Engine jerks forward an shifts irractically an shifts an downshifts hard.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531095July 8, 2023
SUSPENSION, STEERING, WHEELS
While driving the front end suspension slips, bounces up and down very harshly, tires slip, squeak, and slide in an hard to control way, sometimes into oncoming traffic when in slightly damp conditions an on roads with any amount of bumps, to the point that I need to drive extremely slow to avoid danger which in turn puts my and my passengers and my kids in danger by goin to slow in regards to the traffic around us. When hitting relatively small bumps the suspension bounces the car severely up and down and across the road into harms way.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481505August 27, 2022
UNKNOWN OR OTHER
I would be driving on highway my wrench light would come on and my car would come to a crawl I always have kids in my car I could easily be rear ended and maybe hurt or killed I have to find a place to pull off where people behind me is cussing me out they think I did on purpose I then shut car off and tirn back on. Then ok till happens again there should be a recall I am on a fixed income and can't afford another car please help
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481067August 24, 2022
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2006 Ford Five Hundred. The contact stated while driving 50 MPH, the instrument cluster lights turned became inoperable. The contact veered to the side of the road. The contact stated that the instrument cluster lights illuminated after 5 minutes. The contact was able to continue driving. However, the failure reoccurred on four different occasions. The vehicle was taken to a local Pep Boys who was unable to duplicate the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11473538July 12, 2022
POWER TRAIN
While waiting at the light in traffic, my car all of a sudden Accelerated, and decelerates, I have to push hard on the breaks in order for it to not slam into the cars infront of me.. this is really dangerous, from what I have been reading this is a wide spread issue that ford has ignored for years..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11470129June 20, 2022
VEHICLE SPEED CONTROL
while we are in idel for a period of time the car wants to surge forward without pushing on the gas. it wants to rev withough the has pedal being pushed. It does it at red lights, stop signs, and if Im in a drive through.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448311January 21, 2022
UNKNOWN OR OTHER
Door latch freezes i cold weather causing the door not to latch closed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11444954December 25, 2021
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
when I’m The vehicle and the temperature reaches middle temp ,the car starts to beep and all the dashboard lights go completely out and the head lights and tail lights be blinking as if they are about to go off . Even when I have the heater or a/c on they turns off and I’m a afraid that if or when I’m on the highway all my lights will just stop working on the middle of the highway at night and no one will be able to see me. And that will cause a big wreck and maybe kill myself or worst someone else. I have looked my car up to see if it has a recall but none are given. I’m afraid for the safety of my fellow drivers on the at night . And I don’t know what to do about this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11441008November 19, 2021
ENGINE, POWER TRAIN
The contact owns a 2006 Ford Five Hundred. The contact stated while driving at various speeds, the transmission was slipping. The contact restarted the vehicle and the transmission worked as designed for a while. While traveling up a hill or at a stop light, the vehicle would drift backwards. The contact had to let the vehicle drift to shift into gear. At times the vehicle failed to shift. The engine and wrench warning lights were illuminated. The contact was concerned about driving the vehicle. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11429929August 20, 2021
ENGINE
The contact owns a 2005 Ford Five Hundred. The contact stated that while starting the vehicle, the "fail safe engine mode" and check engine warning lights were illuminated. The vehicle stalled with the RPM revved up. The vehicle jerked while driving at an undisclosed speed. The dealer nor the independent mechanic was not made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to a dealer for assistance. The failure mileage was approximately 122,832.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11396488February 16, 2021
ELECTRICAL SYSTEM, ENGINE, VEHICLE SPEED CONTROL
I WAS AT RED LIGHT PERSON CROSSING ROAD I WAS I. DRIVE FOOT ON BRAKE, RPMS SHOT UP ENGINE REEVES CAT LUNGED FORWARD I PRESSED HARDER IN BRAKE ALMOST HIT PERSON. AT THE TIME NO WARNING LIGHTS. THEN AT PHARMACY DRIVE THRU W CAR I. FROM AND I. BACK OF ME CAR DID SAME THING. I HAD TO PRESS BRAKE HARD TO PREVENT MOVING HITTING CAR IN FROM OF ME. I WAS IN DRIVE BUT FOOT ON BRAKE! NO WARNING LIGHTS AT TIME. HAD THROTTLE BODY REPLACED STILL HAD SIMILAR PROBLEMS PROGRESSING LITTLE DID I KNOW WHEN THROTTLE BODY IS REPLACED HAS TO BE REPROGRAMMED BY FORD! SPENT SO MUCH MONEY AND TIME TRYING TO FIGURE OUT PROBLEM. THIS IS A FLAW W FORD 500 2005 THROTTLE BODY MANY COMPLAINTS AND TEST DOES NEVER ISSUES RECALL, UNSAFE. I COULD HAVE KILLED SOMEONE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11395906February 12, 2021
ENGINE, FUEL/PROPULSION SYSTEM
AFTER DRIVING HALF-HOUR IN HIGH-WAY SOUTHWARD ON I-45 IN THE MORNING. THE CAR CANNOT BE ACCELERATE AT AROUND 40MPH WHEN I RAMP UP TO 288, AND THE AUTO-LOCK LIGHT TURNED RED. SECONDS LATER, IT RECOVERED BACK. 2 MINUTES LATER, IT HAPPENED AGAIN . AND AGAIN . SO I PARKED IT . ~8-HOURS LATER, I STARTED IT AND THE AUTO-LOCK LIGHT RED AGAIN. SECONDS LATER, THE ENGINE STOPPED WHEN I BACK THE CAR. I STEPPED ON GAS-PEDAL WHEN I TRIED 3RD TIME, AND THE CAR MOVED AND THE AUTO-LOCK LIGHT KEPT RED. 10-MINUTS LATER, WHEN I DRIVE ON 288-SOUTH AT ~60MPH, BOTH OF THE REPAIR LIGHT AND ENGINE LIGHT TURNED YELLOW AND THE AUTO-LOCK LIGHT OFF, SECONDS LATER, THE REPAIR LIGHT OFF. THE ENGINE LIGHT KEPT ON. SO I GET DOWN THE HIGHWAY, CANNOT ACCELERATE CAR WITH GAS-PEDAL ON AND CANNOT TURN STERRING WHEEL, THE CAR SLOW DOWN AND STOPPED BY ITSELF. 5-MINUTES LATER, I STARTED IT AGAIN WITH ENGINE LIGHT ON WITH YELLOW, THE CAR MOVED AND 10 MINUTES LATER, I PARKED IT HOME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11388625January 18, 2021
ELECTRICAL SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
I WAS ON MY WAY HOME COMING DOWN FARROW RD. AND MY CAR STALLED OUT, SO I SLOWLY PULLED IN THE MEDIAN TURN CAR OFF AND BACK ON. WHEN I GOT READY TO PULL OUT OF THE MEDIAN THE CAR WOULDN'T GO NO FASTER THAN 5 MILES AND HOUR. SO I HAD MY FRIEND HELP ME PULL IT OUT OF THE ROAD AND TAKE ME HOME AND TOW MY CAR TO THE HOUSE. WHEN I GOT IT HOME THERE WASN'T ANY ACCELERATION, RPMS WONT MOVE AT ALL, CAR HAS POWER AND CRANKS BUT WHEN I PUT IT IN DRIVE IT WON'T GO ANYWHERE. IT STALLS AND CUTS OFF, EVEN IN NEUTRAL NO ACCELERATION. EVERYTHING LIGHTS UP AND CUTS ON BUT NO ACCELERATION. FROM MY PHOTOS BELOW YOU WILL SEE I HAVE REPLACED ALTERNATOR, THROTTLEBODY, THE RED AND BLACK WIRING ON THE BACK OF THE INTAKE I'VE CHECKED ALL MY HOSES THERE WAS NO SPLITS NO CUTS NO VACUUM LEAK AND EVERY TIME I GET A READING ON IT IT GIVES ME A DIFFERENT CODE PLEASE READ AND REPLY IF THIS IS A RECALL I NEED MY CAR FIXED IMMEDIATELY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11386131January 2, 2021
POWER TRAIN
VEHICLE STOPS AND STARTS WITH A JERK. JUMPING CAUSING SLOW DOWN EVEN WHILE ON THE INTERSTATE. FORD IS AWARE OF THIS PROBLEM AND HAS DONE TO FIX IT. SEEMS LIKE EVERY FORD HAS THIS PROBLEM AT SOME POINT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11366459October 26, 2020
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN CAME UPON SOME K FORMATION AS TO A RECALL FORD PUT IN PLACE STATING IMPROPER CALIBRATION OF PCM AND TCM CAUSE UNNECESSARY INTERACTION I THE ELECTRICAL SYSTEM AND MALFUNCTION OF THE VEHICLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365936October 23, 2020
POWER TRAIN, VEHICLE SPEED CONTROL
TRANSMISSION HAS VERY HARD AND DELAYED UPSHIFT AND DOWNSHIFT MAKING IT DIFFICULT TO CONTROL SPEED WHEN ACCELERATING AND DECELERATING. RPM GETS STUCK AROUND 3000 AT LOWER SPEEDS AND UPON ENGAGING INTO GEAR HAS MADE MY TIRES SQUAWK WITH A SUDDEN LUNGE IN SPEED AND SAME PROBLEM WHEN TRYING TO STOP, THE CAR LUNGES FORWARD. IT ACTS AS THOUGH IT IS IN NEUTRAL BUT THEN WHEN IT ENGAGES INTO GEAR SUDDEN CHANGES IN SPEED OCCUR CAUSING RAPID ACCELERATION OR DECELERATION. THE PROBLEM GETS WORSE AFTER THE CAR IS UP TO NORMAL OPERATING TEMPERATURE. IT DOESN'T OCCUR AS OFTEN AT COLDER OPERATING TEMPERATURE. THIS PROBLEM MAKES IT DIFFICULT TO GET BACK UP TO SAFE HIGHWAY SPEEDS AFTER HAVING TO STOP FOR TRAFFIC OR RED LIGHTS AS WELL AS HARD TO GET UP TO SPEED TO SAFELY MERGE INTO TRAFFIC FROM AN ON RAMP. AS FAR AS "WHEN" THIS HAPPENED IT IS EVERY DAY AS I DRIVE DAILY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Five Hundred