Ford · Model Report
Showing safety data for the 1985 model year only.
METAL BURRS AND SHARP EDGES ON FUEL RAILS MAY HAVE DAMAGED ADJACENT O-RING SEALS DURING ASSEMBLY. THE DEFECT COULD CAUSE FUEL LEAKAGE WHEN ENGINE IS OPERATING.
1985 FORD F-150 HEADLIGHTS FAILED AND VEHICLE SHUT OFF. *KB WHEN THE VEHICLE SHUT OFF, THE CONSUMER DRIFTED OFF TO THE RIGHT SIDE OF THE ROADWAY AND STRUCK A GUARD RAIL. *JB
THE VEHICLE EXPERIENCED TIRE TREAD SEPARATION ON 2 DIFFERENT OCCASIONS. WHILE DRIVING ON 04/10/03 THE PASSENGER REAR TIRE EXPERIENCED PARTIAL TREAD SEPARATION WHICH RESULTED IN A BLOW OUT. WHILE DRIVING 70 MPH ON 04/12/03 THE DRIVER'S REAR TIRE TREAD COMPLETELY SEPARATED AND ALMOST CAUSED A DANGEROUS COLLISION. TIRE INFO: DAYTON, RADIAL STAG ST 31X10.50R15LT, DOT-V060U6A118, NOT ORIGINAL, 90% OF TREAD INTACT, 2K-3K MILES ON TIRES AT TIME OF FAILURE. *NLM.....*AK
No injuries · No fire · No crash
THIS CAUSE'S LOUD POPING AND CRACKING NOISE WHEN TURNING AND EXCESSIVE TIRE WEAR ON THE OUT SIDE OF TIRE. FORD REP. TOLD ME THAT THERE WAS NOT A RECALL ON THIS AND THAT EVEN IF THERE WAS DUE TO AGE OF THE TRUCK THAT THEY WOULD NOT PAY TOWARDS FIXING IT. I POINTED OUT THAT THIS IS A SAFETY ISSUE, BUT THIS DIDN'T MAKE ANY DIFFERANCE, JUST TOUGH LUCK ON MY PART. THEY TOLD ME HAVE THE CROSS MEMBER WELDED TO THE FRAME. THIS HAD ALREADY BEEN DONE ONCE SOMETIME IN THE PAST, I DO NOT KNOW WHEN. BUT IT DIDN'T HOLD . SO I AM AT A LOSE AT WHAT DO NOW OR WHERE TO TURN FOR HELP WITH THIS. *AK
No injuries · No fire · No crash
CONSUMER STATED THAT HE HAD TO REPLACE INNER AND OUTER WHEEL BEARING, AND GREASE SEALS AFTER THEY BURNT UP AND SMOKED SEVERAL TIMES DURING A ROAD TRIP. *YD
No injuries · No fire · No crash
IGNITION CONTROL MODULE FAILED INTERMITTENTLY NUMEROUS TIMES BEFORE THE PROBLEM COULD BE IDENTIFIED. ENGINE STALL WAS INSTANTANEOUS AND WITHOUT WARNING; DANGEROUS TRAFFIC SITUATIONS RESULTED. HOT AMBIENT TEMPERATURE AGGRAVATED THE PROBLEM, BUT THE HEAT FACTOR WAS NOT KNOWN UNTIL THE PROBLEM WAS FINALLY ISOLATED. TWO FORD DEALERS WERE ABSOLUTELY NO HELP IN DIAGNOSING THE PROBLEM.
No injuries · No fire · No crash