BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
BMW of North America, LLC (BMW) is recalling certain 2015 X1 sDrive28i, X1 xDrive28i, and X1 xDrive35i vehicles. These vehicles are equipped with air bag inflators assembled as part of the driver frontal air bag modules, used as original equipment or replacement equipment, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
BMW of North America, LLC (BMW) is recalling certain model year 2008-2013 128i and 135i coupes and convertibles and 1 Series M coupes, 2006-2011 325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi, 335i, 335xi, 335i xDrive Sedans, 2009-2011 335d sedans, 2006-2012 325xiT, 328i and 328xi sports wagons, 2007-2013 328i, 328xi, 328i xDrive, 335i, 335xi, 335i xDrive, 335is and M3 Coupes and Convertibles, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i SAVs, 2007-2010 X3 xDrive30i SAVs, 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M SAVs, 2009-2013 BMW X5 xDrive35d SAVs, 2008-2014 X6 xDrive35i, X6 xDrive50i, and X6 M SACs, 2010-2011 BMW X6 xDrive50i SACs and 2008-2011 M3 Sedan vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
The contact owns a 2015 BMW X1. The contact stated that while starting the vehicle, the vehicle hesitated while starting. Additionally, while stopped in traffic, the vehicle was shaking abnormally. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the camshaft position sensor needed to be replaced. The vehicle was not yet repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 97,000.
No injuries · No fire · No crash
Complete electrical failure while driving on the Highway. I barely was able to get over without causing an accident. The car without notice went dead and no power. I couldn't turn the steering wheel. Lots of warning lights started flashing then completely dead.
No injuries · No fire · No crash
I had to replace the Oil Fliter housing with oil cooler because it was made out of plastic and caused an oil and antifreeze. The repair man told me that engine part were made out of plastic and tend to fail over time.
No injuries · No fire · No crash
The contact owns a 2015 BMW X1. The contact stated that while the vehicle was at an independent mechanic for maintenance, the contact was informed that the water pump had failed. The vehicle was not repaired. The contact stated that prior to the visit, the vehicle was taken to the dealer; however, the cause of the failure was not found. The failure persisted. On a separate occasion, while the vehicle was parked, the front passenger's side door failed to open as intended from the outside, and the front passenger's side door only opened from the inside of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer and an independent mechanic. The vehicle was not repaired due to the cost. The contact stated that on a separate occasion, the front passenger’s side rear window failed to function as intended. There was an abnormal sound while rolling up the window, and the window failed to roll up. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired, and the failure persisted. The contact stated that prior to the other failures, the sliding cover on the sunroof failed to function as intended. The sliding cover was stuck, and the contact was unable to move the sliding cover. The contact related the failure to NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). However, the VIN was not included. The vehicle was not repaired for the failure. Most recently, when the vehicle was restarted, the message "Passenger Restraint System Malfunction" was displayed. The contact used a personal scanner to clear the message. The vehicle was not repaired after the most recent failure. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.
No injuries · No fire · No crash
The contact owned a 2015 BMW X1. The contact stated that upon starting the vehicle, she noticed there was smoke emerging from underneath the hood, and it caught fire. The contact was able to exit the vehicle safely. The fire department was able to extinguish the fire. The service warning light was illuminated prior to the failure. There were no reported injuries, air bag deployments, or crashes. A police report was filed. The vehicle was towed to her residence. The local dealer was contacted, but there was no assistance provided. The vehicle was not diagnosed or repaired. The vehicle was deemed a total loss. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 95,800.