Alfa Romeo Stelvio Complaints

215 consumer complaints on file.

#11705307December 16, 2025
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal, and the check engine warning light would illuminate. The vehicle was taken to a dealer, where it was diagnosed with an EVAP system leak; however, the origin of the leak could not be determined. The contact stated that the vehicle later failed to start, and both the check engine and auto Start/Stop warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with a defective fuel pump, and the fuel pump was replaced; however, the failure recurred a month later. The contact stated that the vehicle failed to start after multiple attempts. The contact left the vehicle and returned to the vehicle the following day. The contact managed to drive the vehicle to the residence. The vehicle was then taken back to the dealer, where an unknown repair was performed; however, the failure recurred two days later. The contact later received a recall notice for NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was notified of the failure but refused to acknowledge the recall. The manufacturer had yet to be notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704692December 12, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704009December 9, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, parts to do the recall repair were not yet available. The contact stated that the vehicle failed an inspection and would not pass due to the open recall and the parts not being available to repair the vehicle. The local dealer was contacted, and the dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702929December 4, 2025
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle failed to drive forward. The vehicle was towed to the dealer, where the vehicle was diagnosed with a failed oil solenoid and battery failure. The contact was informed that the oil solenoid and battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred a month later. The vehicle was towed back to the dealer. The contact was informed that the engine bolt needed to be cleaned, and the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact researched NHTSA Campaign Number: 25V586000 (Fuel system, Gasoline); however, the parts were unavailable for the recall repair. The dealer was made aware of the recall. In addition, the contact was without a vehicle because of the unrepaired recall. The contact stated that the dealer never mentioned the unrepaired recall and attempted to perform a temporary repair. The contact stated that whenever the check engine warning light illuminated on Alfa Romeo vehicles, the vehicle remained undrivable until the vehicle was repaired. The vehicle was undrivable and had been undriveable since June 2024. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 62,000. The VIN was unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702468December 2, 2025
FUEL/PROPULSION SYSTEM
While driving at approximately 40 mph, my Alfa Romeo Stelvio suddenly lost all power without warning. The vehicle went from operating normally to immediately illuminating multiple warning lights on the dashboard. I was unable to accelerate and nearly struck by another vehicle due to the sudden loss of power. I had to coast to the side of the road and have the vehicle towed to a repair shop. Upon inspection, it was determined that the fuel pump had failed. I was informed by the technicians that this is a common issue in Alfa Romeo’s and that the previous two model years have already had fuel pump–related recalls. This sudden failure created a serious safety hazard and appears to be part of an ongoing pattern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702549December 2, 2025
EQUIPMENT
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at 50 MPH, the contact became aware of water entering the cabin of the vehicle from under the glove compartment on the passenger’s side. A dealer was contacted. The vehicle was taken to dealer where it was diagnosed and determined the electrical system needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V205000 (EQUIPMENT); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 34,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701333November 24, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that several dealers were contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700765November 21, 2025
ELECTRICAL SYSTEM, ENGINE
My 2018 Alfa Romeo Stelvio experienced a complete electrical failure and will not start at all. The vehicle suddenly lost all functionality and remains fully inoperable. The dealership has had the vehicle for an extended period and has been unable to diagnose or repair the defect. This appears to be related to known electrical issues in 2018 Stelvio models, including BCM (Body Control Module) failures, wiring faults, and fuel system defects reported in recalls and TSBs. A no-start electrical failure is a serious safety concern because similar defects in this model have been linked to unexpected engine shut-offs. The vehicle has been out of service for over 30 days. This is a major safety and reliability issue. I am requesting that NHTSA review this defect, because the manufacturer has not provided a resolution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700554November 20, 2025
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while his daughter was driving approximately 60-75 MPH, the vehicle shuddered and lost motive power. The driver was able to pull over to the side of the road. The check engine warning light and other unknown warning lights were illuminated. The vehicle failed to restart and was towed to the residence. The contact stated that the vehicle was able to be restarted the following day, but the check engine warning light remained illuminated. The vehicle was taken to an Auto Parts Store, where it was scanned, and a DTC for low fuel volume was retrieved. The contact received notification of NHTSA Campaign Number: 25V586000( Fuel System, Gasoline), which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699848November 17, 2025
FUEL/PROPULSION SYSTEM
Recall Issue Sep 09,2025 Manufacturer Recall Number93C NHTSA Recall Number25V-586 Recall StatusRecall Incomplete, remedy not yet available I would like to submit a compliant that it has been two months since the recall was issue and there still is no formal remedy provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698764November 11, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
I received a manufacturer recall notice (Recall 93C / NHTSA 25V-586) for my 2021 Alfa Romeo Giulia concerning a defective rear fuel line quick connector that may leak fuel and cause an engine compartment fire. I contacted Alfa Romeo of Brandon (FL) several times to schedule an inspection and request a temporary vehicle as recommended by FCA. My service advisor, Lenny Patram, confirmed that the remedy is not yet available and advised me to wait for further notice. Despite expressing safety concerns, I was told that no loaner or temporary vehicle could be provided. This situation puts my safety and the safety of others at risk. The recall notice specifically warns that a fuel leak could lead to a fire, yet I have been advised to continue parking the vehicle outside and avoid driving it if possible. I rely on this vehicle for daily transportation and have not been offered any safe alternative or clear timeframe for repair. In addition to the recall, my check engine light has been on for several weeks, and the “A!” warning light appears intermittently. These indicators began appearing after I received the recall notice and may be related to the same underlying defect. The dealer has not inspected the vehicle because parts are unavailable. The issue has not been reviewed by the manufacturer, insurance, or any third party. The vehicle is currently at my residence and available for inspection upon request. Warning lights prior to failure: Yes — check engine light and “A!” warning. Reproduced/confirmed by dealer: No — recall acknowledged but not inspected. Component available for inspection: Yes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698417November 9, 2025
ELECTRICAL SYSTEM
My car stopped and would not turn back on while in the middle lane of a busy highway. We were stopped on the highway >20min until police arrived to block the lanes so we could safely exit the vehicle and a tow truck could safely retrieve it. The ground strap underneath the vehicle that grounds the main engine harness was broken. As a result the electrical short resulted in burning/melting of several spots on the harness. There was no warning ahead of time and I’ve learned that this is a known issue. We are very lucky that this did not lead to a crash, injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697624November 5, 2025
ENGINE, FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle was unintendedly stopping and starting. While driving at 15 MPH, the vehicle shut off. The vehicle was jump-started. The driver was able to continue driving. The contact had the battery replaced at an independent mechanic. The vehicle was taken to the local dealer, who confirmed that the battery was not operating properly. The ABW warning light was illuminated. While pulling into the fuel station, the vehicle shut off. The vehicle was jump-started, and the contact drove to the local dealer, but the vehicle was not diagnosed or repaired. The contact became aware of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The manufacturer was not contacted. The failure mileage was approximately 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697230November 3, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while the vehicle was parked and shut off, the contact attempted to start the vehicle, but the vehicle failed to start. The contact stated that the vehicle lost motive power, and the fuel warning light was illuminated. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to complete the recall repair was not yet available. A local independent mechanic arrived at the residence to inspect the vehicle, but the vehicle was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 41,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697248November 3, 2025
ELECTRICAL SYSTEM, POWER TRAIN, UNKNOWN OR OTHER
The gear shifter broke. The button on the back that you compress in order to trigger a button inside of the shifter, broke off and then the button inside got stuck. I was not able to shift gears and even though there was no other issue with the vehicle, I was stuck in a parking lot blocking other people's ability to move around me. It creates a safety hazard by not being able to shift gears to move the vehicle out of harm's way or even to be able to be towed in a safe manner. The tow truck driver had to climb under my vehicle and find a way to put the vehicle into neutral because the gear shifter would not engage. No to the other questions. I sat for six hours waiting for a tow truck to come because the first one that was dispatched was not able to help due to the specific circumstances. From reading other online forums, this does seem to be a recurring issue with Alfa Romeo's.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696504October 30, 2025
LANE DEPARTURE: WARNING, LANE DEPARTURE: ASSIST, LANE DEPARTURE: BLIND SPOT DETECTION
My Alfa Romeo Stelvio 2020 on Oct 29,2025 stop functioning all the ADAS system as well as the sunroof. Because of this a had a small accident with a gate as it did not advised me. I read in a few websites that I am not the only person having this same issue. This is a very serious issue that Alfa Romeo manufacturing should fix immediately before it can become a tragic event.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11696144October 28, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Alfa Romeo Stelvio. The contact stated that while driving at various speeds, the vehicle occasionally stalled. The contact stated that the message “ Throttle System Service Required” was displayed. The vehicle was taken to a local dealer, who diagnosed the vehicle and determined that the fuel pump and fuel pump module needed to be replaced. The vehicle was not repaired. The contact had researched online and related the failure to NHTSA Campaign Number: 21V878000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was not informed of the failure. The failure mileage was approximately 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696095October 28, 2025
BACK OVER PREVENTION
The contact owns a 2021 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V667000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The contact stated that the dealer stated that normal recalls typically took a year for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695302October 23, 2025
FUEL SYSTEM, GASOLINE, AIR BAGS, SEAT BELTS
The contact owns a 2018 Alfa Romeo Stelvio. The contact received notifications of NHTSA Campaign Numbers: 24V510000 (AIR BAGS, SEAT BELTS) and 25V586000 (FUEL SYSTEM, GASOLINE). However, the part to do the recall repair was not yet available. The contact stated that while her daughter was driving 55 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle decelerated from 50 MPH to 40 MPH. An unknown warning light was illuminated. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695015October 22, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle intermittently failed to exceed 30 MPH while driving and depressing the accelerator pedal all the way to the floorboard. The message that the throttle and the ignition were inoperable was displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump and the fuel pump sensor had failed. The dealer related the failure to NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Alfa Romeo Stelvio