Ford · Model Report
Showing safety data for the 1995 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
THE STEERING COLUMN AND ALL THE PARTS ASSOCIATED WITH THE STEERING OF THE VEHICLE WERE AFFECTED WHEN THE BOLTS THAT HOLD THE CLAMPS THAT SECURE THE BUSHINGS TO THE STEERING COLUMN BEGAN TO LOOSEN. I EXAMINED THE AREA CAREFULLY AND NOTICED THAT BECAUSE THE BOLTS LOOSENED, THE CLAMPS WERE GIVEN TOO MUCH PLAY. WITHIN A SHORT WHILE, A MONTH OR TWO, THE ENTIRE STEERING COLUMN AND THE SHIFTER WERE COMPLETELY SECURED BY ONE BROKEN CLAMP THAT HELD ITS PLACE BECAUSE OF THE BUSHINGS AND A LOOSE BOLT. THE OTHER CLAMP WAS ALSO BROKEN BUT WAS LAYING ON THE FLOOR BOARD. IT WASN'T AN EXPENSIVE FIX. I CUSTOMIZED A METAL CLAMP FOR EACH OF THE TWO PLACES THE WENT. THEY ARE THE SAME CLAMPS THE ELECTRICIANS USE TO SECURE CABLES AND WIRES TO THE WALLS AND CEILINGS. I USED THE ONES MADE FROM BRONZE. THEY ARE MORE PLIABLE TO SHAPE FOR AN ALMOST PERFECT FIT. WITH A LITTLE GREASE ABOVE AND BELOW THE BUSHINGS AND ALSO SOME WHERE THE NOW BRONZE CLAMPS HOLD THE BUSHINGS, I BELIEVE THAT THE STEERING COLUMN IS AS SAFE AS CAN BE. ALSO, THE PLASTIC THAT HOLDS THE CABLE THAT IS USED TO ADJUST THE SHIFT INDICATOR NEEDS TO BE MADE OF A DIFFERENT MATERIAL. I'LL GET TO THAT SOON.
No injuries · No fire · No crash
I GOT IN MY CAR A BATTERY LESS THAN 2 WEEKS OLD WAS ALMOST DEAD NOTHING WAS PLUGGED IN OR ON I DROVE GOT ON THE FREEWAY ABOUT 20 MIN ON FREEWAY CAR STOPS WON'T MOVE MAKES REV NOISE EVENTUALLY STARTS LONG ENOUGH TO STOP AGAIN AT BOTTOM OF FREEWAY EXIT STARTS AGAIN GET IN INTO GAS STATION I SIT IN GAS STATION FOR ABOUT 12 HOURS ADD 5 QUARTS OF TRANSMISSION FLUID EVENTUALLY CAR WILL LET ME DRIVE ABOUT TWO BLOCKS BUT COME TO FIND OUT I WAS DRIVING WELL ON FIRE RACE TO GET MY DOG AND I OUT CAR CATCHES COMPLETELY ON FIRE FIRE MAN SAYS IT ELECTRIC UNDER HOOD NO PREVIOUS PROBLEMS OTHER THAN THE BATTERY AND THE OD OFF LIGHT COMING ON AND OFF I HAD THE CAR ABOUT A MONTH POLICE REPORT NUMBER1702207 OAKLAND CA POLICE DEPARTMENT
INTERMITTENT STARTING PROBLEMS AND STALLS WHILE DRIVING
No injuries · No fire · No crash
95 FORD EXPLORER PARKED IN CARPORT WITH ENGINE SHUT OFF FOR 5 MIN WHILE CARRIED GROCERIES UP STAIRS - I HAD LEFT DOG IN CRATE TIL FINISHED UNLOADING BUT WHEN I CAME DOWN NOTICED ELECTRICAL SMELL, GOT OUT LOOKED AROUND CAR BUT DID NOT NOTICE ANY BURNING, GOT DOG OUT AND RETURNED IN THREE MINUTES TO FIND KEY NO LONGER UNLOCKED DOOR AND COULD NOT SEE THROUGH WINDOWS - WHEN DOOR WAS OPENED SMOKE BELLOWED OUT, INTERIOR WAS COVERED WITH BLACK SOOT, A HOLE BIGGER THAN A BASKETBALL WAS BURNT OUT OF SEAT AND BACK OF DRIVER'S SEAT WAS PARCHED - HAD I NOT HAD THE WINDOWS COMPLETELY UP IT MOST LIKELY WOULD HAVE TO CONTINUED TO BURN. *TR
TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THERE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.
No injuries · No fire · No crash