Ford · Model Report
Safety data across 24 model years.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Ford Motor Company (Ford) is recalling certain 2026 Explorer and Mustang vehicles. The engine piston circlips may have been incorrectly installed during manufacturing, which can result in piston failure and engine damage, leading to a loss of drive power.
Ford Motor Company (Ford) is recalling certain 2026 Lincoln Aviator and Explorer vehicles. The heating, ventilation and air-conditioning (HVAC) system may fail, which can cause the defrosting and defogging system to become inoperative.
The panoramic sunshade on our 2023 Ford Explorer bunches up and dips down into the rear passenger compartment when being retracted, obstructing rear visibility when using the rear view mirror or looking over your shoulder.
No injuries · No fire · No crash
NHTSA COMPLAINT: VIN [XXX]: Transmission cooler (Part 7869) ruptured, mixing fluid/coolant into corrosive glycol-acid in violation of SSM 52917. Contamination dissolved wiring insulation and delaminated clutch plates, causing systemic short circuits and CAN-bus load-shedding. Boiling fluid released toxic glycol/hydrocarbon vapors through HVAC ducts into the cabin without notice, creating an inhalation hazard. Vehicle available for inspection at South Bay Ford (BAR #XXX; captive 93 days).RISK: On XXX short circuits caused complete power steering assist dropout mid-transit. Steering locked during a turn, causing a crash into gate posts, endangering my minor children inside. Cabin chemical vapor inhalation caused respiratory tract irritation, dizziness, and headaches. Open recall hazards remain for visibility loss (Recall 26S14) and rollaway (Recall 26S48 parts backordered to 2027).CONFIRMATION: Contamination, a -1,212-mile odometer fraud discrepancy, and bricked electrical starting systems confirmed by dealer records XXX. Admitted unauthorized repairs to mask trouble codes and evade SSM 52917 confirmed in writing by Service Director [XXX] XXX, violating CA Bus & Prof Code 9884.9.HISTORY: Tracked under Ford RAV buyback #XXX, Corporate Escalation #[XXX], and CA Bureau of Automotive Repair Investigator [XXX] (Case #XXX). Total statutory loss is $54,628.75.SYMPTOMS: Transmission drops began XXX (42,319 miles). Dealer cleared codes and coerced 500 extra miles. XXX alerts included "Powertrain Malfunction" loops. Telematics registered false "Vehicle is On" loops. On XXX, dealer blocked diagnostics via a manufactured battery charge demand exactly 24 hours before federal Recall 26S48 launched. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I am reporting recurring engine misfires involving my 2025 Ford Explorer Platinum equipped with the 2.3L EcoBoost engine. The vehicle currently has approximately 15,700 miles. The first incident occurred approximately five months ago. The check-engine warning appeared and the vehicle was diagnosed by an authorized Ford dealership with DTC P0303, indicating a cylinder 3 misfire. The cylinder 3 spark plug was replaced. A second misfire subsequently occurred at approximately 15,700 miles. The vehicle again exhibited an engine misfire/check-engine warning and was transported through Ford Roadside Assistance for service. An authorized Ford dealership diagnosed DTC P0301, indicating a cylinder 1 misfire. I was advised that the cylinder 1 spark plug was physically damaged and that a portion/cap of the plug had broken off and was not present. I am concerned because this represents two spark-plug-related misfires involving two different cylinders of the same engine within approximately five months and at relatively low mileage. Ford has issued technical service information addressing P0301-P0304 misfires on certain 2025 Explorer vehicles equipped with the 2.3L EcoBoost engine. I am not claiming that this establishes the cause of my vehicle's failures; I am reporting the recurring condition so NHTSA can document it and evaluate it alongside any similar reports. Both incidents were diagnosed by authorized Ford dealerships. Repair documentation and manufacturer/dealership correspondence concerning the incidents have been retained and can be provided if requested. The vehicle/component may be available for further inspection if requested, subject to its current repair status.
No injuries · No fire · No crash
While operating the vehicle, a loud clunk occurred, followed by a grinding noise. I stopped the vehicle immediately. Upon exiting, I observed the rear driver‑side tire positioned at an abnormal angle. Inspection underneath the vehicle revealed a fractured rear control arm. This failure is consistent with recall 23S55, which applies to Ford Explorers manufactured between 6/25/21 and 7/6/22. My vehicle’s build date is July 2022, which falls within the affected production window. The damage is clearly consequential to the control arm failure.
No injuries · No fire · No crash
I had my car in drive in a parking spot. I was ready to go, put the car in drive, DID NOT MOVE but needed to put it in park fast to assist to a child in the back seat. I put it in park pretty fast. Took my seatbelt off and assisted child. It must have not engaged. Car rolled into my office metal mailbox. I 100% put it in park. I took my seatbelt off after so I seen it. It was fast with the gear shift though. Should this have been an issue? I feel like if it was any other car you with a manual gear shifter , not electrical, it’s fine. I feel this was not my fault at all and was a malfunction of the car. The car did not automatically stop either. It hit the mailbox at like 3-4mph. I have never been in an accident of my fault in 10 years of driving. I’ve never made a crazy mistake like that. It should’ve never happened. I drive all types of cars/ and trucks. This is also a lease and I’m SO PISSED. Especially because my kids were in the car. Luckily no one was hurt and no property damage. Just the car.