Ford · Model Report
Showing safety data for the 1993 model year only.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.
IGNITION SWITCH TURNS WITHOUT A KEY AND THEN IT IS HARD TO INSERT THE KEY. ENGINE STALLED POSSIBLY BECAUSE OF THE SWITCH WHILE WAITING FOR TRAFFIC LIGHT TO CHANGE TO GREEN.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1993 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE BRAKE PEDAL WAS DEPRESSED AND WENT TO THE FLOORBOARD WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ABS MODULE FAILED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE REPLACEMENT PART WAS UNAVAILABLE. THE CONTACT WAS UNABLE TO REACH THE MANUFACTURER FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000. *BF *AS
THE ABS MODULE FAILED WITHOUT WARNING WHILE DRIVING STRAIGHT ON A CITY STREET AT ABOUT 20 MPH.
MICHELIN LTX M/S XL P235/75R-15 ON 93 EXPLORER XL. TIRES ARE 5 YRS OLD WITH LESS THAN 5000 MILES. SERIES OF SIDEWALL CRACKS ABOUT 8" LONG APPEARED IN FRONT RIGHT TIRE, APPROX 5/8" FROM RIM, WITH THE LONGEST CRACK ABOUT 4" LONG AND 0.11" DEEP. NO FAILURE YET, AND THE AMERICAS TIRE DEALER SAYS THE CRACKS ARE NOT A PROBLEM, BUT THE NUMBER OF COMPLAINTS OF SIDEWALL CRACKING AND BLOWOUTS IN MICHELIN TIRES CONCERNS US. *TR
No injuries · No fire · No crash
I WAS PULLING INTO MY CONDO'S PARKING GARAGE WHEN DRIVER IN CAR BEHIND ME ALERTED ME THAT MY TRUCK WAS ON FIRE. I STOPPED IMMEDIATELY AND NOTICED SMOKE AND A BURNING SMELL INSIDE OF THE VEHICLE AND MY FEET GOT REALLY HOT. EXITED VEHICLE AND NOTICED FIRE DRIPPING FROM UNDERNEATH VEHICLE AND BLACK SMOKE AND FIRE FROM UNDER THE HOOD. IMMEDIATELY CALLED 911 TO REPORT FIRE, AS THE FIRE UNIT WAS ON ITS WAY THE VEHICLE HAD TWO OR THREE EXPLOSIONS UNDER THE HOOD AND THE HORN CAME ON. THE ENTIRE VEHICLE WAS ENGULFED IN FLAMES. IT WAS A TOTAL LOSS. THE 22 STORY CONDOMINIUM FIRE ALARMS WENT OFF, ALL THE ELEVATORS STOPPED WORKING AND THE FIRE MARSHALL EVACUATED THE ENTIRE BUILDING. THE PARKING GARAGE WAS FULL OF SOOTH AND DENSE BLACK SMOKE. THE MAIN LOBBY AND ELEVATOR LOBBY WAS FULL OF SMOKE. THE ER DIAGNOSED ME WITH SMOKE INHALATION AND SHORTNESS OF BREATH. SUBSEQUENT LUNG TEST SHOWS 30% DECREASED LUNG CAPACITY. *TR