Volkswagen · Model Report
Showing safety data for the 2000 model year only.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES AND DOUBLE-LAYER FUEL TANKS, TENSION ON THE FUEL SUPPLY LINE MAY CAUSE THE FUEL PUMP SUPPLY NIPPLE TO CRACK WHICH COULD RESULT IN A LEAK.
I HAD JUST GOT ON THE FREEWAY ABOUT 5MINS. ON THE CAR SHUT DOWN AND THEN THERE WAS A BACK FIRE THEN I SEEN A SYMBOL OF A CAR WITH A KEY UNDER IT LIT IN THE DASHBOARD, THE CAR WOULD NOT START BACK UP I HAD IT TOWED TO THE HOUSE AND THEN THE CAR STARTED BUT NOW IT HAS A PUTTER NOISE I CHANGED THE SPARK PLUGS THE WIRES AND O2 SENSORS AND IT STILL HAS THE PUTTERING NOISE. *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DEALER STATED THAT THE FUEL SYSTEM PUMP NEEDED REPLACING.THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V154000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE FAILURE AND CURRENT MILEAGES WERE NOT AVAILABLE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN GOLF. THE CONTACT STATED THE MATERIAL THAT WAS USED TO INSULATE THE VEHICLE RELEASED A TOXIC ODOR THAT CAUSED THE CONTACT TO HAVE HEADACHES, AND A RASH. THE MANUFACTURER FILED COMPLAINT 110328029 AND ADVISED HIM TO HAVE THE DEALER DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,909 AND THE CURRENT MILEAGE WAS 94,236.
2000 GOLF GLS. REPLACED CLUTCH IN MARCH 2008 AT 135K MILES. REPLACED CLUTCH FAILED IN NOVEMBER 2009 AFTER 15K MILES ON HIGHWAY! CAR TOWED TO NEAREST VW DEALERSHIP. CLUTCH REPLACED. VW REFUSED TO PAY FOR COST OF REPLACING CLUTCH SAYING NOT COVER UNDER WARRANTY EVEN THOUGH FAILURE ONLY AFTER 15K. *TR
No injuries · No fire · No crash
2000 VW GOLF 2.0L ENGINE; DRIVING TO WORK ON FREEWAY (65-70MPH). HEARD "POP" AND A HISSING NOISE FROM FRONT OF VEHICLE. SLOWED DOWN AND PULLED OVER TO SHOULDER, SAW COOLANT LEAKING. ENGINE WOULD NOT RESTART. TOWED TO DEALERSHIP, FOUND INTERNAL ENGINE DAMAGE TO VALVES AND PISTONS. CAUSE WAS A FAULTY WATER PUMP: VW USES A PLASTIC IMPELLER ON THE WATER PUMPS WHICH FREQUENTLY BREAK AND CAUSE THE ENGINE TO OVERHEAT VERY QUICKLY. AFTER THE DAMAGE, A SIMPLE GOOGLE SEARCH ON VW FORUMS REVEALED NUMEROUS OTHER PEOPLE HAD THE SAME PROBLEM I HAD. THE END RESULT WAS THAT I HAD TO REPLACE THE ENGINE, RADIATOR, TIMING BELT, WATER PUMP ($6000 REPAIR BILL). SADLY, VW PUT IN THE SAME TYPE OF WATER PUMP WITH THE PLASTIC IMPELLER, SO I HAVE LITTLE CONFIDENCE THAT IT WILL LAST LONGER THAN ANOTHER 60000 MILES. I WOULD HAVE CHANGED IT WITH THE TIMING BELT, BUT VW SAYS THE BELT IS NOT DUE TO BE REPLACED ON THIS VEHICLE UNTIL 105,000 MILES (JUST OUTSIDE THE 100,000 MILE WARRANTY, CONVENIENTLY!) CAR HAD ONLY 60,000 MILES ON IT, VW CLAIMS IT IS NOT COVERED UNDER WARRANTY DUE TO AGE OF VEHICLE. *TR
No injuries · No fire · No crash