Volkswagen · Model Report
Showing safety data for the 1991 model year only.
CERTAIN HYDRAULIC BRAKE HOSES, P/N 171.611.107B, SOLD AS REPLACEMENT EQUIPMENT FOR 1975-1985 VOLKSWAGEN (VW) RABBIT; 1985-1992 VW GOLF; AND 1980-1992 VW JETTA PASSENGER VEHICLES. POSSIBLE BRAKE HOSE RUPTURE COULD OCCUR WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES."
AN ENGINE PREHEATING TUBE MAY NOT BE PROPERLY SUPPORTED DUE TO A MISSING SUPPORT BRACKET, CAUSING THE PREHEATING TUBE TO CHAFE AGAINST THE RIGHT FRONT METAL BRAKE LINE. THIS CAN DAMAGE THE HYDRAULIC LINE, CAUSING BRAKE FLUID LEAKAGE AND DIMINISHED BRAKING IN ONE BRAKE CIRCUIT.
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
WHILE DRIVING IN EXTREMELY COLD WEATHER THE ACCELERATOR STUCK OPEN. ( IN RESEARCHING ON THE INTERNET I FOUND VOLKSWAGEN RECALLED CARS IN CANADA FOR THIS PROBLEM. RECALL TR (CANADA ONLY). ) THIS HAPPENED THIS WINTER -- BELOW 10*F . IT IS AN EXTREMELY HAZARDOUS SITUATION IN TRAFFIC. I HAD TO PULL OFF THE ROAD AND TURN THE CAR OFF -- PUSHING THE CLUTCH IN CAUSED HIGH REV'S. IN ADDITION, THE VEHICLE WOULD NOT IDLE WHEN IT WAS BELOW 20*F PUSHING THE CLUTCH IN AT A STOP LIGH WOULD CAUSE THE ENGINE TO QUIT. REPLACING THE IDLE STABILIZER VALVE HELPED THIS ISSUE -- AFTER THE ISV I REMOVED FROM THE CAR SAT INSIDE FOR SEVERAL DAYS I PICKED IT UP TO MOVE IT AND A CLEAR LIQUID RAN OUT WHICH LOOKED A LOT LIKE WATER. I HAVE OWNED THE CAR FOR SEVERAL YEARS BUT THIS IS THE FIRST YEAR I HAVE DRIVEN IT DURING THE WINTER AND THIS YEAR I HAVE MOVED 240 MILES FURTHER NORTH WHERE THE WEATHER IS COLDER. *AK
No injuries · No fire · No crash
TOP SECTION OF HEATER CORE CRACKED OPEN WHILE ENGINE AT IDLE SPEED ALLOWING VERY HOT COOLANT TO ENTER THE COCKPIT DRIVER AND PASS. SIDE AT THE FOOT LEVEL. AFTER EMAILING OTHER VW OWNERS GOLF, JETTA, GTI, PASSAT THEY HAVE REPORTED SAME PROBLEMS DUE TO FACT THAT VWOA USES THE SAME PART ON THESE CARS. ALSO FOUND A SAFETY RECALL W/ WWW.ALLDATA.COM WITH TSB # CMPGSD ISSUED MAY 1992 RE: HEATER CORE.
CONSUMER RECEIVED RECALL CAMPAIGN SK IN NOVEMBER 1999 DATED AUGUST 1993, HOWEVER NOT ABLE TO RECEIVE REPAIR DUE TO LACK OF KITS AVAILABLE FOR REPAIR. (92V-058) *MJS
No injuries · No fire · No crash
WINDSHIELD WIPER CONTROL SWITCH FELL OFF DUE TO WEAK MATERIAL. MJS
No injuries · No fire · No crash
HEATER CORE FAILED POURING HOT COOLANT INTO PASSENGER SIDE FLOOR AND STEAM POURING THROUGH VENTS.
No injuries · No fire · No crash