Ram 3500 Complaints (2018)

810 consumer complaints on file.

#11488985October 12, 2022
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
The contact owns a 2018 Ram 3500. The contact stated that while driving, the ABS and Traction control warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the ABS control module and HCU needed to be replaced. The vehicle was not repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11488226October 6, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM
ABS and Traction Control lights and DIC alarms came on while driving. They stayed on for a few minutes then went off. Also the service trailer brake system message came on. This has happened several times now turning off cruise control too. I reseated all fuses and went for two weeks before it started happening again. Happens sometimes as we go over expansion joints or hit potholes while driving at highway speeds. I notice several other reports of this here at NHTSA site and various RAM forums across various RAM years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11487181September 30, 2022
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
The contact owns a 2018 Ram 3500. The contact stated while driving 45 MPH, the antilock brakes (ABS) and the traction control warning lights illuminated. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the ABS module and the anti-skid controller to be replaced. The vehicle was not repaired due to parts being on back order. The contact called the local dealer and made them aware of the failure. The manufacturer had been informed of the failure. The failure mileage was 70,780.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11485692September 21, 2022
SERVICE BRAKES
I am getting two errors: 1) Service anti-lock braking system with the ABS light on; 2) Service electronic brake system with the traction control light lit.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11485376September 20, 2022
SERVICE BRAKES
Abs and traction control system stopped working with only 33000 miles. Dealer states module and pump need replacement. No warranty as vehicle is 4 years old as no driving during covid. This has happen to 1000's of ram trucks. Repair is $1600. Will have to drive with out repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11484622September 15, 2022
STRUCTURE:BODY
On Sept 11, 2022, we experienced a heavy rain shower while traveling along I64 westbound in VA. My 7 year old daughter in the back seat informed me the headliner was wet in the rear driver side corner. Upon further inspection the passenger side headliner rear corner was also wet. I inspected the top of the ruck, no damage was noted and the seals all appeared to be in place. There is a Jereco High Rise cap on the bed of the truck and we were pulling a 38' travel trailer at the time. The posted speed limit was 70mph on the stretch of road where the rain was encountered, however we were traveling between 40-60 mph during the rain event. No immediate safety risk was present. However, I'm concerned water intrusion may eventually result in an electrical fire or failure of a required safety device. Should water find it's way into a hidden harness or other electrical component such as the CHMSL (VOQ 10968851) or factory subwoofer which is located below the area which leaked. The vehicle has not been inspected or repaired by a dealer as it is just out of warranty. I did report this to RAM via Ram trucks on-line owner's portal. No warning lamps, messages have been observed at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11483727September 9, 2022
POWER TRAIN
The transmission in my truck has been having problems starting on 9/25/18. On 7/21/22, Grey Chrysler replaced the solenoid in the trans and also did an update. When I brought truck back after the same code, PO871, was thrown again on 08/30/22, I was told the warranty company couldn’t recreate the problem so they would not be fixing my trans. This is the same trans that is in the 2019-2022 Ram 2500 trucks and has a recall on it for the SAME problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11479535August 16, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM
ABS and EBS sytem is shutting on and off on highway at speeds. This is a random event that started at about 20,000 miles then went away for about 6,000 miles then came back at 29,000 miles whil on a 1,500 trip and is now not going away. The system shuts on and off constantly with chimes and alarms to "service ABS/EBS. I have the truck at the dealership and they advsied it needs to have the ABS pump and control module replaced. I have looked on the internet and see several hundred complaints for the same issue. The delaer says this is not a recall and is not covered by warrenty. To me this seems like a safety issue that is being ignroed by Chrysler corp / Ram. They are looking at the numbers and not enough people have been in accidents to justuify the cost of a recall. I have a video of the issue system turning on and off constntly at about 62 MPH as I enetered the freeway from and on ramp to merge in trafic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477458August 3, 2022
SERVICE BRAKES
A 2018 3500 RAM WITH 31K MILES JUST EXPERIENCED TWO WARNINGS ON THE DASH. 1. SERVICE ELECTRONIC BRAKE SYSTEM 2. SERVICE ANTI-LOCK BRAKE SYSTEM DIAGNOSED USING OBD BY MIDAS: BOTH ABS MODULE AND PUMP ARE GOING OUT. VEHICLE IS NOT CONSIDERED SAFE TO DRIVE. AREA IS BACKLOGGED FOR THESE PARTS (1000). THIS IS A MAJOR SAFETY ISSUE AS I'M TOLD THIS IS A CRONIC PROBLEM. COST TO REPAIR IS EXCEEDING $1800 NOT INCLUDING THE DIAGNOSIS. CALLED OUR LOCAL DODGE/RAM DEALER AND THEY SAID IT IS NOT ON ANY RECALL. WHY NOT? ITS MY UNDERSTANDING THAT NHTSA INITIATES SAFETY RECALLS WHEN VEHICLES ARE IN PERIL OF CRASHING DUE TO A FAILURE. WE MADE IT HOME BUT IF IT WENT COMPLETELY OUT, WE WOULD NOT BE HAVING THIS DISCUSSION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11474527July 18, 2022
TIRES, TIRES:TREAD/BELT
Our 2018 RAM 3500 is factory equipped with Nexen LT235/80R tires. This Ram has 16023 miles on it. We pull a 36 foot 5th wheel RV, weighing approx 15K lbs. When coming home from a trip on July 16th 2022 at 7pm, on I75 south around Sidney Ohio, 15 miles from home. This is a 70 mph zone, when we got to 60 mph the entire cab and bed started shaking and vibrating to where it was hard to keep on the road. At this time we feared of being or causing an accident. We exited and visually inspected the Ram and unit, and visually looked to be fine, We continued home via back county roads at a 35mph speed as the fear was still within us from what we just experienced. On Monday July 18th 2022 I took the Ram to Tires Choice 1101 West Main Street Troy Ohio [XXX]. The tech and I took the Ram out and reproduced exactly what we experienced on July 16th, without the trailer hooked. After inspection while on the lift it was found that the belt was broken on the front passenger tire , and was told we were lucky this did blow hauling a 15k trailer. I replaced all 6 tires in fear that the other tires may also be faulty, and if fear of having or causing an accident to would result in serious injury or even death. After researching this particular Nexen tire I found SEVERAL negative and shocking reviews. THIS TIRE NEEDS TO BE REMOVED AND RECALLED FROM THE PUBLIC. Thank you [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469850June 17, 2022
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
Unsafe and very hesitant acceleration nearly causing accidents. Long lag time between pressing the accelerator and engine responding to throttle input.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468241June 8, 2022
SERVICE BRAKES
Truck has 22000 miles ABS and traction control lights constantly coming on and off along with service electronic braking system warning. Kicks the cruise control off every time it pops up. The cause is the abs module which apparently is a very common issue on these trucks and costs over $1000 to repair
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466048May 25, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The ABS Anti lock lights came on and says check Electrical Brake System. Dealer said The ABS anti lock brake pump assembly was bad and it was on me to replace it. This is a big safety Issue to me. I got a 2018 3500 ram and paying big money for a truck and my safety, there should be a recall before some people get kill.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464844May 16, 2022
ELECTRICAL SYSTEM
The contact owns a 2018 Ram 3500. The contact stated while driving approximately 35 MPH, the contact observed that the check engine warning light was illuminated and the coolant temperature warning light was also illuminated. The contact pulled over safely and turned off the vehicle. The contact drove the vehicle to a dealer where it was diagnosed and determined that the thermostat, coolant sensor, and air intake heater relay needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V798000 (Electrical System) however, neither the VIN nor the vehicle year was included. The manufacturer had been informed of the failure. The failure mileage was approximately 67,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464183May 11, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
ABS and Traction control pump system electrical failure. Went to a Dodge Dealer and had the system read due to light coming on and off. Originally started around 38,000 miles on the truck. A code came up C0020-01. ABS pump motor control electrical failure. Researched on the net. Seems to be a big issue from 2013 on up on trucks. Chaffing wires? Pump failure? Dealer said the ABS Pump could Possibly be bad. Wondering if there is a safety Recall or will have one. I have my truck scheduled for repair next week. Estimated cost of $700.00 according to service department.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462539April 28, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
The warning chirp occurred and the ABS and ESC lights came on the first two times. The incident happened so quickly I could not clearly determine which warning lights illuminated. On April 18 with just over 39,000 miles on the vehicle the chirping alarm and the ABS and ESC light illuminated. In addition two warnings appeared in the dash: "Service Antilock Brake System" and "Service Electronic Braking System." The warnings happened multiple times per minute in some cases. Other times the vehicle would go for many miles without the warning. Every time the warning chirp was heard the cruise control would disengage. I did not notice any problems with the brakes of the truck. In researching the issue I learned that many people are having this problem. I contacted Ram and they directed me to a dealer who diagnosed the C0020-01 fault code and that the hydraulic control unit (HCU) for the ABS system was defective. According the the TSB Ram has put out about the issue the ABS module could also be bad, but the first part of the repair it to replace the HCU and if the problem persists to then replace the ABS module. Ram apparently has an inconsistent level of support for owners experiencing this malfunction with some getting the repair done out of warranty, while others have to pay for the repair. Because it is brake related it seems this should be an item replaced as a safety issue, no matter what the mileage on the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11462552April 28, 2022
ELECTRICAL SYSTEM
Uconnect screen delamination causes phantom button pushing while driving down the road. This causes random buttons to be selected and for things to start happening while driving. Driving distracted is dangerous driving. It will randomly call people, including using the SOS functionality. Making non-emergency calls to the emergency line is unacceptable. Once while driving, it turned the radio on and my volume was cranked up. I almost crashed into the car next to me because it scared me half to death. This is a known issue from what I've been reading on RAM forums and almost always shows up outside of warranty. The manufacturer should be held accountable for this to prevent future wrecks, distracted driving, and unnecessary SOS phone calls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461108April 18, 2022
SERVICE BRAKES
Service ABS light intermittent flashing and error code when checked. ABS is a safety issue that SHOULD not be defective at 40K miles. The ABS does NOT always work in inclement conditions such as rain, snow. When towing a 15K lb fifth wheel ram should FIX these issues as seen on many online communities
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461142April 18, 2022
WHEELS
The contact owns a 2018 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V398000 (Wheels) however, the part to do the recall repair was unavailable. The dealer had been notified about the issue; however, the contact was informed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460432April 11, 2022
SERVICE BRAKES, ELECTRICAL SYSTEM
Service electronic brake system with the traction control light lit. Seems to be a common occurrence
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 3500