Mercedes-Benz Sprinter Complaints

760 consumer complaints on file.

#11363990October 12, 2020
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL, WHEELS
WHILE DRIVING ON THE HIGHWAY IN CLEAR WEATHER, ABS/BAS/ESP WARNING LIGHTS TURN ON CAUSING LIMITED DRIVING DUE TO NO ABS BRAKING CRUISE CONTROL, OR STABILITY CONTROL. THIS HAS HAPPENED 5 TIMES ON VARIOUS WHEELS OF MY SPRINTER 3500 FROM 2013-2019. THE FAILURE OF THESE SENSORS CAUSES A VERY UNSAFE CONDITION. BESIDES THE SAFETY ASPECT, REPAIR OF THESE SENSORS ARE $500 EACH OCCURRENCE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11363787October 11, 2020
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN, VEHICLE SPEED CONTROL
THIS IS A WINNEBAGO VIEW 24G ON SPRINTER 3500 CHASSIS. WHILE HIGHWAY DRIVING, SUDDEN ABS AND ESP WARNING LIGHT WITH MESSAGE TO GO TO WORKSHOP. CRUISE CONTROL STOPS WORKING. LOSS OF POWER AND SHIFTING ABILITY IS INTERMITTENT. WAS ABLE TO DRIVE (WITHOUT CRUISE CONTROL AND WITH WARNING LIGHTS ON) FOR 100+ MILES TO SHOP. WHEN LOSS OF POWER OCCURED, I WOULD PULL OFF THE ROAD AND TURN OFF ENGINE, AND THIS WOULD TYPICALLY RESOLVE THE PROBLEM FOR AWHILE SPRINTER AUTHORIZED SERVICE CENTER REPLACED BOTH REAR WHEEL RPM SENSORS 7/3/20 ($581.09). SAME CONDITION RE-APPEARED DURING SIMILAR DRIVING CONDITION. SAME SPRINTER DEALER REPLACED RIGHT FRONT WHEEL SPEED SENSOR TO RESOLVE THE PROBLEM ON 8/18/20 ($507.48).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362944October 5, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
WHEEL SPEED SENSOR FAILURE CAUSED VEHICLE TO DISABLE CRUISE CONTROL, ABS BRAKE SYSTEM AND PUT THE TRANSMISSION IN LIMP MODE. CANNOT ACCELERATE MORE THAN 25 MPH ON THE INTERSTATE. WAS TRAVELLING AT 62 MPH WHEN EVENT OCCURED. FRIGHTENING EXPERIENCE!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362948October 5, 2020
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN, VEHICLE SPEED CONTROL
WHEEL SPEED SENSOR FAILED AT 10000 MILES (REFER TO PREVIOUS COMPLAINT), AGAIN FAILS AT 20000 MILES CAUSING ERRATIC TRANSMISSION SHIFTING AND PROPULSION WITHOUT DRIVER INPUT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362556October 3, 2020
VEHICLE SPEED CONTROL
ON 10/15/2018 WHILE DRIVING THE VEHICLE I BEGAN EXPERIENCING FLUCTUATIONS IN SPEED, WHAT FELT TO BE AT TIMES A SLIPPING TRANSMISSION, DIFFICULTY BREAKING, AND INEXPLICABLE WARNINGS ON MY DASH MESSAGE BOARD, AND A FEELING OF A LOSS OF CONTROL OF THE VEHICLE. I HAD THE VEHICLE TOWED FROM TUNICA, MS. TO MEMPHIS, TN. TO TAG TRUCK CENTER, A CERTIFIED REPAIR CENTER FOR SPRINTERS, WHERE THEY DIAGNOSED A FAULT IN THE RIGHT REAR WHEEL SPEED SENSOR. THEY REPLACED THE RPM SENSOR. THE COST FOR THE REPAIR WAS $494.20. AT THE TIME I HAD 23,029 MILES ON THE VEHICLE, BUT THE REPAIR WAS NOT COVERED BY A VEHICLE WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362197October 1, 2020
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL, STEERING
THE VEHICLE HAS SOME EMERGENCY STEERING CONTROL THAT IS AUTOMATICALLY BUILT IN. IF YOU GO OUTSIDE OF THE LANES, IT NOT ONLY STEERS YOU BACK TO WITHIN THE LANES, BUT ALSO SLAMS ON THE BRAKES. IT IS AUTOMATICALLY ON. IT CAN BE SHIFTED OFF EVERY SINGLE TIME YOU START THE VEHICLE, BUT IT IS A DEFAULT SETTING. THIS HAS PROVEN TO BE EXTREMELY DANGEROUS IN APPROXIMATELY 5 SITUATIONS WHILE DRIVING THE VEHICLE, AND I JUST BOUGHT THE VEHICLE FOUR MONTHS AGO. TO ILLUSTRATE IT: WE WERE DRIVING THROUGH A CONSTRUCTION ZONE. AT TIMES IN CONSTRUCTION/WORK ZONES, THE FLOW OF TRAFFIC FORCES YOU OUTSIDE OF THE LINES FOR SAFETY PURPOSES. HOWEVER, THE VAN TRIED TO FORCE US BACK "INTO THE LINES" MULTIPLE TIMES, IN CONSTRUCTION, AT NIGHT, WITH MANY OTHER VEHICLES. IT ACTUALLY FORCED OUR VEHICLE BACK ACROSS THE LINE AND INTO ONCOMING TRAFFIC IN MULTIPLE SCENARIOS. THIS IS A CASE OF AN AUTOMATIC "SAFETY" SETTING GONE WRONG. IT IS HIGHLY, HIGHLY DANGEROUS TO HAVE IT AUTOMATICALLY DO THIS, WHETHER IT'S DUE TO ONCOMING TRAFFIC, SAME DIRECTION TRAFFIC, CONSTRUCTION OBSTACLES OR EVEN SWERVING TO AVOID DEBRIS OR ANIMALS. THIS LANE ASSIST MUST BE DISABLED TO ALLOW FOR SAFE OPERATION OF THIS VEHICLE.*DT *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362276October 1, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
RMP SENSOR FAILED CAUSING VEHICLE TO LOSE ANTI LOCK BRAKES, TRACTION CONTROL AND CRUISE CONTROL. PLUS FORCED VEHICLE INTO LIMP MODE SO IT WOULD BARELY MOVE TO REST AREA TO CALL FOR ASSISTANCE. I'VE BEEN TO THREE DEALERSHIPS WITH THIS ISSUE AND THEY ARE ALL VERY AWARE THAT THESE FAULTY SENSORS EXIST. THEY HAVE BEEN AND ISSUE FOR YEARS PUTTING 100S IF NOT THOUSANDS OF SPRINTER OWNERS AT EXTREME RISK WITH LOSS OF ANTI LOCK BRAKES AND TRACTION CONTROL AT THE SAME TIME. MERCEDES BENZ NEEDS TO CORRECT THIS FAULTY PART AND RECALL ALL VEHICLES AND FIX
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11360999September 24, 2020
ELECTRONIC STABILITY CONTROL (ESC)
POWER STEERING WENT OUT AND CAR CRASHED. MERCEDES BENZ WALNUT CREEK CALIFORNIA REFUSED FREE REPAIR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11360859September 24, 2020
ELECTRICAL SYSTEM
RV TRANSFER SWITCH CAUGHT FIRE WHILE SLEEPING. 5100 SERIES TRANSFER SWITCH.*DT CONSUMER STATED DIDN'T KNOW WHY IT HAPPENED BUT COULD OF BEEN THE VIBRATION WHICH MAY HAVE LOOSEN THE SCREWS.*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11360835September 23, 2020
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
I HAVE A 2010 E350 WHILE DRIVING THE CAR IT THREW ITSELF INTO PARK , I WAS TRAVELING 5 MPH OR SO. IT DID IT A FEW TIMES ESPECIALLY WHEN COMING TO A STOP IN NEW YORK CITY , THIS IS DANGEROUS! THIS IS THE FIRST TIME TODAY IT'S HAPPENED AND IT HAPPENED ABOUT 4 TIMES TONIGHT , SCARY! , I CANNOT EXACTLY DUPLICATE WHEN OR WHY IT DOES IT. WHAT I HAVE DONE SO FAR... 1. I CHECK MY DOOR. MY DOOR IS NOT OPEN. THIS IS DANGEROUS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11360500September 22, 2020
POWER TRAIN
DRIVER PARKED VAN ON A HILL, PUT THE VAN IN PARK AND EXITED THE VAN. WAS OUT OF THE VAN FOR APPROXIMATELY 15-20 SECONDS. DRIVER HEARD A POP AND A GRIND. TURNED AND WATCHED HIS VAN ROLL DOWN A HILL INTO A HOUSE. INCIDENT WAS ON A CITY STREET IN A NEIGHBORHOOD. VEHICLE WAS STATIONARY.*DT *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11355724September 18, 2020
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
VEHICLE WAS DRIVEN ABOUT 5 MILES, PARKED AND NOT RUNNING, ABOUT 2.5HRS LATER FIRE STARTED ON THE LEFT REAR SIDE / UNDERCARRIAGE. FUEL TANK CAUGHT FIRE. NO PRIOR RUNNING DEFECTS. STARTING POINT FOR THE FIRE APPEARS AT OR NEXT TO FUEL TANK ON THE LEFT SIDE WITH THE FIRST FLAMES VISIBLE UP THE LEFT REAR WHEEL HOUSING WITH THE VEHICLE PARKED ON A SLIGHT INCLINE AND THIS ETCHED IN AN ARC SHAPE ABOVE THE LEFT REAR WHEEL. INSIDE VEHICLE NO PERSONAL ITEMS OR AFTERMARKET MODIFICATIONS. FIRE SPOTTED APPROXIMATELY 3:15 - 3:17 EASTERN TIME, WEATHER TEMPS IN MID 70S. THIS WAS A HIGH TOP 12 PASSENGER MODEL 144" WHEELBASE WITH AUXILIARY AIR AND HEAT OPTIONS. NO OCCUPANTS AND NO INJURIES.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11354676September 16, 2020
POWER TRAIN
2016 MERCEDES BENZ SPRINTER 3500. CONSUMER WRITES IN REGARDS TO ACCELERATION ISSUES. *LD THE CONSUMER STATED, WHILE DRIVING ON HIGHWAY 20, THE VEHICLE LOST THE ABILITY TO ACCELERATE AND SHIFT GEARS. THE SPEED DECREASED TO LESS THAN 20 MPH. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11355406September 16, 2020
ENGINE
MERCEDES BENZ 2500 2013 V6 DIESEL. YELLOW ENGINE WARNING LIGHT AND THE EBT YELLOW WARNING LIGHT CAME ON AND ANOTHER WARNING ON THE INSTRUMENT CLUSTER THERE ARE 5 MORE ENGINE STARTS REMAINING AND IT WILL NOT START IF DRIVEN MORE THAN 340 MILES. BOTH THE ERG VALVE AND THE EBT TANK AND HEATER HAVE BEEN REPLACED. WE WERE DRIVING UNDER AN EVACUATION ALERT BECAUSE OF FIRE. SPEED WAS 45-50 MPH. THIS INCIDENT HAS PUT US IN A DANGEROUS SITUATION BECAUSE WE ARE DEPENDENT IN THE SPRINTER FOR EVACUATION. THE DEALER IS 40 MILES AWAY AND CANNOT SERVICE THE SPRINTER UNTIL THE END OF SEPTEMBER. LAST NIGHT WE READ ABOUT MERCEDES BENZ EPA SETTLEMENT BECAUSE OF A DEFEAT PROGRAM AND FAULTY EMISSION COMPONENTS. WHAT CAN WE DO?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11355040September 14, 2020
STEERING
THIS SAFETY INCIDENT REPORT APPLIES TO ALL 2019+ SPRINTER 1500/2500/3500 WITH THE 4X4 DRIVETRAIN (HYDRAULIC POWER STEERING SYSTEM), IT DOES NOT APPLY TO 2WD MODELS WITH ELECTRONIC POWER STEERING RACKS. THE UPPER POWER STEERING HOSE THAT CONNECTS THE PS RESERVOIR TO THE PS COOLING ELEMENT LOCATED AHEAD OF THE RADIATOR IN THE FRONT GRILLE IS SECURED BY A WORM DRIVE CLAMP AT THE RESERVOIR SIDE AND A SPRING CLAMP AT THE COOLING ELEMENT SIDE. THE LOWER PS HOSE THAT CONNECTS THE COOLING ELEMENT TO THE HARDLINE WHICH BOLTS IN TO THE HYDRAULIC STEERING RACK ON THE DRIVER SIDE IS SECURED WITH A SPRING CLAMP ON THE COOLING ELEMENT SIDE AND A SWAGED CONNECTION ON THE HARDLINE SIDE. THIS SAFETY INCIDENT IS SPECIFICALLY FOR THIS LOWER PS HOSE CONNECTION. THE HOSE IS TOO SHORT FROM THE FACTORY, AND IS TAUT BETWEEN THE COOLING ELEMENT SPRING CLAMP AND HARDLINE SWAGED CONNECTION. OVER TIME, WITH NORMAL DRIVING VEHICLE VIBRATIONS & ENGINE BAY HEAT CYCLING, THE LOWER PS HOSE WILL BACK OFF THE COOLING ELEMENT UNTIL IT FALLS OFF AND PS FLUID IS DUMPED IN THE ENGINE BAY. THIS MAKES THIS HEAVY FULL SIZE VAN INSTANTLY EXTREMELY DIFFICULT TO STEER. HOSE BLEW OFF ON MY VAN AT 9500MILES ON THE ODOMETER, AS I WAS EXITING A FREEWAY ONTO A CURVING OFFRAMP. HAD I NOT BEEN AWARE THIS IS A KNOWN ISSUE I MIGHT NOT HAVE CAUGHT IT IN TIME... AT SPEED, ON A WINDING ROAD, WITH A CLIFF / DROP OFF NEARBY THIS COULD HAVE CATASTROPHIC RESULTS IF THE DRIVER IS NOT ABLE TO OVERCOME THE SUDDENLY VERY HEAVY STEERING EFFORT. THE SOLUTION IS A SIMPLE ONE. THE LOWER PS HOSE JUST NEEDS TO BE 1-2" LONGER SO THAT IT IS NOT TAUT BETWEEN THE TWO CONNECTIONS. TO DATE MERCEDES DEALERSHIPS HAVE ONLY REMEDIED TO THE PROBLEM BY ADDING A WORM DRIVE CLAMP IN PLACE OF THE SPRING CLAMP. THIS IS A POOR TEMPORARY FIX AND DOES NOT RESOLVE THE ISSUE THAT THE HOSE IS SIMPLY TOO SHORT AS MANUFACTURED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354416September 11, 2020
ENGINE
AT APPROXIMATELY 11,600 VEHICLE MILES THE DEF WARNING MESSAGE CAME ON STATING THAT THERE WERE ONLY 10 REMAINING STARTS LEFT ON THE VEHICLE. PREVIOUS MESSAGE PRIOR TO THIS WAS TO CHECK THE DEF SYSTEM LEVEL. DEF HAD BEEN ADDED FOR THE PREVIOUS 2500 MILES EVERY 500 MILES TO MAINTAIN A FULL TANK. SINCE I WAS IN WYOMING THERE WERE NO MERCEDES DEALERS AVAILABLE TO TROUBLESHOOT THE WARNING MESSAGES. AFTER THE LIMITING START MESSAGE I CONTACTED THE NEAREST MERCEDES DEALER IN FARMINGTON, UTAH FOR AN EMERGENCY APPOINTMENT THE FOLLOWING DAY. I DROVE APPROXIMATELY 260 MILES FROM THE TETONS IN WYOMING TO HAVE THE SYSTEM CHECKED AND REPAIRED AT MY EXPENSE. THE REPAIR REQUIRED THE REPLACEMENT OF THE DEF TANK AND ASSOCIATED COMPONENTS AT A COST OF $3,400.00. MERCEDES REFUSED TO COVER THE COST OF REPAIR DUE TO VEHICLE AGE FOR THE STATE( NC ) NOT COVERED IN EXTENDED EMISSIONS WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354158September 10, 2020
ELECTRICAL SYSTEM
MERCEDES HAS LOCATED A DASHBOARD DRINK HOLDER DIRECTLY ABOVE A VENT THAT OPENS TO THE STARTER ELECTRICAL MODULE AND CIRCUIT BOARD. THE DRINK HOLDERS ARE VERY SHALLOW, AND UNSTABLE. THE LOCATION ON THE DRIVER'S SIDE DASH, NEXT TO A VENT THAT LEADS TO THE STARTER CIRCUIT BOARD IS EXTREMELY DANGEROUS. I ACCIDENTLY SPILLED COFFEE ON THE DASH DRINK HOLDERS, AND THE SUBSEQUENT SPILL LED TO THE STARTER MODULE TO SHORT CIRCUIT, STRANDING OUR SPRINTER VAN, WHICH WOULD NOT START FOR OVER AN HOUR. ONCE STARTED AND DRIVEN FOR AWHILE, THE VAN WOULD NOT TURN OFF UNTIL PUSHING THE STARTER BUTTON CONTINUALLY FOR 20 MINUTES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11353595September 7, 2020
ELECTRONIC STABILITY CONTROL (ESC)
THE LANE KEEPING ASSIST ON THE MERCEDES SPRINTER 3500 IS UNSAFE. THE BRAKES ARE APPLIED WHEN YOU TOUCH A LANE MARKING CAUSING THE VEHICLE TO SWERVE AND SLOW DOWN RAPIDLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11352380August 31, 2020
ENGINE
TL* THE CONTACT OWNS A FOREST RIVER SOLERA RV TRAILERED TO A 2014 MERCEDES-BENZ SPRINTER 3500. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE ENGINE STALLED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO SEVERAL UNKNOWN MERCEDES-BENZ DEALERS WHERE, THE KNOCK SENSOR WAS REPLACED. THE CONTACT ALSO STATED THAT WHENEVER ONE OF THE SPEED SENSORS ON THE WHEELS FAILED, THE GEAR SHIFTER FAILED TO OPERATE INTERMITTENTLY. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE SUN MOTOR CARS, INC LOCATED AT 6677 CARLISLE PIKE, MECHANICSBURG, PA 17050, WHERE THE TECHNICIAN DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THE WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 1,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11352167August 30, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), STEERING
THE ACTIVE LANE KEEPING ASSIST IS HIGHLY DANGEROUS AND NEEDS TO BE PERMANENTLY DISABLED OR REMOVED FROM THE VEHICLE. I NARROWLY AVOIDED GETTING INTO A ACCIDENT. I WAS DRIVING ON THE HIGHWAY IN THE LEFT LANE AND HAD TO SERVE AROUND SOME DUMP ITEMS THAT FELL OF THE BACK OF THE TRUCK AHEAD. THE ACTIVE LANE KEEPING ASSIST FORCED THE VAN BACK INTO THE LANE AND TOWARDS THE JUNK IN THE ROAD AND ENDED UP RUNNING OVER IT. IT COULD OF BEEN A LOT WORSE IF THE OBJECT WAS BIGGER, A CAR, PERSON OR ANIMAL. I SHOULD BE ABLE TO TURN IT OFF ONCE! NOT EVERY TIME I HAVE TO RESTART THE VEHICLE. THIS WORRIES ME ESPECIALLY. WITH ALL THE SPRINTER VANS I SEE OUT THERE ON THE ROAD EVERYDAY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercedes-Benz Sprinter