Kia EV6 Complaints

534 consumer complaints on file.

#11721869March 3, 2026
FUEL/PROPULSION SYSTEM
ICCU failure. Pulled out of driveway, heard a pop, received warning to pull over and check vehicle power. Car had to be towed to dealership but they are experiencing so many of these failures that they are extremely backed up on even being able to check out the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721858March 3, 2026
ELECTRICAL SYSTEM, POWER TRAIN
The driver (my wife) was operating the Kia EV6 (with approximately 10,000 miles) when the vehicle suddenly experienced a severe loss of motive power. While driving, a warning message appeared on the dashboard indicating an issue with the power supply. Immediately after, the vehicle forced itself into "turtle mode," severely restricting the maximum speed to 20 mph and refusing to accelerate further. This sudden, unexpected deceleration on an active roadway put the driver at a significant risk of a rear-end collision. The driver managed to slowly navigate the vehicle back to our residence at a maximum speed of 20 mph, which was extremely hazardous. Shortly after safely parking at the residence, the vehicle experienced a complete electrical failure. It would no longer start, could not be shifted into neutral, and ultimately had to be dragged onto a flatbed tow truck by roadside assistance because the wheels were locked. The vehicle was towed to an authorized Kia dealership, where it is currently undergoing diagnosis and inspection for what is heavily suspected to be a total failure of the Integrated Charging Control Unit (ICCU) and 12-volt battery system. The vehicle and the failed components are currently at the dealership and are available for inspection upon request. Note: This catastrophic power loss occurred just weeks after the vehicle was in the shop for nearly a month to have its entire high-voltage battery pack replaced due to severe range degradation, marking the second major electrical system failure on this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721743March 3, 2026
UNKNOWN OR OTHER
Dash board showed limited power couldnt accelerate above 10-12 mph pulled into residental area dash then showed warning sign 12v battery then car died in middle of street. Could not put car in neutral called dealership said car cannot be put in neutral without special tools. I had taken it in for recall in 2023 or 2024 cant remember. Luckily i was not on highway as i could not even turn on hazard lights and car shut off abruptly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721716March 3, 2026
ENGINE, FUEL/PROPULSION SYSTEM
On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive.\n\nThe next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message.\n\nI then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle.\n\nI attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.”\n\nThe vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced.\n\nThe ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721594March 2, 2026
POWER TRAIN, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
1st instance: Battery Coolant errors that occurred on and off. 2nd instance: The ICCU unit failed and car was not able to charge via level 2 and only fast charge. Car was still operable. Dealer replaced ICCU 3rd instance: The ICCU failed and car was rendered inoperable. Dealer Replaced ICCU. We are now on our third ICCU since we purchased the car in 11/26/2022. This would be considered a lemon law
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721403March 2, 2026
POWER TRAIN
ICCU unit lost power and the car was unable to drive. Luckily I was parked when it happened but if I had been driving it would have been very dangerous. The part was replaced under warranty but they said it could happen again which really scares me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721305March 1, 2026
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
Persistent ICCU failure causing charging interruptions, “Check Vehicle Charging System” → “Stop vehicle and check power supply” warnings, low 12V battery voltage (down to 12.1V), and risk of power loss/strand. Kia Connect sent “Charge Interrupted” alert during a session that reached 99%. Multiple prior recalls/attempts failed to resolve (Sep 2023 TSB ELE291 BMS, Jun 2024 SC271 ICCU SW, Jan 2025 SC273 VCU SW, May 2025 SA5999 limp-home logic, Sep 2025 dead 12V stranding). Towed Feb 2026 after stranding; dealer confirmed ICCU failed (DTC P1A9096), replaced ICCU (P/N 36400-1XFA0AQQK latest revision), fuse, and SW update under SC327 (24V-867). Repair completed same day (Feb 24, 2026), but dealer skipped charging system test and filling coolant. Safety impact: Stranded wife twice (dead battery and iccu failure), tow required, potential sudden power loss while driving. Report purpose: Document recurrence despite multiple recalls; seeking NHTSA tracking for effectiveness of SC327 remedy.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721162February 28, 2026
ELECTRICAL SYSTEM
While charging my vehicle at a level 2 charging station, my vehicle ceased charging. I received no other warnings or symptoms prior to my vehicle ceasing to charge. Upon being alerted by the Kia Access app that the charging stopped, I went to check my vehicle and none of my doors would unlock in response to the buttons on my keys. I had to manually unlock my driver side door in order to enter my vehicle. I attempted to start my vehicle and unplug/re-plug in the charger, but my vehicle would not start or charge. Using a portable jump starter, I was able to jump start my vehicle and begin charging again. However, after approximately 5 minutes of charging, my vehicle stopped charging and once again would not start. At that point, I called for my vehicle to be towed to a Kia Service Center. The Kia Service Center was able to reproduce the problem of my vehicle not starting or charging and informed me that there was an internal short circuit caused by a bad Integrated Charging Control Unit (ICCU). The bad ICCU shorted my ICCU fuse, resulting in the draining of my 12-volt battery. The ICCU and fuse were replaced at no cost to me. Although my vehicle is available for inspection upon request, the parts that malfunctioned have been replaced with new, functioning parts. My safety or the safety of others were not at risk in this situation, but I was fortunate that my 12-volt battery died while parked and charging, not while I was driving, which could have caused an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721111February 28, 2026
ELECTRICAL SYSTEM
My car (Kia EV6) suddenly stopped charging with Level 1 and Level 2 charging. I brought it to the Kia dealership and it was diagnosed ICCU failure. ICCU was swapped and the car is charging again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720624February 26, 2026
ELECTRICAL SYSTEM
While the vehicle was on the charger, the ICCU failed which then caused then fried my JuiceBox EV40 charger and flipped the dedicated circuit breaker. The car has since been repaired. I am concerned that this is a dangerous failure. If it happened on the road it potentially left me without propulsion. I'm also concerned that but for the circuit breaker functioning as designed it could have caused an electrical fire. My understanding is that this has been an ongoing problem with Kia and Hyundai EVs. I do not believe that Kia/Hyundai are taking responsibility for fixing the problem that have not plagued other manufacturers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720542February 25, 2026
ELECTRICAL SYSTEM
While driving the car we heard a loud pop in the cabin. That was followed by electrical warning lights on the dash. WE were only about a mile from home and did make it back safely at greatly reduced speed. The ICCU was confirmed to have failed by the dealership. The part was replaced. If we had been traveling on the highway it might have been difficult to find a safe place to exit the roadway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720488February 25, 2026
ELECTRICAL SYSTEM
ICCU failure. The vehicle would no longer charge via AC and tripped the circuit breaker whenever plugged in. All necessary software updates related to the ICCU issue were completed timely before its failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720446February 25, 2026
ELECTRICAL SYSTEM, POWER TRAIN, FUEL/PROPULSION SYSTEM
The ICCU unit failed. Limited speed and no charging capabilities. The Dealer has been informed and an appointment has been made 3 weeks out as they are too busy. The ICCU has not been inspected yet. No warning lamps or messages appeared before the problem started. After a loud POP or bang in the rear of the car 1 warning light appeared and 1 message. (See Attached) POP happened at 16:15 hrs on the attached graph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720337February 25, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, ENGINE
On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive. The next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message. I then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle. I attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.” The vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced. The ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720112February 24, 2026
ELECTRICAL SYSTEM
The contact owns a 2022 Kia EV6. While the contact’s daughter was driving approximately 40 MPH, the messages "Electric Failure: Stop Car Do Not Drive” and “12-Volt Battery Voltage Low" were displayed on the instrument panel. The vehicle then failed to exceed 20 MPH, causing the driver to activate the hazard lights while pulling over to a side street while driving approximately 5 MPH. On the side of the road, the vehicle lost power. The vehicle was left at the side of the road to be towed to the nearest dealer. The dealer was contacted and confirmed that it was a known failure with the Interior Command Centre Unit(ICCU), and that the ICCU might need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720052February 23, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
ICCU failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719960February 23, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Pulling out of garage, car warned of limited speed and then within about 30 seconds completely shut down-- could not move, operate locks, etc. Car could not be started again and had to be towed away. 12v battery had been drained down to 4v due to failure of ICCU unit. Dealership replaced entire ICCU unit and fuse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719909February 23, 2026
UNKNOWN OR OTHER
ICCU failure. It blew up my home charger and shorted out. Would no longer charge the car on level 1 or 2 charger.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719866February 23, 2026
ELECTRICAL SYSTEM
vehicle will not charge properly due to ICCU failure, causing it to not charge the 12v battery which could have caused it to run out of battery at any moment causing the car to stop operating while driving which could have caused an accident, particularly because I do mostly highway driving. The dealership has confirmed the ICCU failure. While it supposedly got the previous recall fixes, that did not prevent it from failing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719771February 22, 2026
POWER TRAIN, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
The ICCU system in my 2022 Kia EV6 failed for the SECOND time on the highway. The car threw an error telling me to "Check the electrical system" and "Pull over safely immediately" or something similar. Had I not made it to the shoulder, I would have been completely stranded in the middle of the highway, creating an incredibly dangerous situation. This is the second time this has happened with my EV6 in less than 50,000 miles on this car. I had to call a tow truck. I confirmed with the Kia dealership the ICCU system had randomly failed and was required to be replaced *AGAIN*. My wife was in the car with me and was freaked out. She doesn't feel safe in it because there's no rhyme or reason to when it happens. KIA says it is a known issue, and confirmed it was the second time this has happened to my car. No symptoms prior to it happening. We were just driving and then suddenly the car lost power and the warning displayed on the dash.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia EV6