Kia EV6 Complaints

534 consumer complaints on file.

#11757866August 19, 2026
UNKNOWN OR OTHER
I charged my car at a level 3 fast charger on a road trip. After completing my charge, the AC stopped working. The fan worked but it was only blowing hot air. Normally this would be a nuisance, but the day was about 114 degrees and the car’s interior was probably close to 140 degrees. I was driving on the interstate so it was very hard to keep the windows down. The lack of HVAC made the car difficult to operate and if my family was in there would have been a safety hazard. I took it to the dealer who initially thought it need the coolant to be recharged. It turns out that the inverter for the A/C died. Apparently this has some connection to the known issues with the ICCU, which in my case just blew out and was replaced a month and a half prior to this incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757865August 19, 2026
ELECTRICAL SYSTEM
ICCU failure. I charged overnight at my home L2 charging as usual. I backed out of my garage and heard a loud pop. Almost immediately an “check electrical” warning came up. The car went to turtle mode and then completely died. The car was towed and I was informed the ICCU needed to be replaced. The car had all previous checks on ICCU performed (per mailed recalls) and was updated and passed each time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756873August 14, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
I own a 2025 Kia EV6 Wind RWD. At approximately 14,655 miles, the vehicle experienced a confirmed Integrated Charging Control Unit (ICCU) failure that resulted in loss of 12-volt charging and reduced motive power. On August 1, 2026, while reversing the vehicle, I heard a loud pop from underneath the rear seating area. Immediately afterward, the red 12-volt battery warning light illuminated and the vehicle displayed a “Check Electrical Vehicle System” message. Because I was concerned that the vehicle was no longer charging the 12-volt battery, I externally charged the 12-volt battery with a smart charger and then measured the battery voltage with a multimeter. With the vehicle off, the battery measured 12.99 volts. After starting the vehicle and confirming it was in READY mode, the voltage measured only 12.35 volts, indicating that the vehicle was not maintaining the 12-volt electrical system. When I drove the vehicle to Hilltop Kia on August 3, 2026, the vehicle had substantially reduced propulsion and would not exceed approximately 45 mph. The dealer diagnosed the vehicle and documented DTC P1A961C, “LDC Internal Power Supply,” and DTC P1A9096, “LDC Input Voltage Sensor.” The dealer’s Kia diagnostic system showed LDC input voltage of only 1.7 volts, compared with a stated typical value of approximately 565.5 volts. The dealer replaced the Integrated Charging Control Unit (ICCU), part number 36400-1XF06, and the high-voltage ICCU fuse, part number 375F2-GI040, under warranty. The cooling system was bled, diagnostic trouble codes were cleared, and the vehicle was road tested and returned to me on August 6, 2026. I purchased the vehicle new on November 28, 2025. My vehicle is a 2025 model year EV6 and is outside the earlier 2022-2024 EV6 ICCU recall population. I am filing this complaint because the ICCU failure caused the vehicle to stop charging the 12-volt electrical system and resulted in significantly reduced motive power. The symptoms and dealer-confirmed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756869August 14, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, POWER TRAIN
While driving southbound on the [XXX] in a rented 2023 Kia EV6 from The Hertz Corporation, picked up in [XXX] on XXX, the vehicle entered "Power Limited" mode without warning. The vehicle lost normal propulsion and decelerated from highway speed to a crawl, forcing 4-5 emergency stops onto the highway shoulder over several miles while semi-trucks passed at 70+ mph in live traffic, with two minor children in the vehicle. The vehicle was ultimately abandoned at a highway rest stop on Hertz Roadside Assistance's instruction and towed. This vehicle was subject to three NHTSA recall campaigns for the ICCU defect that produces exactly this failure mode: 24V057000 (SC295, driveshaft, notice mailed XXX), 24V200000 (SC302, ICCU 12V charging failure/Power Limited mode, notice mailed XXX), and 24V867000 (SC327, expanded ICCU remedy superseding SC302, notice mailed XXX) — all mailed well before this vehicle was rented to me on XXX. Under 49 U.S.C. §30120(i), a rental company may not rent a covered rental vehicle subject to an unremedied safety recall. I am requesting NHTSA use its inspection authority under 49 U.S.C. §30166 to determine whether Hertz completed the required SC327 remedy on this vehicle before renting it to me, and to review Hertz's fleet-wide recall compliance for its Kia EV6 inventory. This does not appear to be an isolated incident: NHTSA complaint ODI XXX, filed XXX, describes a near-identical failure — a rented 2023 Kia EV6 (Dollar Rent A Car, a Hertz-owned brand) losing power and shutting down multiple times on the freeway during a single trip, also towed. Two renters, two Hertz-family rentals, same defect signature, five months apart. Hertz has been on written and verbal notice of this incident since XXX, and I sent a formal written demand on XXX with a response deadline of XXX. As of this filing, Hertz has not responded. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756667August 13, 2026
ELECTRICAL SYSTEM
I began to drive. The dashboard display read "Check low voltage supply" or something like that and on the opposite side of the display there was a small image that looks like a 12V battery. A moment later the dashboard display changed to read "DO NOT DRIVE." The car was towed to a dealer who reported a "failed ICCU and High Voltage Fuse." The vehicle was towed to a dealership where it is being repaired under warranty. The same parts were replaced on December 26, 2024, that time because the electric vehicle would no longer accept a charge from a 240VAC source, although it continued accept a charge from a high voltage DC source. At that time there was also a software update that was said to correct the defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756380August 11, 2026
ELECTRICAL SYSTEM
The door closed sensor fails intermittently. This causes the car to sound an alarm while driving, prevents locking of the doors, and results in automated sudden braking at low speeds, such as in heavy stop & go traffic, causing a significant crash hazard. When it engages in the emergency braking routine, it shifts out of gear, so you can’t prevent a rear collision by simply accelerating, you must rapidly shift the car into gear, first.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753434July 29, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM, POWER TRAIN
While driving a rented 2023 Kia EV6 on the freeway, the vehicle lost power and shut down completely, without warning, on multiple separate occasions during a single trip. This occurred at highway speed in live traffic, creating a serious risk to vehicle occupants and surrounding traffic. The vehicle was a rental (Dollar Rent A Car); no external damage or collision was involved. The vehicle has since been towed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753424July 29, 2026
EXTERIOR LIGHTING
The taillight came loose and every time i take it in to get checked or fixed at the dealer they ignore me, so i went in and tightened my self. there were 4 nuts already off and inside my trunk and there was no loctite on the bolts holding the light on. now the lamp is leaking water into the trunk and the tail light has water inside of it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753355July 28, 2026
ELECTRICAL SYSTEM, ENGINE
Vehicle Safety Complaint My Kia experienced an ICCU (Integrated Charging Control Unit) failure and was at the dealership for approximately two months while awaiting repairs. The ICCU and related components were replaced, and I was told the vehicle had been repaired. However, immediately after I received the vehicle back, the “Check Electric Vehicle System” warning illuminated again. Since that time, the vehicle has continued to experience serious electrical issues. The vehicle has unexpectedly shut off while stopped at red lights and has failed to restart on multiple occasions, leaving me stranded. This creates a significant safety hazard because the vehicle can lose the ability to move while in traffic, placing me and other motorists at risk. I have returned the vehicle to the dealership twice since the ICCU replacement, but the problem has not been resolved. The dealership has been unable to identify or permanently repair the defect. I have been without my vehicle for nearly three months this calendar year due to this issue. More importantly, I no longer feel safe driving the vehicle because I cannot trust that it will remain operational in traffic. I am submitting this complaint because I believe this represents a serious safety defect involving the vehicle’s electrical system and propulsion system. I request that NHTSA investigate this issue to determine whether other Kia owners are experiencing similar failures and whether additional action is warranted to protect consumers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753114July 27, 2026
STRUCTURE:BODY
The front lower air dam and felt underguard detached while driving at highway speed on an interstate. The panel dropped and dragged on the pavement. I secured it with duct tape and zip ties at the roadside in order to drive home. There was no collision and no impact with road debris. The bumper fascia directly above the panel is undamaged, with no deformation and no paint transfer, which is not consistent with an impact and is consistent with failure of the panel's mounting fasteners. The panel shows longitudinal drag scoring on the underside and outward flex-fracture of the mounting clips. The right side detached first and the left side remained held by a single screw. The component is available for inspection on request. There were no warning lamps or messages before the failure. I brought the vehicle to a Kia dealer in [XXX] on XXX, at approximately 40,000 miles and within the 5-year/60,000-mile basic warranty. The dealer's technician identified multiple fractured mounting clips, of which only two remain intact. The dealer declined to submit a warranty claim, citing evidence of impact, and reattached the panel using added screws. The fractured clips were not replaced. The dealer's paperwork records the vehicle as repaired, but the technician verbally advised me to drive carefully because the underlying fastener failure was not corrected and the panel is not held by its designed fasteners. I opened a case with the manufacturer's consumer assistance center on June 9, 2026 (case number XXX) and submitted photographs as requested. I have received no substantive response in six weeks. A body panel that detaches at highway speed and drags on the roadway is a hazard to the vehicle behind it and to my control of the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752073July 22, 2026
ENGINE, POWER TRAIN
Hi, I had to transport a few lumber pieces that did not fit into the trunk of my Kia EV6, so I had to leave the hatch open (I pulled it down as far as possible and secured it via a rope against the latch). When I started driving the car started beeping frantically, but allowed me to drive. When I crossed an intersection traffic came to a temporary halt, and when I came to a stop my Kia all of a sudden shut off and would not allow me to put it back into gear again. When traffic around me continued I was unable to move and presented a security hazard with cars coming from behind almost running into me because they expected me to move, which I couldn't. I inquired about this at my dealership this morning and was told that there is no way to override the car's behavior and that this behavior was a "safety feature" to ensure the car wouldn't be driven with the hatch open. Now I'm asking since when is it a safety issue to knowingly drive with the hatch open to transport an oversize item - shouldn't that decision be left to the operator of the vehicle? In my opinion it's a much bigger safety issue to all of a sudden disable the entire powertrain of the vehicle when coming to a brief stop. What if the brief stop would have happened on a highway or freeway? Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751635July 20, 2026
ELECTRICAL SYSTEM
Car was totally dead even with a 68% charge. AAA came out to jump start. The next day while driving on the highway the car started to lose power. A red warning to check the electrical system came on along with "turtle mode". I was able to pull over off the highway, grateful the two small children were not with me. Car was towed to dealer who kept it for the three days. Only after repeated calling could I reach someone who said they couldn't reproduce the problem. I'm afraid to drive the car at this point as I feel it's just unsafe to do so. This seems to be an ongoing issue that Kia can't seem to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750683July 15, 2026
WHEELS
Rear tires on my 2024 Kia EV6 wore down to the tire wear-bar limit (2/32" remaining tread) at approximately 19,500 miles, while the front tires on the same vehicle measured roughly double that remaining tread (4/32") at the same odometer reading. The factory-installed tires are rated by the manufacturer for approximately 50,000 miles of tread life under normal use, so reaching the wear-out point on the rear tires alone at roughly 39% of that rated mileage is well outside expected wear for this vehicle at this mileage. This is not an isolated event: numerous other EV6 owners have independently reported the same front-to-rear wear disparity and premature rear tire wear online, across different driving styles and regions, which points to a vehicle characteristic (front/rear torque split, alignment or camber specification, or suspension geometry) rather than individual driver behavior. Uneven, accelerated rear tire wear reduces traction and increases stopping distance, and raises the risk of hydroplaning, tread separation, or blowout, particularly in wet weather, since the rear tires lose effective grip well before the front tires or before a typical maintenance interval would flag it. The wear was confirmed and documented, including tread-depth measurements at all four corners, by an independent third-party vehicle condition inspection performed at lease return. There were no dashboard warning lights or driver-facing alerts indicating the wear; it was only discovered through physical tread-depth measurement at that inspection. The tires inspection results are available upon request. This appears to reflect a design or specification issue affecting the vehicle's rear tires disproportionately, rather than a manufacturing defect isolated to one tire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749585July 10, 2026
ELECTRICAL SYSTEM
We purchased a certified pre-owned 2024 Kia EV6 GT on 6/5/2026. On 6/6/2026 while driving on city streets, the display screen suddenly displayed a large and flashing red warning message "Stop vehicle and check power supply" in addition to the battery symbol. We took the vehicle to the dealership and they diagnosed that the ICCU had failed and needed to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748279July 4, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
1. Severe Safety Concerns (Battery Thermal Risk & Component Interdependency) The PTC (Positive Temperature Coefficient) heater in my vehicle has failed. This component failure has completely disabled my vehicle’s air conditioning (AC) system. In the Kia EV6 architecture, the AC compressor loop is not merely a cabin comfort feature; it is intrinsically linked to the vehicle's thermal management system responsible for cooling the high-voltage traction battery pack. California temperatures are projected to hit 110°F immediately. Without a functioning AC system, the vehicle cannot execute critical battery cooling procedures. Yesterday, when plugging the vehicle into a charger, the high-voltage battery became alarmingly hot. Forcing a lithium-ion battery pack to accept high-current DC fast charging without operational coolant loop heat rejection poses an immediate, catastrophic risk of thermal runaway and vehicle fire. I am terrified to operate, park, or charge this vehicle in upcoming extreme summer conditions. 2. Predatory Maintenance Plan Tie-In Offer Yesterday, the dealership called and acknowledged the issue. They offered to cover 70% of the diagnostic and repair labor costs under corporate goodwill, as I am technically out of the standard warranty period. However, they applied an unfair and coercive condition: I am only eligible for this safety assistance if I purchase a mandatory 2-year maintenance contract costing $120 per month (totaling $2,880 over 24 months). Because the EV6 is a fully electric vehicle, its routine maintenance profile is virtually nonexistent. The dealership explicitly stated that this contract would exclusively cover tire rotations. Charging nearly $3,000 for tire rotations as a gatekeeping mechanism to fix a dangerous battery cooling defect is highly exploitative. The cost of this forced maintenance plan essentially equals or exceeds paying for the entire repair out-of-pocket, rendering the "70% goodwill coverage" an empty gesture.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747419June 30, 2026
ELECTRICAL SYSTEM
The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 6-7 MPH in the left-turn lane, the vehicle made an abnormal popping sound and stalled. The vehicle was pushed to the side of the road with assistance. The vehicle failed to restart and was towed to the dealer, where it was diagnosed with Integrated Charging Control Unit (ICCU) failure. The ICCU was replaced, and the vehicle was repaired; however, the failure recurred several times. Additionally, the contact stated that while driving at slow speeds, the messages "Check ABS", "Check ESC", "Check Electronic Parking Brake" and "Pull Over Safely" were displayed, and alarms sounded on several occasions. The vehicle was not repaired. The manufacturer was contacted several times, and a case was filed. The failure mileage was approximately 12,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747389June 30, 2026
ELECTRICAL SYSTEM
ICCU failure caused charger circuit breaker to trip due to sudden fault current situation
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747190June 29, 2026
ELECTRICAL SYSTEM
On the night of [XXX], the vehicle was plugged in to AC charge at my home charging at 7.5kw (32 amps/240 volts). The next morning, the dedicated breaker to the EVSE was tripped, and the EVSE was damaged and unusable upon resetting the breaker. The car had charged approximately 20% before cutting off. A new EVSE was ordered and arrived by that night, however the car would not accept a charge, and displayed a "charging failure" message, despite the new EVSE working on two other electric vehicles. Additionally, the vehicle to load (V2L) functionality was compromised, and the vehicle displayed an error message when attempting to use the V2L. The vehicle was taken into Kia service center located in Mission, KS on 6/29, and diagnosed with a broken ICCU, which is scheduled for service on 7/1/2026. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746106June 24, 2026
ELECTRICAL SYSTEM
Driving on three lane highway at 60 mph the car abruptly lost power. Was able to get off the highway. Called Kia roadside assistance. Tow truck picked up car and delivered it to Kia dealership. Service dept diagnosed and is replacing the ICCU.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746073June 23, 2026
ELECTRICAL SYSTEM
ICCU electrical system failed while driving (~1mi from house). Warning messages popped up and caused me to pull over and drive back to house under reduced speed. Kia told me car was not safe to drive and to tow car for repair under warranty. ICCU failure was confirmed by service provider and repaired after 2 weeks (diagnosis, part order, and replacement).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia EV6