Hyundai Santa Fe Complaints

8,019 consumer complaints on file.

#11538851August 16, 2023
POWER TRAIN
Once again on 7/18/2023 (P1C2D03) and 8/15/2023 (P1C2E92) DTC for TCU issues VERY DANGEROUS condition, fails to accelerate from stops at signs and traffic lights, then nearly stalls in traffic lane bogging down, and cuts out decelerating when accelerator pushed to floor, risking being rear-ended by following cars. By the time car is ready to take to dealer for analysis the fault has corrected and there is no active code for diagnosis – been repaired twice but continuing TCU codes. SEEMS to be same issue as Recall 236, don't believe the fix is effective
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538542August 15, 2023
ENGINE
Engine threw a rod. Brought it to Kearny Mesa Hyundai here in San Diego, they submitted a claim to see if corporate would grant an engine replacement and it was denied due to it being a V6
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538607August 15, 2023
ENGINE
While driving on the highway my engine seized up and stopped working altogether. My dashboard went completely red with warning lights and I could get to the side of the road to call for assistance. The day prior while getting an oil change I was told by the mechanic that some Hyundai cars have been consuming oil quickly and that I had less than a quart left while I just was a little of the 3000-mile mark. The previous oil change I was also told I was at a very low level as well. I called the dealership about the concern and they were willing to run some tests on the car, but that afternoon the engine seized up. The car was towed back to the dealership and I was able to have the engine replaced by the manufacturer. I was very concerned for our safety when the incident happened because I was on a highway traveling at a high-speed rate (posted 60mph) but was glad to safely make it to the shoulder of the roadway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538673August 15, 2023
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Upon approaching stop sign, the vehicle stalled and after restart, the vehicle ceased acceleration at intervals. This caused the vehicle to impede/slow traffic during journey. Again, at stop light, the vehicle stalled and “all” warning lights appeared. The engine failed to restart and the vehicle was towed from traffic due to engine failure. The vehicle is a 2017 Hyundai Santa Fe Sport 2.4 with 116,000 miles. An Engine Class Settlement has been established for the model years 2010-2012 with this same issue. The vehicle will be towed to a dealership for inspection, confirmation and repair. I felt the need to make an incident report thinking maybe other reports have been filed, also, and the manufacturer reusing to admit to problem issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538760August 15, 2023
ENGINE
Rod knock, engine failure. Vehicle still runs. Engine was accepted for replacement via Kearny Mesa Hyundai dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538430August 14, 2023
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
I was driving the vehicle my pregnant wife and 1 year old baby were in the car with me. Car started shaking and i was loosing speed right before getting off the freeway. There was a very strong smell of gas as if it was leaking but it was not. I have an appointment to be checked at the dealership Wednesday August 16th. This is the second time something like this happens while driving in the freeway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538200August 13, 2023
ENGINE
Vehicle is at 106,000 miles. Coming to a stoplight the vehicle completely shut down. Upon inspection seeing the drive belt was missing. Vehicle will not turn over, battery is fully charged no other issues. Check engine light is now flashing AFTER it shut down NOT before like NHTSA recommends..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538222August 13, 2023
ENGINE
I was driving home from work, no warning lights flashed. My car abruptly stopped and my engine started misfiring and making loud noises. After the experience the engine light started to illuminate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538085August 12, 2023
ENGINE
My 2017 Hyundai Santa Fe is excellently maintained with 130,000 miles on it with a faulty rod requiring engine replacement. There is a safety recall #168 for the exact same failure on the same year make and model and engine but Hyundai will not cover my engine as this recall is vin specific and mine does not qualify. Now left a loan on a car that I cannot drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538150August 12, 2023
ENGINE, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
On May 2023, while my husband was taking my daughter to go to school with 2017 Hyundai Santa Fe, he noticed engine knocking noises emanating from the engine compartment. Shortly after, the vehicle's performance significantly deteriorated, and the check engine light illuminated on the dashboard, and the engine shut down. Get the car towed to the nearest auto service, the mechanic told me that there’s an engine failure as result of abnormal oil consumption causing internal damage and need to be fixed by Hyundai. I called Hyundai USA, and was told that in order to have it covered under the warranty, it needed to be repaired by an authorized dealer. However, no authorized dealer had an available appointment for at least 2 months. Finally after 2 months, I had the car towed to the authorized Hyundai service center for diagnosis and repairs. Upon examination by the certified technicians at the Hyundai service center, I was informed that it needs and engine replacement that will cost around $20,000. I called Hyundai Corporation and had escalated my case to the case manager, but the manager never called back to give me an update. Their customer service department is also frustrating to deal with. They just sort of repeat the same phrases over and over again rather than having any sort of actual conversation with you. It's been more than 2 months after the incident and they finally they can’t do anything about it because it’s outside of warranty. It’s very frustrating
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537914August 11, 2023
ENGINE
The contact owns a 2013 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the steering wheel became inoperable, and the steering wheel seized. Several unknown warning lights were illuminated. The contact was able to safely drive the vehicle into a parking lot before the vehicle lost motive power. The contact stated that she then called her husband, and her husband was able to restart the vehicle and drive it to the residence safely. The vehicle was towed to the dealer, where it was diagnosed with a faulty alternator. The vehicle was repaired. The contact stated that while driving on the highway, the failure reoccurred with several unknown warning lights illuminated before the vehicle stalled. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the alternator had been replaced twice and the battery had been replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 144,904.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537846August 11, 2023
ENGINE
About two months ago my son was driving home and noticed the oil light flash on and off quickly while he was driving. He immediately brought the car to our regular mechanic who instructed him to just check the oil "it might be a little low"- When my son arrived home we checked the oil and the oil was down 3+quarts. There is no engine oil leak, and the oil in the car had been changed recently and has also been changed every 3-5K miles per the manufacturers recommendation. We did a bit of research and learned that this is a known problem for thousands of Hyundai owners and that Hyundai recommended we start a case with them. We did. We had an oil consumption test performed during which we were told not to check the oil at all ourselves or it would "ruin the test". We were then told that the car was "only down a quart of oil after 1K miles and so it is fine"- The case manager told us that if the car had been down even an ounce more than a quart, we would be moved into a place where we could get some repairs done on the known defective engine. We are now left with a car that burns oil at a rate that is not normal or safe. In addition, our car makes loud popping noises upon start which we have researched and found is due to oil escaping from the engine and going to places in the car where it should not be. We don't believe the car is safe to drive because there is no consistent way to determine how much oil the car is burning and asking a customer to replace a quart of oil every 1K miles is unreasonable. There are thousands of people across the US who are experiencing this same issue. Why hasn't there been a recall?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11538034August 11, 2023
ELECTRICAL SYSTEM, ENGINE, STEERING
May 5th 2023 my car was broken in to.The back passenger window was broken out and the steering column was tour out .The car was undrivable. The car was towed May 18th to Nalley Hyundai.I just got my car back today Aug 11. I understand Hyundai is suing TikTok I was given a number.She said when they go to court.When .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537739August 10, 2023
ENGINE
My Santa Fe has just under 87,000 miles on the engine and has developed a knock. No check engine light was ever illuminated. We scheduled the vehicle for an inspection at the dealer. After a week, we were informed that we had a connecting rod bearing failure. We purchased this car second hand at 74,000 miles and have put 2 oil changes on it since owning it. This car is the primary vehicle for my wife and if this rod would have locked up while driving, it could have put my entire family at risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537795August 10, 2023
ELECTRICAL SYSTEM, ENGINE
Failed oil pressure sensor which was leaking oil through the wiring harness; could have caused a fire from oil dripping on exhaust system. Oil pressure sensors should only fail electrically, not from allowing high pressure oil to leak out. Dealer states there have been some cases where the oil flowed through the wiring harness to the vehicle ECU, rendering a severe problem in controlling the vehicle. Dealer repair invoice attached. Besides the oil pressure sensor the wiring assembly had to be replaced from the oil contamination.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537803August 10, 2023
POWER TRAIN, FUEL/PROPULSION SYSTEM
The car is 2017 Hyundai Santa Fe with a defective crankshaft. The car is leaking oil. I called Hyundai and they noted that although they have recall 168 the VIN for my car doesn't match a recall that is on their website. I spoke to a Hyundai case manager today who said that even though my car has the defective crankshaft they will not repair the vehicle because it beyond 100,000 and the recall is expired. I am seeking help from the NHTSA as my car should be covered under this recall. I took it to an independent shop that noted that my car should be covered. I have photo and documents to prove that my car should be covered under this recall. My VIN just doesn't match their records and they are denying my claim.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537455August 9, 2023
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
The contact owns a 2012 Hyundai Santa Fe. The contact stated that while driving 25 MPH, the vehicle made an abnormal sound. No warning light was illuminated. The contact looked in the rear-view mirror and became aware that the spare tire had detached from the vehicle. The contact was able to drive to the dealer. The vehicle had not been diagnosed due to a diagnostic fee being charged. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,250.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537412August 9, 2023
POWER TRAIN
The vehicle started stalling on HWY and check engine light came on. I was trying to accelerate as other vehicles were catching up but it won't do that. After a while it did regain the power. We took the vehicle to Hyundai dealership in Roswell, GA and they reset the check engine light. They told us that it was OK to drive with solid check engine light. We need to pull over and call roadside assistance if check engine light starts to blink. We have an appointment for oil change on 8/18 and when we bring in the vehicle at that time, ask them to do the diagnostics. Even yesterday, the car started to stall. Reported the incident to Hyundai case # 21849832. Error code on dash - P1C2D03
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537141August 8, 2023
ENGINE
8/5/23 was driving on turnpike when 2016 Santa Fe lost complete power without warning. Was barely able to pull over to the side of the road and the car completely died. Was in the car with 3 small children all under the age of 7 and stuck for over 2 hours waiting for a tow no air conditioning and no safe place to wait on the side of the turnpike with barely enough shoulder space for the car. Had car towed to Napleton Hyundai in West Palm Beach. We have unfortunately had this happen before on our Hyundai Sonata, similar circumstances car lost all power while driving and would not restart. The Sonata turned out to have defective engine and was replaced at a different dealership under the class action, but we have had zero communication from Napleton Hyundai regarding the Santa Fe. We have provided everything that the dealer has requested, and not received any response from Napleton. We were told if the engine seized, engine is covered up to 150K miles and they are aware of the Santa Fe defect. But, we are stranded hours from home without a car and no one at the service department has called us back or informed us what are the next steps despite repeated requests from us to find out what is going on with the Santa Fe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537231August 8, 2023
ENGINE
please merge this additional information with Complaint Number: 11537141, submitted electronically to NHTSA on 8/8/2023, 12:54:24 PM earlier today. Napleton Hyundai of West Palm Beach finally confirmed moments ago that the engine on the 2016 Santa Fe is defective and did seize causing us to lose control of the vehicle, resulting in the engine shutting down and fail while we were driving with our family on the turnpike on 8/5/2023. We already submitted the requested documentation to the service department to show that we have maintained the vehicle and completed regular oil charges. We are now awaiting approval from Hyundai corporate to allow the dealer to repair the defective engine under warranty/per the class action. It is shocking to us that we have now had this experience with two separate Hyundai vehicles. We purchased the Santa Fe brand new and expect it to last. Our lives, the lives of our children were completely put at risk - and it is a miracle that there was no accident, no injuries, and no one died. We suffered stranded on the side of the road waiting for a tow for two hours while the vehicle reached 100 degrees with no safe place to seek refuge while tractor trailers and other cars passed us at high rates of speed; hoping that no one would hit our car and that we would survive. We hope that Hyundai will approve and complete the repairs quickly. At this time we are without a vehicle and were informed that Hyundai also has to approve a loaner or rental while the repairs are completed, we ask that Hyundai does so immediately. It is hard to believe that we had to have a near death experience for the defective engine to be addressed. At this point, we just ask that Hyundai please make the repairs quickly and grant us a loaner vehicle in the meantime.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe