Ford · Model Report
Showing safety data for the 1997 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE INSPECTION AT HALDEMAN FORD OF KUTZTOWN, INC. (15465 KUTZTOWN RD, KUTZTOWN, PA 19530, (610) 683-3553) THE MECHANIC DETERMINED THAT THE FRONT AND REAR SUBFRAME WAS SEVERELY CORRODED. AFTER HAVING AN EMISSIONS INSPECTION, THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 154,000.
No injuries · No fire · No crash
FORD RANGER 4X4 XLT 4.0L HAS HAD PROBLEMS FROM THE BEGINNING FRONT TIRES TWO OUT , FOG LIGHTS, AIR CONDITIONING, TRANSMISSION SHIFT POINTS , CHECK ENGINE LIGHT WHEN NEW AND TO THIS DAY GAS MILEAGE NOT AS STATED ON WINDOW STICKER ,ALSO WINDOWS MOTOR AND CONTROLS
No injuries · No fire · No crash
BELT SEPARATION ON 2 TIRES IN ONE MONTH TIME SPAN. FUSION TOURING 195 70R14 91T. THESE TIRES HAVE 8/32 TREAD REMAINING. FAILURES WERE FRONT RIGHT, THEN LEFT READ ONE MONTH LATER. CAUSED DIFFICULTY STEERING AS THE CAR WAS ALL OVER THE ROAD PLUS BUMPY RIDE. THE TIRES ARE VISIBLY BULGING BALOON. I FELT TIRE TEMP WITH MY HAND. UNIFORMLY WARM EXCEPT AT THE BULGE WHERE IT WAS SO HOT AS TO BURN MY HAND. WOULD NTSB LIKE ME TO SAVE A TIRE FOR EVALUATION? THIS SECOND TIRE FAILURE OCCURRED AT 70 MPH ON I-94 IN MICHIGAN WHEN A SUDDEN VIBRATION OCCURRED AND I OBSERVED THE LEFT REAR FENDER BOUNCING UP AND DOWN. I STOPPED TO INVESTIGATE AND FOUND THE BULGE AND HOT SPOT.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1997 FORD RANGER. UPON INSPECTION, IT WAS DISCOVERED THAT THE FUEL TANK WAS NOT SECURED AND WAS HANGING FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS CAUSED BY SEVERE RUSTING AND CORROSION OF THE SUBFRAME. THE FAILURE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 233,479. *TT
No injuries · No fire · No crash
EXCESSIVE RUST NOT CAUSED BY NORMAL WEAR AND TEAR, HAD SPARE TIRE CARRIER RUST OFF WHILE ON THE ROAD
No injuries · No fire · No crash