Ford F-450 Complaints

588 consumer complaints on file.

#11155173November 30, 2018
STRUCTURE:BODY
FORD F-450 2013 HORTON AMBULANCE HAD THE FUEL TANK FALL FROM THE FRAME ON TO THE ROAD ON EMERGENCY 911 CALL. FRAME HAS HUGH CRACK WITH RETAINING STRAPS. HAD TO TOW TO DEALERSHIP. WE HAVE 9 OF THESE EXTENDED CAB HORTON AMBULANCES WITH 7 HAVING CRACKS IN THE FRAME IN DANGER OF FALLING OFF. 2 ARE LEAKING DISEAL FUEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11102808June 20, 2018
POWER TRAIN:DRIVELINE:DRIVESHAFT
TL* THE CONTACT OWNS A 2017 FORD F-450. WHILE DRIVING AT HIGHWAY SPEEDS, THE VEHICLE SHOOK ABNORMALLY WITH A STRONG VIBRATION. THE CONTACT SLOWLY DECELERATED AS THE DRIVESHAFT FRACTURED OUTWARD FROM THE LEFT TO THE RIGHT SIDE. ALSO, THE TRANSMISSION HOUSING BECAME CRACKED AND THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO HIXSON FORD OF MONROE (6300 FRONTAGE RD, MONROE, LA 71202, (318) 388-3300) AND THE CONTACT WAS INFORMED THAT THE WARRANTY WOULD NOT COVER THE REPAIR BECAUSE THE VEHICLE HAD BEEN MODIFIED. THE DEALER DID NOT PROVIDE A SPECIFIC DIAGNOSIS TO REPAIR THE VEHICLE. THE VEHICLE WAS THEN TOWED TO JPS FORD (224 GAP FARMS ROAD, ARCADIA, LA 71001, (318) 263-2084) WHERE IT WAS DIAGNOSED THAT THE TRANSFER CASE NEEDED TO BE REPLACED AND A NEW DRIVE LINE NEEDED TO BE INSTALLED. THE MANUFACTURER AND HIXSON FORD INDICATED THAT THE VEHICLE WAS EXCLUDED FROM MANUFACTURER RECALL NUMBER: 17S108 CONCERNING THE EXCLUSION OF THE 450 AND 550 MODELS, ALTHOUGH THE CONTACT EXPERIENCED THE SAME FAILURES RELATED TO THE RECALL. THE MANUFACTURER REFUSED TO PROVIDE REPAIR ASSISTANCE AND THE VEHICLE WAS REPAIRED BY JPS FORD. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11098871May 30, 2018
WHEELS, STEERING
TL* THE CONTACT OWNS A 2018 FORD F-450. WHILE DRIVING 45 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO LEBANON FORD (770 COLUMBUS AVE, LEBANON, OH 45036, (513) 932-1010), BUT THE FAILURE COULD NOT BE DUPLICATED. THE CONTACT INFORMED THE DEALER AND THE MANUFACTURER SEVERAL TIMES OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 800. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11096659May 18, 2018
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
WHEN TRAVELING DOWN THE HIWAY,SOMETIMES YOU WILL LOSE POWER. YOU WILL FEEL A JERK. THE ENGINE IS STILL RUNNING BUT NO POWER TO THE WHEELS. PRETTY SCARY WHEN YOU ARE TRYING TO PASS A VEHICLE ON THE INTERSTATE. YOU TRY TO PULL OVER TO THE SIDE OF THE ROAD. YOU HAVE NO MEANS OF MOVEMENT. YOU CAN NOW TURN OFF THE VEHICLE AND PUT IT IN NEUTRAL AND RESTART THE ENGINE,YOU CAN NOW CONTINUE DOWN THE HIWAY UNTIL IT HAPPENS AGAIN. THIS HAS HAPPENED MULTIPLE TIMES. WE HAVE DRIVEN WITH OUR HORSE TRAILER DOWN TO ARIZONA 3 TIMES AND THIS HAS HAPPENED 3-4 TIMES EACH WAY. FORD DEALER WHERE PURCHASED HAS NO CLUE WHAT IS CAUSING THIS. THIS VEHICLE WAS PURCHASED BRAND NEW. WE HAVE HAD THIS PROBLEM SINCE NEW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11094101May 16, 2018
SERVICE BRAKES
WHILE DRIVING AT HIGHWAY SPEEDS WITH A TRAILER AND A LOAD CONNECTED TO THE TRUCK THE CHECK BRAKE SYSTEM MESSAGE SUDDENLY APPEARED WITHIN THE MESSAGE DISPLAY, AS WELL AS THE ABS LIGHT, TRACTION CONTROL LIGHT, AND THE PARKING BRAKE LIGHT. IMMEDIATELY WE ATTEMPTED TO SLOW DOWN AND PULL OFF TO THE SIDE OF THE ROAD. FORTUNATELY TRAFFIC WAS NOT TOO CONGESTED AROUND US AND WE WERE DRIVING ON A RELATIVELY FLAT ROAD AT THE TIME. THE VEHICLE HAD LOST VIRTUALLY ALL BRAKING POWER AND THE WE BASICALLY HAD TO COAST TO A COMPLETE STOP. THE VEHICLE IS A 2016 FORD F-450 SUPER DUTY CREW CAB TOWING A 25' GOOSENECK TRAILER WITH ONLY 71,000 MILES ON THE TRUCK. THIS COULD HAVE BEEN AN ABSOLUTE CATASTROPHE HAD WE BEEN HAULING A HEAVIER LOAD AND DRIVING DOWN A DOWNHILL GRADE! THIS SHOULD NOT HAPPEN WITHOUT ANY KIND OF WARNING WHATSOEVER! FORD NEEDS TO FIX THIS ISSUE BEFORE IT RESULTS IN DEATH OR SERIOUS INJURY! *DT*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11081176March 26, 2018
ENGINE, POWER TRAIN
BLOWN MOTOR. BAD LIFTERS AND VALVES. EXHAUST TEMPERATURE SENSOR CHECK ENGINE LIGHT. NO WARRANTY, I HAD TO REPLACE ENTIRE ENGINE AT MY COST OF $15,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11065259January 26, 2018
ELECTRICAL SYSTEM, VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2002 FORD F-450 SD. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE POWER WINDOWS FAILED TO GO UP AND DOWN. ALSO, THE DOME LIGHTING FAILED TO TURN ON AND THERE WAS AN ABNORMAL CLICKING NOISE. THE CONTACT CALLED A LOCAL DEALER (HARRISONBURG FORD, 3155 S MAIN ST, HARRISONBURG, VA 22801) AND WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11063372January 17, 2018
LATCHES/LOCKS/LINKAGES, STRUCTURE:BODY:DOOR
TL* THE CONTACT OWNS A 2007 FORD F-450. WHILE ATTEMPTING TO DRIVE THE VEHICLE, THE FRONT AND REAR DRIVER'S SIDE AND THE REAR PASSENGER DOOR FAILED TO LOCK WHEN THE TEMPERATURE GOT COLD. THE CONTACT CALLED SIEMANS FORD AT (269) 465-5344 (LOCATED AT 8961 RED ARROW HWY, BRIDGMAN, MI 49106) AND WAS INFORMED THAT THERE WAS NO REMEDY FOR THE VEHICLE DOORS. THE MANUFACTURER STATED THAT THEY KNEW ABOUT THE FAILURE AND THERE WAS NO REMEDY TO KEEP THE MOISTURE OUT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 7,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11032567October 9, 2017
WHEELS
THIS VEHICLE IS SHUTTLE BUS, TRANSPORT PASSENGERS FROM CHICAGO O'HARE AIRPORT TO FOUR POINTS HOTELS AND BACK 24/7. THIS VEHICLE IS OWNED BY FOUR POINTS HOTEL AT SCHILLER PARK, IL AND I WORK AS DRIVER. ON OCTOBER 8 2017 JUST AFTER 7 PM I WAS DRIVING THE BUS WITH PASSENGERS ON BOARD FROM THE AIRPORT TO THE HOTEL WHEN I HEARD NOISE FROM THE REAR I PULLED OVER AND STOPPED THE BUS. AFTER CHECKING I SAW THE REAR LEFT WHEEL IS COMING OFF. ALMOST ALL THE NUTS AND BOLTS ARE GONE BOLTS SNAPPED OFF WHILE THE BUS WAS IN MOTION. THE BUS WAS TOWED TO M&M AUTOMOTIVE INC. (708 456 6629) M&M MAINTAIN THE HOTELS BUS. THE SAME ( IDENTICAL) PROBLEM TOOK PLACE ON 11/20/2016, BUT THE REAR LEFT WHEEL COME OFF. AT THAT TIME IT WAS FORD F-450 2011 SHUTTLE BUS VIN ([XXX]) PHOTOS ARE AVAILABLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11032574October 9, 2017
WHEELS
THIS VEHICLE IS SHUTTLE BUS, TRANSPORT PASSENGERS FROM CHICAGO O'HARE AIRPORT TO FOUR POINTS HOTELS AND BACK 24/7. THIS VEHICLE IS OWNED BY FOUR POINTS HOTEL AT SCHILLER PARK, IL AND I WORK AS DRIVER. ON NOVEMBER 20 2016 JUST AFTER 9 PM I WAS DRIVING THE BUS SOUTH BOUND ON MANNHEIM RD AND WHEN BREAKING TO STOP AT THE TRAFFIC LIGHT AT LAWRENCE AVE THE LEFT REAR END HIT THE GROUND AND THE BUS DRAGGED UNTIL REACH COMPLETE STOP. THE REAR OUTER TIER COME OFF ALONG THE (WAS FOUND QUARTER MILE NORTH) SMALL FIRE STARTED , EVACUATED PASSENGERS. ALL BOLTS SNAPPED OFF THE REAR LEFT WHEEL AND THE OUTER TIRE CAME OFF. THE BUS WAS TOUGHED TO M&M AUTOMOTIVE INC. (708 456 6629) M&M MAINTAIN THE HOTELS BUS. PHOTOS ARE AVAILABLE THE BUS STILL AT THE HOTEL AND CAN BE USED? BUT IT HAS NOT BEEN USED FOR WHILE
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10995445June 16, 2017
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I HAVE RUNNING LIGHTS BUT NO TURN SIGNALS, BRAKE, OR FOUR WAY/EMERGENCY LIGHTS ON MY FIFTH WHEEL WHEN TOWING. THIS IS AT ANY TIME HOOKED UP TO THE TRUCK. OTHERWISE ON THE TRUCK ITSELF ALL LIGHTS WORK PROPERLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10984487May 9, 2017
UNKNOWN OR OTHER
THE TRUCK SURGES/ENGINE REVS. FORD DOES NOT KNOW WHY ITS HAPPENING, MULTIPLE PARTS HAVE BEEN CHANGED. SEVERAL FORD ENGINEERS HAVE BEEN INVOLVED WITH NO RESOLUTION. THE TRUCK HAS BEEN AT THE DEALER FOR 7 MONTHS, PARKED FOR THE LAST 1 MONTH WITH NO ACTIVITY. I BELIEVE IT IS A SAFETY ISSUE, DUE TO THE FACT THE TRUCK WILL SURGE FORWARD ON ITS OWN. FORD NOW SAYS IT NOT A WARRANTY ISSUE, BUT WE STILL ARE UNDER THE 5 YR / 60,000 MILE POWER TRAIN WARRANTY. THIS IS A RECOGNIZED PROBLEM FOR MOUNTAIN SUPPLY AND SERVICE AND WE ARE TRYING TO RESOLVE IT BEFORE SOMEONE GETS HURT, AND WE FEEL THAT IT IS NOT OUR RESPONSIBILITY AT THIS POINT, SINCE WE HAVE BROUGHT IT TO FORD'S ATTENTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10972100April 12, 2017
ENGINE
WHILE DRIVING AT 45 MPH ON A HIGHWAY THE ENGINE BLEW UP. FORD REPORTED THE PROBLEM WAS A FAULTY GLOW PLUG WHICH FELL INTO THE CYLINDER CAUSING THE CONNECTING ROD TO BREAK AND EXIT THE SIDE OF THE ENGINE BLOCK. FIRE ENSUED BUT WAS SHORT LIVED.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10957952March 1, 2017
STRUCTURE:BODY
ONE PEACE REAR WINDOW BLEW OUT DID NOT BREAK CAME OUT AROUND GASKET.WAS PARKED WHEN I NOTICED WET SETS AND FLOOR .POSSIBLE HAZARD WHILE MOVE DOWN THE ROAD.NO REASON FOR DISLOGING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10948703January 31, 2017
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2007 FORD F-450 SD. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART AFTER VARIOUS ATTEMPTS; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN, ADDITION THE CONTACT STATED THAT THERE WAS NO FUEL COMING THROUGH THE FUEL FILTER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 41,768.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10928366November 28, 2016
VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2008 FORD F-450 SD. WHILE DRIVING VARIOUS SPEEDS, THE DRIVER AND REAR PASSENGER WINDOWS INDEPENDENTLY ROLLED DOWN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10913839October 4, 2016
ENGINE, STEERING
ENTERED ON 10/04/2016 AT 2:45:07 PM EDT (GMT-0400) BY [email protected]: SENDER NAME: SENDER EMAIL: SUBJECT: FORD F-450 COOLING SYSTEM FAILURE AND ENGINE PROBLEMS COMMENTS: I PURCHASED THIS TRUCK NEW IN 2008 AND DROVE IT CROSS COUNTRY TOWING MY 5TH WHEEL. AT 4,544 MILES THE RADIATOR BLEW APART. (DRIVING HIGHWAY/TOWING) THIS WAS REPLACED UNDER WARRANTY AFTER FIGHTING WITH FORD. AT 6,065 MILES I HAD ANOTHER COOLING SYSTEM LEAK.(DRIVING LOCAL) THEY HAD TO REPLACE THE "SMALL" RADIATOR, THE "FUEL AND TURBO" COOLER. AT 21432 MILES THE POWER STEERING PUMP WENT AND HAD TO BE REPLACED.(DRIVING/TOWING/LOCAL) SHOP STATED THAT "FLUID WAS CONTAMINATED" (THIS TRUCK HAS ONLY BEEN SERVICED BY FORD) AT 22215 MILES I HAD TO HAVE THE LEFT REAR AXLE SEAL, BRAKE PADS AND LOWER CAC HOSE FOR TURBO REPLACED.( DRIVING HIGHWAY/TOWING) NOW AT 29,017 MILES THE RADIATOR TANKS HAVE SEPARATED FROM THE CORE AND NEED TO BE REPLACED AGAIN ALONG WITH THE CRANK SEAL AND ANOTHER POWER STEERING PUMP.( COMBINATION, HIGHWAY/LOCAL/TOWING? NOT TOWING) I HAVE CHECKED WITH FORD AND THEIR CUSTOMER SERVICE DEPARTMENT AND THEY REFUSE TO COVER ANY OF THIS, OR ANY PART, UNDER WARRANTY. I HAVE ALSO DONE RESEARCH ON THESE TRUCKS HAVING FOUND MANY OTHER OWNERS HAVING THE SAME COOLING SYSTEM ISSUES ALONG WITH OTHER ISSUES THAT FORD REFUSED TO COVER. PLEASE LOOK INTO THIS ISSUE, I THINK THEY NEED TO HAVE A RECALL ON THE COOLING SYSTEMS IN THEIR TRUCKS. THANK YOU FOR TAKING THE TIME TO READ THIS. I WOULD APPRECIATE A RESPONSE. CHECK EDMUNDS FORD F-450 SD TURBO DIESEL REVIEW, MULTIPLE COMPLAINTS OF COOLING SYSTEM FAILURE, ENGINE FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10907073September 16, 2016
FUEL/PROPULSION SYSTEM
6.7 DIESEL FUEL INJECTOR HOLD DOWN CLAMP BROKE AND FUEL INJECTOR BLEW OUT OF CYLINDER HEAD SPRAYING FUEL ALL OVER ENGINE COMPARTMENT. VEHICLE WAS ALWAYS SERVICED BY AUTHORIZED FORD DEALERS PER SCHEDULE. VEHICLE IN MOTION ON HIGHWAY. HAS 98,000 MILES ON IT, BUT IS A FEW MONTHS OVER THE 5 YEAR POWERTRAIN WARRANTY. LOCAL FORD TECH SAYS ITS A COMMON PROBLEM FOR THIS ENGINE, AND FORD HAS RECOGNIZED IT AND IS MAKING ENGINEERING CHANGES TO REPLACEMENT PARTS. THIS MAY BE, BUT HAVING A HIGH PRESSURE FUEL SYSTEM BLOW APART ON THE ROAD IS NOT COMMON FOR ME. AND OF COURSE NO WARRANTY COVERAGE SO I HAVE TO COVER ALL COSTS. I HAVE NO NOTIFICATION FROM ANYONE ABOUT RECALLS OR TSBS EFFECTING THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10883654July 8, 2016
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
TL* THE CONTACT OWNS A 2008 FORD F-450. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER THE CONTACT REMOVED AND RECONNECTED THE BATTERY. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EXHAUST FUEL RECIRCULATION VALVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE REMEDY FAILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10873258June 8, 2016
STEERING, SUSPENSION, UNKNOWN OR OTHER
I TOOK MY FORD F-450 LARIAT FOR ITS 60,000 MILES SERVICE. AFTER THE SERVICE WAS DONE, WHILE DRIVING IT HOME FROM THE FORD DEALERSHIP (AUTONATION FORD IN CORPUS CHRISTI, TX), ON THE FREEWAY AS SOON AS I GOT TO AROUND 50 MILES PER HOUR THE VEHICLE'S FRONT STARTED TO SHAKE/WOBBLE VERY VIOLENTLY. SPEEDING UP TO THE SPEED LIMIT (60 MPH) DID NOT HELP AND THE SHAKING GOT ACTUALLY WORST, I HAD TO STOP FOR THE SHAKING/WOBBLING TO STOP, THANKFULLY I WAS STILL ON THE RIGHT LANE AND THERE WAS A WIDE ENOUGH SHOULDER FOR ME TO STOP. AS SOON AS I RESTARTED AND GOT TO ABOUT 50 MPH THE VIOLENT SHAKING RESTARTED, AND I HAD TO STOP AGAIN FOR THIS SHAKING TO STOP. I EXITED THE FREEWAY AT THE FIRST EXIT AND DROVE BACK TO THE DEALER. ON THE WAY BACK THE VIOLENT SHAKING REPEATED AT LEAST 5 MORE TIMES, ONCE ON THE CITY STREET WITH 45 MPH SPEED LIMIT. WHEN I DESCRIBED THE SHAKING TO THE SERVICE ADVISER, HE SAID THEY HEARD ABOUT THIS, AND THEY CALL IT THE "DEATH WOBBLE". ACTUALLY ONE OF HIS MECHANIC EXPERIENCED IT BEFORE ON HIS TRUCK. NOW MY FORD F-450 IS IN SERVICE AGAIN AND THEY ARE TRYING TO FIGURE OUT HOW TO FIX MY "DEATH WOBBLE" PROBLEM. I FILED A COMPLAIN WITH FORD TODAY, BUT I DO NOT EXPECT MUCH TO HAPPEN. GIVEN THAT THE MECHANICS KNEW ABOUT THIS "DEATH WOBBLE", AND AFTER AN INTERNET SEARCH I FOUND THAT IS AFFECTING MANY OTHER FORD OWNERS (THERE ARE MANY GROUPS DESCRIBING THE SAME PROBLEM), I CONSIDER THAT FORD SHOULD HAVE RECALLED THESE VEHICLES, BEFORE SOMEBODY GETS HURT. STOPPING ON THE FREEWAY, WHILE SEMI-TRUCKS WERE BEHIND ME DRIVING AT FULL SPEED WAS THE SCARIEST EXPERIENCE, AND DID NOT THINK THAT I WILL GET AWAY WITHOUT BEING HIT BY OTHER TRUCKS. PLEASE TELL FORD TO FIX THE "DEATH WOBBLE". I DO NOT THINK THAT I SHOULD BE RESPONSIBLE FOR PAYING FOR THIS FIX.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-450