Ford F-150 Complaints

2,276 consumer complaints on file.

#11698234November 7, 2025
POWER TRAIN, BACK OVER PREVENTION, FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford F150. The contact received notifications of NHTSA Campaign Numbers: 23V896000 (Power Train), 25V315000 (Back Over Prevention), 25V455000 (Fuel system, Gasoline), and 25V729000 (Visibility). The contact stated that the part to do the recall repair of NHTSA Campaign Number: 23V896000(Power Train) was not yet available. The contact stated that the first month that the vehicle was purchased, the vehicle experienced failures. The contact stated that while driving at an undisclosed speed, there was an abnormal clicking and rattling sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken to CarMax and then to the dealer. The dealer confirmed that the rear-end axle hub bolt needed to be replaced. The vehicle remained at the dealer unrepaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 22,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698132November 7, 2025
POWER TRAIN
The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698120November 7, 2025
LATCHES/LOCKS/LINKAGES:HOOD:LATCH, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL, ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2024 Ford F-150. The contact stated that while driving on the highway, the hood unexpectedly opened. The instrument cluster was blank, and while it was raining, water entered the vehicle. Additionally, the contact stated that the doors failed to open as needed, and the vehicle was experiencing charging issues, causing the vehicle to fail to charge as needed. The contact deleted the charging time, and the vehicle started to charge and then stopped. The contact stated that vehicle would charge to 74 percent. The contact also stated that the passenger’s seat heater turned on independently. The message "Hands not on the Steering Wheel" was displayed. While driving 20 MPH, the collision avoidance warning light illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure during the initial visit. The vehicle was towed to an unknown local dealer, where it was determined that there was corrosion in the plugs, and the harness was replaced. Additionally, the contact stated while driving at an undisclosed speed, the TPMS alerted the driver that the PSI was at 7. The vehicle was taken to a tire center, which was unable to determine the cause of the failure but changed the tire. The contact stated that the taillight sensor had moisture. The manufacturer was contacted regarding a buy back, but the criteria was not met, and no assistance was provided. The failure mileage was approximately 2,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697616November 5, 2025
ELECTRICAL SYSTEM
The electronic dash flickers black. It comes back on but it is distracting while driving as it draws my attention to the dash instead of the road. I have took it to the dealership with no investigation because it does not happen with their test drive while in their possession. There is no TSB for this issue per the dealership. There should be some investigation as they could look for a loose cable or inquire with the manufacture of the component through Ford. Something is defective...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697591November 5, 2025
VISIBILITY:WINDSHIELD
The contact owns a 2021 Ford F-150. The contact stated that since purchasing the vehicle, there was an abnormal film-like substance visible inside the windshield. The substance obstructed the vision while driving and worsened while driving at night. The vehicle was taken back to the dealer where the vehicle was purchased and detailed the windshield in an effort to remove the film-like substance. Despite the independent mechanics best efforts, the film-like substance remained. The contact called a dealer and was informed that the diagnostic fee to inspect her vehicle would be $300 an hour, and the contact declined the service. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact back to the dealer for assistance. The failure mileage was approximately 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697396November 4, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Safety Defect: 4-6 second engine power loss/stalling while driving Life threating incident (recorded by Ford via phone call)Semi truck nearly collided with us as well as multiple other near misses road rage honking and obscene gestures all of which has my 13 year old son terrified to ride in the truck. First took it in 08/29/2025 @ 33,808 miles Second attempt 09/30/2025 still in shop at Gary Crossley Ford >30 days (unfixable) Ford Lemon Law Ford Case # CXHXXX 11/03/2025 Claim Manager Devin Dean Missouri Lemon Law MO AG CASE#XXX 11/04/2025 filrd today for **Mandatory Repurchase** Request: Investigate this safety defect and force immediate buy back. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697240November 3, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: ASSIST, VEHICLE SPEED CONTROL
On November 2nd, 2025 at approximately 6pm, in Houston, Texas, my 2025 Ford F‑150 with Ford BlueCruise engaged in Hands‑Free mode was traveling with traffic at about 70 mph on a major thoroughfare. Without driver input, the system rapidly reduced speed to about 50 mph after it appeared to misinterpret an unknown speed‑limit change. This sudden, uncommanded deceleration created a hazardous speed differential with surrounding traffic. I swiftly took over manual control to maintain traffic flow and prevent a potential rear‑end collision. No crash or injury occurred, but the behavior constitutes phantom braking and false speed‑limit recognition in an Advanced Driver Assistance System feature.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697214November 3, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed in traffic, the vehicle unexpectedly stalled. There was no warning light illuminated. The vehicle did not need to be restarted. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were unavailable for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 60,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697209November 3, 2025
POWER TRAIN
On Acceleration from a stop at approx. 35 miles per hour the rear wheels locked up causing the vehicle to come to an abrupt screeching stop. Almost rear ended by other vehicles causing great concern for safety. According to Ford the codes that kicked off are transmission shift solenoids. This is the second time this happened, fist time was backing out of a driveway, no codes and could not detect. I have fear this could happen at higher speeds and cause great harm.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697158November 3, 2025
POWER TRAIN
I have taken my truck to two seperate ford dealerships. Both acknowledging something strange on the transmission with the hesitations, the jerkiness and the hard shifting that happens. The first replaced the trans fluid and the filter. The second dealer replaced the valve body. During the 5th visit. They had me drive around their foreman to show him the problems. While he did feel the jerkiness and hesitations I feel, he said that its pretty much not bad enough yet and that the dealership would be held responsible for the cost of a new transmission if they replaced it and ford deemed it not needing to be replaced. Ford corp told me they wouldn't intervene with their attempt to fix it. The ford dealer sent me home and didn't fix anything the 5th time, even after explaining I felt harsh jerking on the way home to the point it felt like it was kicking me and a bunch of white smoke came out of the tailpipe. I even provided them a video of the white smoke when completely stopped after had been driving for 3 hours. The service on this truck is completely up to date and absolutely no reason at 41k miles I should have all these issue with this transmission. Ford has been resisting to replace this transmission but is willing to sell me a $4k extended warranty. Its getting old. This saga needs to end. Ford needs to just recall these transmissions already. This fight has been ongoing long enough! And ford corporate wont even help me. During the 3rd and 4th visit they replaced the valve body sent me home and the next day I had to bring it back after coming out of my work and transmission fluid being all over the ground right after they "fixed" it. They didnt give me a tow truck but rather made me drive almost 20 miles to their dealership. They claim the transmission pan warped but they just didnt screw the pan on correctly and ensure the pan seal was in good shape.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696975November 1, 2025
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
I purchased my vehicle in October 10th of 2025. I drove the vehicle home 2hrs away on the Friday. On Sunday the 12th I started the vehicle with a error of " Park brake fault Service now" I had the car taken to the nearest Ford dealership as it sat for 3 weeks. I was told the recall for the vehicle around this issue has been done twice so Pundmamm Ford the local dealer did not want to do it again. They ended up replacing the driver rear brake caliper bled the brakes and said this fixed it. They did not replace the harness as they said twice repaired was weird that Ford allowed this. I ended up paying for the repairs caused by this recall of over 1000.00 dollars. I have drove it now for two days and already the brake light engaged. Luckily it released and I was able to drive home. I have called Ford on this multiple times as well talked with supervisors and need escalation at this point.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696915November 1, 2025
POWER TRAIN
Recall for rear axel has not been repaired this is now overdue my ford dealer claims parts have not been provided by Ford Corporation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696770October 31, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). However, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696649October 30, 2025
EXTERIOR LIGHTING
Day time running lights have burned out which the only way to fix this problem is to replace them at over 2800.00 per light. There are hundreds of forums stating that the Daytime running lights stop working and there is no financially feasible fix without complete headlight replacement. This is a safety issue that should be resolved by ford
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696627October 30, 2025
EXTERIOR LIGHTING, VISIBILITY/WIPER
Both Running Daytime Lights have stopped working. This is a common issue with 2021 and up F150's. The issue results in a loss of visibility during daylight hours, creating a safety issue during daytime hours. This also seems to be negligence on the manufacturer's side. My understanding of the issue is a part of the headlight gets too hot under normal operating conditions and results in a melting or possible burning of a section of the headlight assembly. This is also a potential fire hazard from this area which is close to the engine also.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696585October 30, 2025
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I’ve now had two major safety issues with my 2024 Ford F-150 STX. 1. September 2025 – Loss of Acceleration While Driving I was driving north at about 40 mph when my truck suddenly stopped accelerating. It felt like it went into neutral on its own. I pressed the gas and nothing happened — the truck just started coasting. There were no alerts, no warning lights, and no explanation. I had to safely pull off the road while the truck was basically free-rolling. 2. Most Recent Incident – Emergency Brakes Slamming On in an Empty Parking Lot When I was leaving a facility recently, I was driving slowly through an empty Walgreens parking lot — no cars or obstacles anywhere around me. Out of nowhere, the truck’s emergency brakes slammed on extremely hard. It didn’t just happen once — the brakes locked up five times within about a minute while I was in Drive. There were zero warning messages on the dash each time. The jolts were so violent that my son flew forward and hit the seat in front of him. My right leg slammed into the dash, and the impact was so strong I ended up in the ER afterward with severe pain on my right side.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11696561October 30, 2025
EXTERIOR LIGHTING
The daytime running lights (DRLs) on my Ford F-150 failed and it is clear from online research that they are prone to failure. Yes, it is available for inspection upon request. The failure of the DRLs put safety at risk because they are important for visibility, protecting the driver and pedestrians. A dealership confirmed the issue. No, it has not been inspected by the manufacturer, police or any other 3rd party. No, there were no warning lamps, messages, or other symptoms prior to the failure. The issue was not noticed until I, the owner, was outside the vehicle and observed it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696457October 29, 2025
ENGINE, ELECTRICAL SYSTEM
the vehicle fails to accelerate when coming of a turn, the accelerator pedal does not respond for several seconds, then the vehicle lunges forward. Ford was contacted and no fix for this problem. I think this is very dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696450October 29, 2025
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696383October 29, 2025
EXTERIOR LIGHTING
The daytime running lights have failed one by one. Now they are all out of service. These are white LED fixtures built into the area around the headlight. These are not user-serviceable. The dealer says they are going out on all trucks due to a wiring issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150