Ford F-150 Complaints

2,276 consumer complaints on file.

#11722660March 7, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, SEAT BELTS
1. Electrical System Failure: While traveling on highway, alternator failed suddenly within 2 minutes of “service soon” and “check electrical system” warnings. Caused complete loss of motive power, electronic parking brake locked up while driving, loss of power steering, all gauges failed, transmission shifted into park while in motion. Battery was damaged (“fried”). Engine continued running for several minutes after stop without ability to shut off ignition. Incident documented by Ohio State Highway Patrol. 2. Seat Belt Issue: Driver-side seat belt interlock sticks in unlocked position, creating risk of failure to lock during a crash. 3. Electronic Parking Brake: Intermittently engages while vehicle is moving downhill to a stop (mostly at or below 5 mph). Parking brake light flashes three times then turns solid while in motion. Ford TSB indicates vehicle not eligible for related recall. 4. Infotainment System: Intermittently freezes, requiring forced reboot. Preceded by audio glitches, laggy dash computerized systems. 5. Transmission: Severe clunk and physical jolt when decelerating from ~30 mph to 8 mph. Also occurs during acceleration, particularly upshifts from 2nd to 3rd and 3rd to 4th gears, more pronounced when turning. 6. 4WD System: Intermittently fails to disengage from 4WD HI to 2WD HI. “Failure to shift” message appears several minutes after command to return to 2WD HI. 7. Front Differential/Axle: Previously, faulty front differential housing fractured due to system malfunction, causing intermittent loss of front driveline engagement in 4WD LO (250-500ms delay then re-engagement under throttle). Ford replaced front differential and axle under warranty after vehicle out of service for 2.5 months. Abbreviations: 4WD HI = 4-Wheel Drive High Range; 2WD HI = 2-Wheel Drive High Range; TSB = Technical Service Bulletin.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722589March 6, 2026
Carry Handle, Shell, Base
I have 4 of the Nuna revv car seats. 2 of these seats have malfunctioned and are stuck in the forward facing position and Will not rotate once the release handle is pressed. I contacted the manufacturer and they stated the seat is two years old and not covered under warranty. And I have an option to purchase a new seat for 400$. I feel like this is extremely unsafe. My son still rear faces and I was forced to put him forward facing on the drive home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722421March 6, 2026
POWER TRAIN
The contact owns a 2023 Ford F-150. The contact stated that while driving from a complete stop on several occasions, the vehicle was sluggish while depressing the accelerator pedal. The failure mostly occurred while driving between 10 and 20 MPH, and the vehicle jerked while driving 20 MPH. The check engine warning light was illuminated. The contact received a message for "Power Train Malfunction - Reduction" from the Mobile App. The vehicle was taken to the dealer to be diagnosed; however, the cause of the failure could not be determined. Upon investigating online, the contact associated the failure with TSB Number: 22-2428. The dealer advised the contact that the manufacturer would be notified of the failure. The contact was awaiting a call back from the dealer. The vehicle was not diagnosed or repaired. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722416March 6, 2026
POWER TRAIN
The contact owns a 2025 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722094March 4, 2026
SERVICE BRAKES, POWER TRAIN, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Giving an error of reverse assist and not available when starting truck and when placing truck in reverse. Have look up to seen if included in the recall that was issued 6 days ago. Have called dealership to confirm that not part of recall. The message just showed up last night. This truck should be included in the recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722078March 4, 2026
POWER TRAIN, WHEELS
Rear axle component failed on my 2023 Ford F-150 Lariat. Vehicle completely lost mobility and would not move. We were stranded on a dangerous freeway exit. A recall repair for issue was performed. A second failure of the axle was later discovered during tire service. This is a repeat failure of a major drivetrain component and raises significant safety concerns. Additionally, the first failure was very traumatic. We had just left the funeral home preparing for my 15 year old daughters funeral. The freeway exit it left us stranded at was unsafe to remain in the vehicle. In order to be safe, we had to go stand in a cemetery. Having this component fail just after a year of being fixed is a serious ongoing safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721965March 4, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
The contact owns a 2023 Ford F-150. The contact stated that while driving approximately 50 MPH and hauling a trailer, the rear brake lights failed to illuminate. There were several messages displayed related to the trailer connection and brake lights. The contact stated that while driving at an undisclosed speed, the trailer was difficult to control, and the display screen inside the vehicle was flashing off and on. The vehicle was driven back to a storage facility. While reversing and attempting to park the trailer, the message that the trailer was disconnected from the vehicle was displayed. The cause of the failure was not yet determined. The local dealer was contacted and informed that the VIN was not included in NHTSA Campaign Number: 26V104000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer was not yet contacted. The failure mileage was approximately 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721926March 4, 2026
POWER TRAIN
The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that while stopped at a red light, there was an abnormal popping sound coming from the vehicle while depressing the accelerator pedal. There was no warning light illuminated. The contact was forced to place the vehicle into 4WD which allowed the contact to drive the vehicle; however, there was an abnormal grinding and popping sound coming from the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and provided a case number. The vehicle was not repaired. The failure mileage was 74,653.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721907March 4, 2026
STRUCTURE:BODY
My 2021 Ford F-150 Lariat has a door latch defect that occurs in freezing or near-freezing temperatures. The failure occurs without warning in cold conditions, causing the door latch to freeze and not fully engage. When this happens, the door is able to freely swing open while the vehicle is in motion and also freely open when the vehicle is parked. This creates a serious safety hazard, including the risk of occupant ejection and loss of vehicle control. The vehicle has no aftermarket modifications and is maintained per manufacturer recommendations. The issue is temperature-dependent and has occurred on multiple occasions. Ford has issued recalls for similar door latch freezing defects on multiple other Ford vehicles and model years. Despite this, my vehicle has not been included, even though it exhibits the same failure mode. This defect presents a significant safety risk and should be investigated for potential recall inclusion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721863March 3, 2026
POWER TRAIN
Vehicle has been inspected by dealer and all I’ve gotten it’s a natural sound. Vehicle has been taken three times for same issue and nothing has been done. No accidents have occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721836March 3, 2026
POWER TRAIN
Shifter stuck in drive and blinking yellow D indicator light after stopping for a gate to open. Power cycle of vehicle did not resolve. Leaving vehicle stranded. No service lights engaged. A quick internet search shows this to be a known issue. Self-resolved after letting vehicle off for 30 minutes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721820March 3, 2026
VISIBILITY/WIPER
I have air bubbles in my windshield and back window
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721784March 3, 2026
POWER TRAIN
as of [1/26/26], Recall 23S65 Is not complete Ford’s repair order states the vehicle is NOT SAFE TO DRIVE and cannot be repaired due to parts unavailability. This is a warrantable, safety‑related defect with no remedy available, rendering the vehicle unusable. Fords inability to repair a known safety defect do to parts shortage. Parts are back ordered for 8-12 months. parts delay ,a safety recall, no repairs performed NHTSA Complaint — Vehicle Information •Year/Make/Model: 2022 Ford F 150 4WD SuperCrew •VIN: [XXX] •Mileage at issue: ~31,851 miles (as of 01/26/2026) Component/System : Power Train → Axle / Driveshaft (Rear Axle Half Shaft & Hub Assembly) Recall ID : Ford Recall 23S65 (rear axle half shaft & hub assembly replacement) Incident Description (Narrative): On January 26, 2026, I presented my vehicle to an authorized Ford dealer (Greenwood Ford, Hollister, CA) to have Safety Recall 23S65 remedied. The dealer generated a Repair Order stating: “RECALL 23S65 NOT COMPLETE. PARTS ARE NOT AVAILABLE. UNSAFE TO DRIVE.” The same document notes “8–12 months before parts are available.” Because of this, my vehicle has an open safety defect that Ford acknowledges but cannot repair for an extended period, and the dealer explicitly documented the vehicle as unsafe to drive. I am unable to safely use the vehicle and have been advised to wait months for parts with no firm ETA. I’m filing this complaint so NHTSA is aware of Ford’s recall remedy parts shortage and the associated prolonged safety risk to owners who cannot obtain a timely repair. Safety Risk / Symptoms Observed: •Manufacturer safety recall with no available remedy for an estimated 8–12 months. •Dealer’s written designation that the vehicle is “UNSAFE TO DRIVE.” •Loss of safe operation and use of the vehicle until the safety defect is remedied. Dates & Attempts: •01/26/2026: Repair Order issued; recall repair not completed due to parts unavailability; dealer notes “UNSAFE TO DRIVE.” •Ong INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721633March 3, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
Driving home last night looking in my rear view mirrors I noticed it looked dark at the back of my F150. Once home I noticed I had no rear running lights, no brake lights, no rear turn signals. Not sure related but 2 days earlier I noticed that about 5 indicator lights on my dashboard were activated all relating to driver assist lane changing, backing up assist, hill parking assist, traction control and so on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721508March 2, 2026
UNKNOWN OR OTHER, VEHICLE SPEED CONTROL
When parking the vehicle at Auto Zone, at a very slow speed, the vehicle suddenly accelerated. Without the accelerator being pressed, the vehicle suddenly accelerated on its own. Notes: Vehicle has One-pedal always activated. It is a new vehicle. Only has 3k miles. I was taken once to the shop for maintenance. Malfunction components: Maybe Speed related components and safety features. The airbag did not deploy and non of all the safety features the vehicle has did not activated. The safety risk was extremely serious. The vehicle went over the concrete parking stopper, tore it off, and then crashed into a concrete column at AutoZone. If anyone had been walking in front of the vehicle, the outcome could have been catastrophic. Despite the impact, the airbags did not deploy and none of the vehicle’s safety systems activated. After the incident, I went to the ER due to pain in both hands, shoulder pain, back pain, and pain in my feet. I was evaluated for these injuries as a precaution. A police incident was done. We have a number. Because it was on private. property there is not a report, but they gave us a police incident number. No warnings, symptoms prior to the incident. It was a dry day, not rain. The incident occurred last Saturday. We tried calling the Ford dealer to have the car towed, but we were unable to reach them. Because of safety concerns, we contacted a towing company and had the vehicle towed to our home instead. We plan to call Ford today, but wanted to report the incident first
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11721461March 2, 2026
POWER TRAIN
The contact owns a 2024 Ford F-150. The contact stated that while the vehicle was at an independent mechanic to be inspected, related to NHTSA Campaign Number: 25V512000 (POWER TRAIN). The vehicle was taken to a dealer, where it was diagnosed, and determined that the vehicle was damaged and was rubbing because the recall repair was not performed. The vehicle was not repaired. The contact reached out to several dealers to inquire about parts availability, but parts were not yet available, even though the recall remedy stated that parts were currently available for the repair. The manufacturer was notified of the failure. The failure mileage was 14,282.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721416March 2, 2026
UNKNOWN OR OTHER
The moonroof on our F-150 exploded going down the interstate. Nothing was hit and it sounded like a gunshot. The headliner remains intact with no damage and glass blew out at an upward angle. We submitted to Ford for a warranty claim but they denied it. Based on my research this is a known problem from Ford and they are not addressing it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721348March 2, 2026
POWER TRAIN
I had my 2021 F-150 into the local ford dealership not even a year ago due to a shifting issue. I was on the interstate and passing a car in the passing lane on the interstate and my truck shifted so hard I thought I lost something and then kinds lost power for a minute. The dealership ran a test on it, and it failed. It was some type of valve that was bad I guess ford and GM are having the issue. Now I am starting to have the same issue on now it is down around 4th to 3rd or 3rd to 2nd gear, but when it shifts once in a while it is a very hard shift and it scares the hell out of you. Now once in a while when I go to shift from drive to park or drive to reverse the shifter will not move. Like I said I am getting ready to get ahold of the dealership again and get it in to be looked at I am just waiting for winter to be over.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721317March 1, 2026
POWER TRAIN, WHEELS, SUSPENSION
The vibration occurs consistently above approximately 40 mph and becomes more pronounced at highway speeds. It is felt in: • Gas pedal • Underbody near shifter • Steering wheel • Seat Despite numerous repair attempts and replacement of major drivetrain components, the vibration has not been permanently resolved. Truck keeps throwing road force on brand new tires as well. Repairs and attempts have included: • Tire pressure corrections • Multiple tire balances and road force balancing • Replacement of all four tires • Subsequent rebalancing of the replacement tires after road force values continued to fluctuate • Additional tire replacement when road force variation repeatedly returned despite proper balancing • Replacement of both front hubs • Replacement of both front axles • Replacement of front steering knuckles • Replacement of front differential ring and pinion bearing kit • Replacement of right front axle • Replacement of transfer case • Replacement of front driveshaft • Diagnostic tire swapping from another vehicle for comparison At one point, test tires from another truck were installed to isolate the concern, which resulted in the vibration spreading further into the steering wheel and seat. The issue affects drivability and confidence in the vehicle at highway speeds. Current visit beginning January 7, 2026: Vehicle has remained at the dealership continuously with no return to me and no confirmed repair completion (now exceeding 40 consecutive days). The cumulative days out of service significantly exceed 30 days. Despite substantial drivetrain component replacement, the vibration concern persists. The persistent vibration affects normal use, drivability, and confidence in the vehicle at highway speeds. Persistent drivetrain vibration at highway speeds raises safety concerns. Repeated axle, differential, transfer case, and driveshaft replacements indicate unresolved mechanical instability.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721289March 1, 2026
UNKNOWN OR OTHER
I HAVE ONLY HAD MY 2022 FORD F150 XLT FOR ABOUT 2 MONTHS AND THE AC IS NOT WORKING. IT IS BLOWING HOT. I TOOK IT TO DEALERSHIP AND PAID $220 FOR A DIAGNOSTIC AND THEY SAID IT IS THE EVAPORATOR CORE. DEALERSHIP I BOUGHT IT FROM SAYS IT PASSED INSPECTION TEST BUT I'M NOT SURE HOW AND 1 MONTH AFTER I BOUGHT IT IT'S NOT WORKING. VERY DISAPPOINTING BEING I'VE ONLY HAD THE TRUCK A LITTLE OVER A MONTH. AND EVEN MORE DISAPPOINTING EVERYWHERE I LOOK ONLINE EVERYONE IS HAVING THIS SAME ISSUE AND FORD HAS NOT ISSUED A RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150