Ford · Model Report
Showing safety data for the 1997 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO SHAKE ABNORMALLY, THE CONTACT WAS UNABLE TO DRIVE IN 4 WHEEL DRIVE. THE CONTACT STATED THE CHECK GAUGE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE FRONT DRIVE SHAFT, THE CONTROL ARMS, THE FRONT OXYGEN SENSOR, AND THE FRONT AND REAR BRAKES NEEDING TO BE REPLACED. THE CONTROL ARMS WERE REPLACED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED IN HIS DRIVEWAY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HYDRAULIC FLUID WAS LEAKING DUE TO THE FAULTY CRUISE CONTROL SWITCH CAUSING THE FIRE. THE CONTACT MENTIONED THAT THE HYDRAULIC FLUID LEAKED OUT WHEN IT GETS WARM EVEN WHEN THE VEHICLE NOT RUNNING. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE VIN WAS NOT AVAILABLE. *BF
MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.
RUNNING ON THE HIGHWAY THE RIGHT AXLE OF THE DIFFERENTIAL BROKEOFF AND THE WHEEL CAME OFF WITH THE BRAKE CALIPER AND BRAKE HOSE AND BECAUSE OF THIS CAUSE LOOSE CONTROL AND CRASH .THE VEHICLE IS TOTAL LOSS.
THE DRIVERS SIDE SEATBELT WILL NOT ENGAGE TO THE LOCK POSITION.
No injuries · No fire · No crash