Ford · Model Report
Showing safety data for the 2002 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
My power steering and brakes went out as I was driving. I was making a turn in town, and I almost collided with another car at the intersection. I pushed the brakes as hard as I could, but it didn't slow down, the car just eventually rolled to a stop on its own. The exact cause is unknown, but it seems like it was a failure in the power steering pump. After turning off the van and turning it back on again a minute later, it started driving normally again.
No injuries · No fire · No crash
The contact owns a 2002 Ford E-150. The contact stated while driving at approximately 75 MPH, he smelled a burning odor in the passenger cabin. The contact stated that he turned the A/C on to help clear the cabin. The contact stated that he noticed smoke was being emitted from the driver's side rear tire and wheel well. The contact stated that the tire separated from the rim and the vehicle dropped to the road. The contact stated he had not noticed any warning lights. The contact stated that he managed to pull over and saw smoke emitted from the rotor and brake pads. The contact stated that the rim was almost destroyed. The contact observed that there was fluid leaking from the rotor and brake pads and had started to burst into flames. The contact stated that he was able to smother the flames with a blanket. The contact stated that he had the vehicle towed to an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 228,000.
IN A PARKING LOT, I WENT TO TURN LEFT, HEARD A LOUD CLUNK AND THE VAN JUST WENT STRAIGHT. LOST ALL STEERING CONTROL. LUCKILY THIS HAPPENED IN A PARKING LOT AND NOT ON THE ROAD AT HIGHER SPEED. IF THIS HAD OCCURRED AT SPEED, I WOULD HAVE HIT ONCOMING TRAFFIC , OR GONE OFF THE ROAD INTO WHO KNOWS WHAT. TWO SEPARATE MECHANICS HAVE DIAGNOSED A COMPLETE FRAME FAILURE WIHICH ALLOWED THE STEERING BOX TO DETACH FROM THE FRAME. THE FRAME IS NOT REPAIRABLE. IF THIS IS A COMMON PROBLEM WITH THE 2002 FORD E150 FRAME PEOPLE ARE GOING TO GET HURT OR KILLED!!!
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 FORD E-150. THE CONTACT STATED THAT THE FRAME EXPERIENCED SEVERE CORROSION. AS A RESULT, THE VEHICLE LOST STEERING ABILITY BECAUSE THE BOLTS CONNECTED TO THE GEAR BOX, WHICH WERE ALL CONNECTED TO THE FRAME, DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS TAKEN TO LES STUMPF FORD (3030 W COLLEGE AVE, APPLETON, WI) WHERE THE FAILURE WAS CONFIRMED; HOWEVER, NO FURTHER ASSISTANCE WAS OFFERED BECAUSE THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.
No injuries · No fire · No crash
SPARK PLUG BLEW OUT OF ENGINE BLOCK. I WAS GOING IN REVERSE WHEN THIS HAPPENED.
No injuries · No fire · No crash