Ford · Model Report
Showing safety data for the 1996 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
MY VEHICLE ACCORDING THE NHTSA HAS RECALL #09V399000 FOR THE BRAKE SYSTEM SPEED CONTROL WHICH CAN CATCH ON FIRE EVEN IN THE GARAGE WITH THE VEHICLE OFF. I ASKED FORD TO REPAIR THIS BECAUSE I JUST BOUGHT THIS VEHICLE AND THEY CLAIM THERE ARE NO RECALLS ON THIS VEHICLE, AND I KNOW THERE IS AND I KNOW THE RECALL HASN'T BEEN INSTALLED ON MY VEHICLE. ARE THEY SAYING THIS BECAUSE TIME RAN OUT TO HAVE THIS DONE BECAUSE I JUST BOUGHT THIS VEHICLE OR DO THEY JUST NOT WANT TO? THANKS FOR YOUR HELP. *JS
No injuries · No fire · No crash
VEHICLE WAS PARKED, AND UPON ENTERING NOTICED THE SMELL OF AN ELECTRICAL FIRE. STARTED THE VEHICLE, ODOMETER WAS INOPERABLE AND VEHICLE WOULD NOT SHIFT OUT OF PARK. UPON FURTHER INSPECTION, FOUND A BLOWN 15 AMP FUSE IN THE FUSE PANEL. REPLACED FUSE, ODOMETER CAME BACK ON AND VEHICLE SHIFTED OUT OF PARK. APPROXIMATELY 10 SECONDS LATER, THE SMELL OF BURNING WIRING WAS EVIDENT, AS WAS SMOKE FROM UNDER THE HOOD. PULLED THE FUSE BACK OUT, OPENED THE HOOD TO FIND THE BRAKE PRESSURE SWITCH ON FIRE, WHICH MELTED THE BRAKE FLUID RESERVOIR AS WELL AS THE BATTERY CASING ALSO. *TR
A CHROME COLOR GRILLE ABOUT 2.5 FEET WIDE AND 6" TALL FLEW OFF THE FRONT OF OUR 1996 F150 FORD VAN WHILE WE WERE DRIVING AT HIGHWAY SPEED. I NOTICED OTHER SIMILAR FORD VANS THAT HAVE ALSO LOST THE SAME FRONT GRILL PART. WE WERE GOING 55 MPH DOWN A 2 LANE HIGHWAY AND A LARGE TRUCK WAS GOING THE OTHER WAY. THE GUST OF AIR FROM THE PASSING TRUCK WAS SUFFICIENT TO TEAR OFF THE GRILL PART AND CAUSE IT TO FLY OVER THE TOP OF OUR VAN. *TR
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 1996 FORD E-150. WHENEVER THE CONTACT STARTS THE ENGINE AND DEPRESSES THE ACCELERATOR PEDAL, THE ENGINE BECOMES STUCK AT A HIGH RPM AND WILL NOT RETURN TO THE IDLE POSITION. THE FAILURE CAUSES THE VEHICLE TO EITHER SURGE FORWARD OR BACKWARDS DEPENDING ON WHAT GEAR IT IS IN AT THE TIME. THE ENGINE HAS TO BE TURNED OFF IN ORDER TO RESTORE THE VEHICLE TO A PROPER SPEED. IN ADDITION, THE BRAKES DO NOT HOLD OR STOP THE VEHICLE WHEN THEY ARE ENGAGED. THE FIRST TIME THIS FAILURE OCCURRED, THE VEHICLE CRASHED INTO A TREE AT 10 MPH. THERE WERE NO INJURIES; HOWEVER, THE REAR WINDOW WAS DAMAGED. THROUGH RESEARCH, THE CONTACT FOUND NUMEROUS ISSUES WITH THIS DEFECT ON THE SAME MAKE AND MODEL VEHICLES. THE VEHICLE WAS TAKEN TO A REPAIR SHOP TWICE. DURING THE FIRST VISIT, THE MECHANIC CLEANED OUT THE ENGINE, ENGINE THROTTLE, AND CABLES. THE FAILURE WAS CORRECTED FOR TWO MONTHS BEFORE IT RECURRED AGAIN. DURING THE SECOND VISIT, THE VEHICLE WAS TOWED TO THE SHOP AND THE MECHANIC CHECKED TO MAKE SURE THAT EVERYTHING WAS LUBRICATED PROPERLY. THE SHOP DID NOT GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE CONTACT BELIEVES THAT A RECALL SHOULD BE ISSUED. THE FAILURE MILEAGE WAS 150,000 AND CURRENT MILEAGE WAS 152,000.
1996 FORD E-150 SERPENTINE BELT, AIR CONDITIONING COMPRESSOR. ELECTRICAL SYSTEM, IGNITION MODULE REPLACED, ABS LIGHT ILLUMINATED WHEN BRAKES WERE APPLIED, TIE RODS REPLACED, FUEL PUMP REPLACED. *KB
No injuries · No fire · No crash